基于设备网(DeviceNet)总线技术的矿井瓦斯传感器的设计

介绍瓦斯传感器的国内外研究现状,给出以设备网(DeviceNet)总线构成的瓦斯传感器检测网络结构。简要分析了DeviceNet总线协议特点以及其关键技术,提出具有DeviceNet总线规范的矿井瓦斯传感器的设计及实现方案。硬件电路主要由信号调理电路、数字信号处理器,以及能实现DeviceNet网络通信的接口电路构成,用对象建模的方法构建了矿井瓦斯传感器的对象模型,并用模块化编程技术实现了矿井瓦斯传感器作为一个网络从设备的应用层的软件设计。该传感器作为从设备和带有PCI-CAN网卡的计算机组成主/从连接网络,能对多个矿井瓦斯传感器的数据实现远距离的控制。     

钠盐量影响下DD6单晶高温合金的高温热腐蚀规律研究

目的 开展镍基单晶高温合金DD6在950 ℃下的热盐腐蚀试验(95%Na2SO4+5%NaCl)，探明涂盐量和涂盐方式(周期涂盐和单次涂盐)对DD6高温热腐蚀的影响规律和机理。方法 结合扫描电子显微镜、X射线能量色散谱、X射线衍射等设备，对不同涂盐量及涂盐方式下DD6的表面及横截面形貌进行观察分析，分析不同涂盐量和涂盐方式下DD6的高温热腐蚀机理。结果 DD6在950 ℃下主要发生碱性熔融热腐蚀，同时伴随氧化、硫化和氯化等过程。高温热腐蚀使得DD6合金表面生成的保护性氧化膜被熔融态的腐蚀介质破坏，导致O、S、Cl等外部元素通过氧化膜的缺陷进入DD6基体中，在合金的亚表面发生内氧化、内硫化以及内氯化反应，横截面上出现明显的腐蚀层，其主要由氧化物以及硫化物组成。随着热腐蚀的进行，DD6表面物质发生了剥蚀，沉积盐量的增加导致剥蚀现象越加严重，合金内部致密的组织结构也被破坏，横截面上出现了大量孔洞、裂纹等缺陷。在相同涂盐量下，周期涂盐法使得DD6的腐蚀程度高于单次涂盐法。结论 DD6高温热腐蚀行为与涂盐量及涂盐方式密切相关，相同涂盐方式下，涂盐量越大，DD6热腐蚀更加严重。涂盐量一定时，周期涂盐法使得DD6的热腐蚀剧烈程度大于单次涂盐法，且DD6在上述热腐蚀条件下均发生剥蚀破坏。     

联苯代谢对微生物的生长胁迫及分裂抑制

以联苯/多氯联苯降解菌株R04（Rhodococcus sp.R04）和几种模式微生物为研究对象，利用高效液相色谱、荧光显微镜、扫描电子显微镜等分析微生物在联苯及其代谢物培养条件下细胞分裂和形态的变化.结果表明联苯及其代谢产物对红球菌R04和几种模式微生物细胞的分裂有抑制作用，并对部分微生物形态有影响.与前体-联苯及其代谢产物2-羟基-6-酮基-6-苯基-2，4-己二烯酸相比，2，3-二羟基联苯对G⁺、G^-细菌，或是酵母细胞分裂都有较强的抑制和形态的改变.2，3-二羟基联苯导致R.R04和缺陷型R.R04细胞形成不完整隔膜的比例增加；造成96.4%的大肠杆菌BL21细胞表面凹陷，胞质内容物流失，菌体体积缩小；导致枯草芽孢杆菌89.6%的细胞体积明显缩小；导致金黄色葡萄球菌基本没有细胞能形成完整的分裂隔膜；导致红酵母细胞能进行出芽生殖的比例从64.2%降低到19.3%，但对其细胞形态无明显改变.联苯代谢物2，3-二羟基联苯对红球菌R04及其它微生物细胞分裂和增殖的抑制作用比其前体-联苯强，建议在研究环境化合物与微生物互作时，应考虑环境化合物代谢的毒性效应.     

