沉降速率作为选择压对好氧颗粒污泥性质影响

在序批式反应器中以普通活性污泥驯化而得的好氧颗粒污泥为接种污泥,葡萄糖为碳源,研究作为选择压的沉降速率对好氧颗粒污泥性质的影响。结果表明:作为选择压的沉降速率与反应器中SV值和MLSS成反比关系;在沉降速率变化过程中,污泥龄、耗氧速率、胞外多聚物和COD去除率均产生变化。在本试验条件下,改变沉降速率,能改变反应器中生物量的洗出量并在一定程度上影响微生物群体的组成,从而影响活性的生物学性能;但生物相的改变限度在一定范围内,存在着动态平衡。污泥龄的波动与不同沉降速率下反应器中污泥中的胞外多聚物含量的变化有关。大量的胞外多聚物在颗粒污泥表面形成粘液层,对颗粒污泥形成保护。不同沉降速率下颗粒污泥的的胞外多聚物发生变化,进而影响颗粒污泥的稳定性。     

Hydraulic characteristics of an anaerobic baffled reactor as onsite wastewater treatment system

The feasibility of using anaerobic baffled reactor(ABR)as onsite wastewater treatment system was discussed.The ABR consisted of one sedimentation chamber and three up-flow chambers in series was experimented under different peak flow factors(PFF of 1 to 6),superficial gas velocities(between 0.6 and 3.1 cm/hr)and hydraulic retention times(HRT)(24,36 and 48 hr).Residence time distribution(RTD)analyses were carried out to investigate the hydraulic characteristics of the ABR.It was found that the PFF resulted in hydraulic dead space.The dead space did not exceed 13% at PFF of 1,2 and 4 while there was 2-fold increase(26%)at PFF of 6.Superficial gas velocities did not result in more(biological)dead space.The mixing pattern of ABR tended to be a completelymixed reactor when PFF increased.Superficial gas velocities did not affect mixing pattern.The effects of PFF on mixing pattern could be minimized by higher HRT(48 hr).The tank-in-series(TIS)model(N=4)was suitable to describe the hydraulic behaviour of the studied system.The HRT of 48 hr was able to maintain the mixing pattern under different flow patterns,introducing satisfactory hydraulic efficiency.Chemical oxygen demand(COD)and total suspended solids(TSS)removals under all flow patterns were achieved more than 85% and 90%,respectively.The standard deviation of effluent COD and TSS concentration did not exceed 15 mg/L.     

中空纤维膜生物反应器处理生活污水的特性

中空纤维膜生物反应器生活污水处理特性的试验研究结果表明：Ｄ ＨＲＴ为１．５ｈ,ＣＯＤ容积负荷为５．７６ｋｇ／（ｍ＾３·ｄ）条件下,均可实现９０％以上的ＣＯＤ去除率;对ＮＨ３－Ｎ的去除率可稳定在９０％以上,高ＭＬＳＳ浓度８０００－１００００ｍｇ·Ｌ）提供了内部厌氧环境,使膜生物反应器的Ｔ－Ｎ去除率可达５０－６０％,中空纤维生物反应器处理高效,不受冲击负荷影响,操作管理方便,其生活物反应器体积比常规生     

Identical full-scale biogas-lift reactors (BLRs) with anaerobic granular sludge and residual activated sludge for brewery wastewater treatment and kinetic modeling

Two identical full-scale biogas-lift reactors treating brewery wastewater were inoculated with different types of sludge to compare their operational conditions, sludge characteristics, and kinetic models at a mesophilic temperature. One reactor （R1） started up with anaerobic granular sludge in 12 weeks and obtained a continuously average organic loading rate （OLR） of 7.4 kg chemical oxygen demand （COD）/（m3.day）, COD removal efficiency of 80%, and effluent COD of 450 mg/L. The other reactor （R2） started up with residual activated sludge in 30 weeks and granulation accomplished when the reactor reached an average OLR of 8.3 kg COD/（m^3·day）, COD removal efficiency of 90%, and effluent COD of 240 mg/L. Differences in sludge characteristics,biogas compositions, and biogas- lift processes may be accounted for the superior efficiency of the treatment performance of R2 over R1. Grau second-order and modified StoverKincannon models based on influent and effluent concentrations as well as hydraulic retention time were successfully used to develop kinetic parameters of the experimental data with high correlation coefficients （R2 〉 0.95）, which further showed that R2 had higher treatment performance than R1. These results demonstrated that residual activated sludge could be used effectively instead of anaerobic granular sludge despite the need for a longer time.     

高浓度有机废水二相厌氧消化过程特性研究

以填充床生物膜酸化反应器与上流式污泥床反应器（UASB）甲烷化反应器组成的二相厌氧消化装置处理高浓度啤酒废水或合成废水,最大处理能力为32～35kgCOD/d·m³。提出了二相工艺高负荷运行时最低必需酸化率的概念。进水浓度5000mgCOD/L,容积负荷30kgCOD/d·m³时,最低酸化率为28％。对主要操作参数的灵敏度分析表明,操作负荷、酸化率和进水碱度是影响COD去除率的主要操作参数。对二相厌氧消化系统中影响反应器内微生物群系的生态平衡、微生物本征活性和反应器宏观行为的主要因素进行了分类和综合讨论。     

