苯硝化工艺HAZOP分析的定量化研究

为提高危险化工工艺过程风险评估的准确性,通过工艺仿真模拟,研究工艺参数波动对生产装置安全性能的影响。以苯硝化工艺为例,采用危险与可操作性分析对该过程进行定性的风险评估;同时利用Aspen Plus建立苯硝化装置的模拟流程。结合HAZOP分析中偏差与模拟中硝化釜的流程变量之间的联系,以进料混酸的流量和1号硝化釜热负荷及出口温度为量化指标,观察混酸流量在正常操作点17.6 m3/h的±100%范围波动下1号硝化釜热负荷及出口温度的变化。研究结果表明,保持1号硝化釜温度为正常值,随着混酸流量的增大,硝化釜热负荷先增大后减小;保持硝化釜热负荷不变,随着混酸流量的增大,硝化釜温度先增大后减小。其中混酸流量值超过22.95 m3/h时,温度超过报警阈值60℃。     

Effects of operational factors on soluble microbial products in a carrier anaerobic ba ed reactor treating dilute wastewater

The effects of feed strength, hydraulic residence time （HRT）, and operational temperatures on soluble microbial product （SMP） production were investigated, to gain insights into the production mechanism. A carrier anaerobic baffled reactor （CABR） treating dilute wastewater was operated under a wide range of operational conditions, namely, feed strengths of 300-600 mg/L, HRTs of 9- 18 h, and temperatures of 10-28℃. Generally, SMP production increased with increasing feed strength and decreasing temperature. At high temperature （28℃）, SMP production increased with decreasing HRT. As the temperature was decreased to 18 and 10℃, the SMP production was at its peak for 12 h HRT. Therefore, temperature could be an important determinant of SMP production along with HRT. A higher SMP to soluble chemical oxygen demand （SCOD） ratio was found at high temperature and long HRT because of complete volatile fatty acid degradation. SMP accounted for 50%-75% of the SCOD in the last chamber of the CABR. As a secondary metabolite, some SMP could be consumed at lower feed strength.     

抗生素降解菌剂对猪粪堆肥腐熟和细菌群落演替的影响

接种抗生素降解菌可促进畜禽粪便中抗生素去除,但相关污染物降解菌对堆肥进程及土著微生物群落演替的影响研究甚少.分析一种以抗生素降解菌种为核心的复合微生物菌剂在猪粪抗生素去除中的作用,探究接种菌剂对猪粪堆肥理化进程以及细菌群落演替的影响.结果表明,抗生素降解菌剂接种处理猪粪中抗生素去除率达81.95%,与对照相比,其抗生素残留总量下降42.18%.在堆肥条件下,接种抗生素降解菌剂促进了猪粪堆肥升温,加速了堆体水分去除,降低了堆肥中氨气和硫化氢累积排放量,使得堆肥产物中氮磷钾总养分含量和萝卜种子发芽指数分别提高6.80%和68.33%,同时堆肥产物中稳定性有机质含量增加,纤维素和半纤维素等难分解物质含量下降.细菌群落结构分析指出,接种菌剂提高了堆肥中放线菌门和厚壁菌门细菌的相对丰度,其中与堆体升温正相关的嗜热菌丰度显著增加（P<0.01）,而致病细菌相对丰度下降.细菌群落共现网络分析表明,接种菌剂改变堆肥土著细菌群落互作模式,降低了细菌群落网络的复杂度和连通性,优化了有益细菌与其他菌群的生态关系,为建立新的和更加健康的堆肥细菌群落奠定了基础,可为抗生素降解菌剂在堆肥中的应用开发提供了科学依据.     