Retrieval of refractive index of ultrafine single particle using hygroscopic growth factor obtained by high sensitive surface plasmon resonance microscopy

When exposed to different relative humidities (RHs), the optical properties of atmospheric aerosols will change because of changes in the aerosol particle size and complex refractive index (RI), which will affect haze formation and global climate change. The potential contributions of ultrafine particles to the atmospheric optical characteristics and to haze spreading cannot be ignored because of their high particle number concentrations and strong diffusibility; measurement of the optical properties of wet ultrafine particles is thus highly important for environmental assessment. Therefore, a surface plasmon resonance microscopy with azimuthal rotation illumination (SPRM-ARI) system is designed to determine the RIs of single particle aerosols with diameters of less than 100 nm in the hygroscopic growth process. Measurements are taken using mixed single particles with different mass ratios. The RIs of mixed single aerosols at different RHs are retrieved by measuring the scattering light intensity using the SPRM-ARI system and almost all the RIs of the bicomponent particles with different mass ratios decrease with increasing water content under high RH conditions. Finally, for each of the bicomponent particles, the maximum standard deviations for the retrieved RI values are only $2.06\times {10}^{-3}$, $3.08\times {10}^{-3}$ and $3.83\times {10}^{-3}$, corresponding to the NaCl and NaNO₃ bicomponent particles with a 3:1 mass ratio at 76.0% RH, the NaCl and glucose particles with a 1:3 mass ratio at 89.0% RH, and the NaCl and OA particles with a 1:1 mass ratio at 78.0% RH, respectively; these results indicate that the high-sensitivity SPRM-ARI system can measure the RI effectively and accurately.     

The Kinetics of Interesterfication on Waste Cooking Oil (Sunflower Oil) for the Production of Fatty Acid Alkyl Esters using a Whole Cell Biocatalyst (Rhizopus oryzae) and Pure Lipase Enzyme

Recent research and technology have provided promising outcomes to rely on biodiesel as the alternative and conventional source of fuel. The use of renewable sources constitutes the main stream of research. Waste Cooking Oil (WCO) was used for biodiesel production in this study. Lipase enzyme producing fungi Rhizopus oryzae 262 and commercially available pure lipase enzyme were used for comparative study in the production of FAAE. The whole cell biocatalyst and pure enzyme were immobilized using calcium alginate beads. It was prepared by optimizing with different molar ratios of calcium chloride and different percent sodium alginate. Entrapment immobilization was done for whole cell biocatalyst. PE was also immobilized by entrapment for the transesterification reaction. Four different solvents methanol, ethanol, n-propanol, n-butanol were used as the acyl acceptors. The reaction parameters like temperature, molar ratio, reaction time, and amount of enzyme to be used were also optimized for methanol alone. The same parameters were adopted for the other acyl acceptors too. Among the different acyl acceptors, methanol whose reaction parameters were optimized showed maximum conversion of triglycerides to FAAE - 94% with PE and 84% with WCB. On the whole, PE showed better catalytic converting ability with all the acyl acceptor compared to WCB, further study, it was observed that three consecutive and reversible reactions occurred in the interesterification of triglycerides. So, a kinetic model based on Michaelis-Menten equation with competitive substrate inhibition was used to find the maximum reaction rate V_i for the four solvents using pure enzyme and WCB.     

双室微生物燃料电池处含银废水的产电性研究

以剩余污泥为阳极底,糖蜜废水为基质,Ag Cl废水为阴极电子受体,构建了双室微生物燃料电池(Two-chamber Microbial Fuel Cell,简称MFCs),并研究了电池的产电特性、库仑效率及金属去除率.结果表明:Ag+不仅可以作为阴极电子受体,而且还能稳定产电,外电阻为1000Ω时,获得的最大电压为514.5 m V,最大功率密度为65.82 m W·m-2.在阴极实现了对废水中Ag+的去除,最大去除率可达71.6%,而且Ag+浓度为2000 mg·L-1时,回收金属银单质质量为197.66 g.在阳极对废水的处理效果也很显著,库仑效率最高为2.66%,COD去除率最大为81.22%.     