基于氨氮,硝氮及乙酸条件下Anammox菌的培养

为探讨Anammox菌在氨氮、硝氮及乙酸条件下的富集特性,采用某城市污水处理厂A²/O系统中的生物填料作为MBBR的载体直接启动并运行.结果表明,在NH₄⁺-N、NO₃^--N及乙酸为基质的培养条件下,Anammox菌可在部分反硝化和厌氧氨氧化协同作用下快速富集.经过130d的富集培养,MBBR处理负荷（以N计）达到920.79mg/（m²·d）,Anammox活性（以NH₄⁺-N计）达到3 018.19mg/（m²·d）.高通量结果显示,经富集培养后,Ca.Brocadia占比从0.89%增至27.80%,为Anammox菌的主导菌属;Thauera占比从0.01%增至6.75%,Flavobacterium占比从0.29%增至11.72%,为部分反硝化菌的主导菌属.     

利用氢基质生物膜反应器去除水中砷酸盐

利用氢基质生物膜反应器(Hydrogen-based membrane biofilm reactor,MBfR)研究了NO_3~--N负荷、SO_4~(2-)负荷、As(Ⅴ)负荷、氢分压对水中砷去除效果的影响.结果表明,随着NO_3~--N进水负荷的增加,As(Ⅴ)和SO_4~(2-)还原受到明显抑制,系统产生As(Ⅲ)和NO_2~-的积累;随着SO_4~(2-)进水负荷的增加,反应器内总砷去除率由78.6%(25 mg·L-1SO_4~(2-))降低至1.1%(200 mg·L~(-1)SO_4~(2-)),而此时NO_3~--N的去除基本不受影响.同时,随着进水As(Ⅴ)负荷从0.25 mg·L~(-1)增至2 mg·L~(-1),出水SO_4~(2-)浓度明显升高,反应器内总砷去除率从70.0%降低至47.3%,而此时NO_3~--N的去除基本不受影响;当氢分压低于0.06 MPa时,提高氢分压可降低出水As(Ⅴ)浓度,当氢分压高于0.06 MPa后便不再是控制因素.由于体系中氢自养还原微生物会优先利用NO_3~--N和SO_4~(2-)作为电子受体,因此,为了保证As(Ⅴ)的高效还原去除,必须控制氢分压在0.05~0.07 MPa之间.     

固定化微生物流化床反应器的研究进展

综述了固定化微生物流化床反应器的发展及应用等,包括生物流化床处理废水的特点及发展过程;固定化微生物反应器的几种类型及特点;在工业生产和废水处理方面的应用;影响固定化微生物流化床反应器设计和操作的因素,固定提出了固定化微生物流化床反应器今后的研究方向。     

微气泡曝气生物膜反应器同步硝化反硝化研究

同步硝化反硝化(SND)是废水处理中的新型生物脱氮工艺,和传统生物脱氮工艺相比具有显著的应用优势.本研究采用微气泡曝气固定床生物膜反应器,研究了SND过程中污染物去除效果并检测了生物膜功能菌群的变化情况.结果表明,在微气泡曝气固定床生物膜反应器内可以实现同步硝化反硝化,通过提高进水COD负荷和C∶N比,降低溶解氧(DO)浓度,同时增加填料床层孔隙率,可以改善SND效果.当进水COD负荷和总氮(TN)负荷为0.86 kg·(m3·d)-1和0.10 kg·(m3·d)-1,且填料床层孔隙率为81%时,COD和TN的去除率分别为97.6%和70.2%,实现了COD和TN的同步高效去除;同时,微气泡曝气对氧传质的强化作用使得氧利用率高达91.8%.此外,生物膜活性和硝化及反硝化功能菌群的变化,与反应器COD、氨氮和TN去除能力的变化基本一致.     

膜序批式间歇反应器的膜污染特性及控制

采取厌-好氧交替运行、实验室人工配水的方式,连续运行300 d,研究膜序批式间歇反应器运行过程的膜污染特性及其控制.结果表明,在运行初期的75 d内,污泥处于絮体状,SVI值64.6～110.6 　mL·g^-1,膜污染呈快速指数增长趋势,TMP平均增长速率为0.309　kPa·d^-1,膜阻力变化在0.393×10¹¹～1.298×10¹¹ m^-1·d^-1之间,比膜通量从4.4 　L·(m²·h·kPa)^-1下降为0.52 　L·(m²·h·kPa)^-1,75　d时的临界膜通量为20 　L·(m²·h)^-1.从75～120　d对系统进行了调控,反应器培养出好氧颗粒污泥,SVI值逐渐下降,从170　d开始,SVI一直保持在40 　mL·g^-1左右,污泥粒径逐渐增大,220　d时污泥粒径分布大多在500～1 000　μm.120～300　d运行过程中的膜污染呈缓慢增长趋势,TMP平均增长率仅为0.062 　kPa·d^-1,膜阻力变化率在0.291×10¹¹～0.404×10¹¹m^-1·d^-1,比膜通量从4.4 　L·(m²·h·kPa)^-1下降为1.4 　L·(m²·h·kPa)^-1,220 d时的临界膜通量为40 　L·(m²·h)^-1.这些数据表明好氧颗粒污泥的培养对减缓膜污染发生具有极大作用.曝气强度为100 m³·(m²·h)^-1时,比膜通量最大,曝气强度为69 m³·(m²·h)^-1时,膜污染速率最小.