猪粪和羊粪与麦秆不同配比中温厌氧发酵研究

研究了猪粪和羊粪分别与麦秆不同配比中温(35℃)厌氧发酵对产气量、消化时间和最优C/N值的影响。结果表明,猪粪与麦秆在中温厌氧发酵时,所需的最优C/N值为21,且经141 d就可充分发酵,最大干物质累积产气量可达369.53 mL/g。羊粪与麦秆中温厌氧发酵时,所需的最优C/N值为24,且经96 d就可充分发酵,最大干物质累积产气量可达209 mL/g。猪粪秸秆中温厌氧发酵时易发生酸化,发酵前应通过预处理来减少酸化可能;而羊粪麦秆不易发生酸化。     

不同生物炭对猪粪堆肥过程中抗生素及抗生素抗性基因的削减规律研究

为探讨不同类型生物炭对猪粪堆肥过程中抗生素和抗生素抗性基因(ARGs)的削减规律,分别将玉米秸秆生物炭、竹炭和猪粪生物炭添加到猪粪中进行好氧堆肥,解析不同类型生物炭添加对猪粪堆肥过程中抗生素浓度和ARGs丰度的影响.研究发现,添加竹炭堆肥对抗生素的平均去除率最高(97％),其中对四环素类抗生素的去除率高达98％;添加玉...     

碳氮比对稻草和猪粪生物处理及厌氧消化的影响

以农业废弃物稻草和猪粪为发酵原料,首次采用纤维素降解复合菌系对稻草和猪粪混合物进行生物处理,通过考察不同碳氮比(25∶1、30∶1、35∶1和40∶1)条件下稻草和猪粪混合物生物预处理的发酵特征及后续的产甲烷能力,探讨了碳氮比对稻草和猪粪的协同生物预处理及厌氧消化效果的影响.结果表明,控制碳氮比为30∶1、料水比为11%时,稻草和猪粪混合物经纤维素降解复合菌系于55℃预处理30 h后其厌氧消化效果最佳.在此条件下,稻草和猪粪降解液中滤纸酶活和羧甲基纤维素酶酶活分别达到了2.18和2.31 IU,其失重率高达41.69%;随后经厌氧发酵后其甲烷产率和产甲烷速率分别可达318.14 m L·g-1(以VS计)和10.61 m L·d-1·g-1(以VS计),且总量为9.9 g的稻草和猪粪混合物的总甲烷产量可达1948 m L,上述结果相对于未经生物预处理的对照组均提高了38%.本研究结果可进一步为其它种类的农作物秸秆和畜禽粪便的高效资源化利用提供理论支撑,展现出了巨大的应用潜力.     

Concentrations of additive arsenic in Beijing pig feeds and the residues in pig manure

The swine industry in China has grown rapidly over last two decades. Great amount of pig manure is generated in China, which can be used as organic fertilizers on agricultural lands. Meanwhile, the organic arsenic compounds have been used as feed additives for swine disease control and weight improvement. Once the excessive additives are released in the environment, arsenic may compromise food safety and environmental quality. There is a growing public concern about the arsenic residues accumulation in pig manure, however, little work has been done to investigate the exact arsenic content in pig feed and the residues in manure in China This study investigates the concentrations of arsenic in 29 pig feed samples and 29 manure samples collected from eight pig farms in the Chaoyang district, Beijing city. The detected rate of arsenic in 29 couples of samples was 100%. The concentrations of arsenic in pig feeds and manures ranged from 0.15 to 37.8 mg/kg and 0.42 to 119.0 mg/kg, respectively. The result showed that arsenic concentration in pig manure will be greatly elevated when the arsenic in pig feed was largely increased. The loading rates of pig manure in fourteen Beijing counties and districts were in the range of 2.7–57.2 t/ha yr. Accordingly, the potential soil arsenic increase rates resulting from land application of pig manure might range between 11.8 and 78.9 μg/kg yr. Despite these findings, it is too early to draw the conclusion that arsenic pollution from pig manure is serious in Beijing farmland; therefore, longitudinal studies about the chemical form transformation and the environmental behaviors of pig manure arsenic are required in order to come up with more definitive conclusions.     