Influence of hypothyroidism on oxidative stress,c-Fos expression,cell cycle,and apoptosis in rats testes

The molecular basis of male reproduction for cross-regulation between androgen and thyroid hormone axes is still rudimentary. This study aims to define a possible mechanism of hypothyroidism-induced reproductive influence with respect to sex hormone, mineral, sperm motility, oxidative stress, c-Fos expression, cell cycle, and apoptosis in rat testes. The Wistar rats were randomly divided into control group (NS) and hypothyroidism group [1 ml/100g BW/day, 0.1% propylthiouracil (PTU)] by intragastric gavage for 60 days. Blood samples were collected to measure the serum levels. The epididymis was excised to measure sperm motility and testes were excised to measure mineral, oxidative stress, c-Fos expression, cell cycle, and apoptosis. After 60 days, body weight, relative testes weight, triiodothyronine, and total thyroxine were all significantly decreased, whereas thyroid stimulating hormone was increased in the hypothyroidism group. A significant increase in sex hormone level of estradiol (E2) and significant decreases in testosterone (T) and T/E2 ratio were observed following PTU treatment. And sperm quality was also significantly changed. There were significant decreases in the contents of calcium (Ca²⁺) and zinc (Zn²⁺). On the other hand, malondialdehyde and hydrogen peroxide contents significantly increased, whereas the activity of superoxide dismutase, catalase and nitric oxide synthase and nitric oxide content significantly decreased in hypothyroid rats. The mRNA and protein expressions of c-Fos decreased significantly. The cell percentage in G0/G1 phase increased significantly, whereas decreased significantly in S and G2/M phases. Also, a significant increase in testicular cell apoptosis was observed in hypothyroid-treated rats. These results suggested that hypothyroidism could affect reproductive function in the form of changed sex hormone levels, sperm motility and testicular Ca²⁺ and Zn²⁺, and enhanced oxidative stress leading to c-Fos abnormal expression and increased apoptosis.     

一株产电菌嗜根考克氏菌(Kocuria rhizophila)的分离及其产电性能优化

本研究以天津泰达污水处理厂污泥浓缩间的污泥为接种物,启动并运行了微生物燃料电池(MFCs).从富集的阳极生物膜上分离得到了一株纯培养的微生物菌种,命名为P2-A-5.研究发现,菌株P2-A-5的16S rDNA序列与菌株Kocuria rhizophila DC2201具有100%的同源性,结合该菌的形态特征和生理生化实验,将其归属为嗜根考克氏菌(Kocuria rhizophila).通过化学剂处理、底物种类和浓度的优化,进一步提高其在微生物燃料电池中的产电性能.结果表明,菌株K.rhizophila P2-A-5经0.5 mg·L-1溶菌酶处理45 min后,接种到以2.0 g·L-1海藻糖为底物的阳极液中运行MFCs,其功率密度达到314.8 m W·m-2,比优化前(74.9 m W·m-2)提高了320.3%.这是首次对K.rhizophila种内微生物产电性能及其在微生物燃料电池中应用的报道,其成果对于丰富产电微生物的多样性,挖掘更多具有高电化学活性的微生物菌种,提高其产电性能具有重要的理论意义.     

Enhanced catalytic complete oxidation of 1,2-dichloroethane over mesoporous transition metal-doped γ-Al2O3

High-surface-area mesoprous powders of γ-Al₂O₃ doped with Cu^2 +, Cr^3 +, and V^3 + ions were prepared via a modified sol–gel method and were investigated as catalysts for the oxidation of chlorinated organic compounds. The composites retained high surface areas and pore volumes comparable with those of undoped γ-Al₂O₃ and the presence of the transition metal ions enhanced their surface acidic properties. The catalytic activity of the prepared catalysts in the oxidation of 1,2-dichloroethane (DCE) was studied in the temperature range of 250–400°C. The catalytic activity and product selectivity were strongly dependent on the presence and the type of dopant ion. While Cu^2 +- and Cr^3 +-containing catalysts showed 100% conversion at 300°C and 350°C, V^3 +-containing catalyst showed considerably lower conversion. Furthermore, while the major products of the reactions over γ-alumina were vinyl chloride (C₂H₃Cl) and hydrogen chloride (HCl) at all temperatures, Cu- and Cr-doped catalysts showed significantly stronger capability for deep oxidation to CO₂.