Macroscale and microscale analysis of Anammox in anaerobic rotating biological contactor

Inoculated with conventional anaerobic activated sludge, the Anammox process was successfully developed in an anaerobic rotating biological contactor (AnRBC) fed with a low ratio of C/N synthetic wastewater. Operated in a single point feed mode, the AnRBC removed 92.1% (n = 126) of the influent N at the highest surface load of 12 g/(m².day). The biomass increased by 25% and 17.1 g/(m².day) of maximum N removal surface load was achieved by elevating flow rate with another feed point. Fluorescence in situ hybridization and polymerase chain reaction analysis indicated that the Anammox genus Candidatus Kuenenia stuttgartiensis dominated the community. Both Anammox and denitrifying activity were detected in biofilm by the application of microelectrodes. In the outer layer of the biofilm (0-2500 μupm), nitrite and ammonium consumed simultaneously in a ratio of 1.12/1, revealing the occurrence of Anammox. In the inner layer (> 2500 μupm), a decrease of nitrate was caused by denitrification in the absence of nitrite and ammonium.     

不同肥料施用对设施菠菜地NH3挥发和N2O排放的影响

以湖南设施菠菜地为研究对象,采用通气法和静态箱-气相色谱法研究了设施菠菜生长季施用工厂化堆肥(SC)、农民传统堆肥(SS)和单施化肥(FC)对土壤NH_3和N_2O排放的影响.结果表明在同等施氮水平下,与FC相比,SC处理能减少NH_3和N_2O排放量,分别减少52.9%和95.12%(P0.01);SS处理则增加NH_3挥发量24.8%,减少N_2O排放量48.8%.不同处理NH_3损失率分别为SS(10.97%)FC(4.19%)SC(2.74%);N_2O排放系数分别为FC(4.50%)SC(2.21%)SS(0.60%);与FC处理相比,SC处理条件下菠菜产量和作物吸氮量分别降低19.61%和13.20%,差异不显著;SS处理则显著降低27.9%和40.0%(P0.05).在该地区冬季设施菠菜田中,影响NH_3和N_2O排放的主要因素为土壤水分,环境温度不是此研究中影响气体排放的主要因素.因此,畜禽养殖固体废弃物经过不同处理后作为有机肥施入菠菜田,SC处理的菠菜可保证产量的同时,减少NH_3挥发和N_2O排放损失.     

不同配比农业废物堆肥过程中堆肥的阴阳离子和大分子对种子发芽的影响

为揭示不同配比农业废物堆肥过程中阴阳离子和大分子对植物毒性的影响机理，开展了以鸡粪和猪粪为主料，稻草秸秆为辅料的条垛堆肥试验，设置的试验处理包括：等质量的鸡粪+稻草秸秆+包菜（1∶1∶1）处理（T1）、鸡粪+稻草秸秆（1∶1）处理（T2）、大量猪粪+少量稻草秸秆（85∶15）处理（T3）.测定了各处理的堆温、堆肥的水溶性无机阴阳离子和有机大分子变化，以及对大白菜（Brassica rapa L.）和水堇（Lepidium sativum. L.）种子发芽指数（Germination Index， GI）等指标变化的影响.试验结果表明，T3处理堆肥的高温（>55 ℃）持续期最长，杀灭病原微生物和杂草种子的能力最好，且其堆肥的Cl^-、SO42-、K⁺、Na⁺、Ca²⁺和Mg²⁺浓度最低；T2处理堆肥的NH4+ 浓度最低.T1和T2处理堆肥过程中堆肥的脂肪烃可转化为稳定的芳香烃.T3处理堆肥对大白菜和水堇的种子发芽指数大于80%.堆肥中抑制种子发芽的阴阳离子及大分子浓度分别为：Ca²⁺浓度>0.98 mmol·L^-1，Mg²⁺浓度>0.92 mmol·L^-1，NH4+浓度均>5.75 mmol·L^-1，芳香C/多糖比值>0.33，羧基C/多糖比值>0.30.堆肥中脂肪族大分子增加、多糖类大分子减少可抑制种子发芽.综上所述，猪粪与稻草秸秆的质量配比为85∶15、初始C/N比为25、初始水分含量为60%、 堆肥期周为35 d是条垛式堆肥处理猪粪和稻草秸秆的最佳工艺参数.大白菜比水堇种子更能准确反映农业废物堆肥的植物毒性.本研究可为优化不同畜禽粪便与农作物秸秆的条垛堆肥工艺参数、减少土地利用的风险提供重要的决策支持.