Supercritical water oxidation of polyvinyl alcohol and desizing wastewater：Influence of NaOH on the organic decomposition

Polyvinyl alcohol is a refractory compound widely used in industry. Here we report supercritical water oxidation of polyvinyl alcohol solution and desizing wastewater with and without sodium hydroxide addition. However, it is difficult to implement complete degradation of organics even though polyvinyl alcohol can readily crack under supercritical water treatment. Sodium hydroxide had a significant catalytic effect during the supercritical water oxidation of polyvinyl alcohol. It appears that the OH ion participated in the C-C bond cleavage of polyvinyl alcohol molecules, the CO2-capture reaction and the neutralization of intermediate organic acids, promoting the overall reactions moving in the forward direction. Acetaldehyde was a typical intermediate product during reaction. For supercritical water oxidation of desizing wastewater, a high destruction rate (98.25%) based on total organic carbon was achieved. In addition, cases where initial wastewater was alkaline were favorable for supercritical water oxidation treatment, but salt precipitation and blockage issues arising during the process need to be taken into account seriously.     

好氧颗粒污泥处理青霉素废水研究

青霉素在其生产过中产生大量的废水,其COD值较高,生化性较差,成分复杂,微生物难以降解,其处理技术是世界性难题。文章采用以葡萄糖模拟废水培养的好氧颗粒污泥为接种体,经青霉素废水逐步驯化后,使其完全处理青霉素废水。实验结果表明,应用好氧颗粒污泥技术,处理青霉素废水,COD,NH3_N,TP去除率较高,具有很好的处理效果。     

氟硅酸钠废水处理与循环利用探讨

从芒硝法（Na2SO4）氟硅酸钠生产工艺过程分析了氟硅酸钠母液废水的来源和主要成分,剖析了现有污水处理工艺过程存在的三个方面缺陷,并从实施清洁生产、节能减排和完善治理设施两方面提出了改进对策,全面实现了废水的循环利用。     

Effect of two-stage sodium hydroxide pretreatment on the composition and structure of Napier grass (Pakchong 1) (Pennisetum purpureum)

ABSTRACT

Sodium hydroxide is ideal in removing lignin from lignocellulosic materials at an effective operational cost. Two-stage NaOH pretreatment was employed herein to investigate lignin and hemicellulose removal and understand the morphology of Napier grass (Pakchong 1) (Pennisetum purpureum), which is considered lignocellulosic due to its high carbohydrate content. NaOH was used at different concentrations (0, 1, 2, 3, and 4 wt.%) and presoak times (1, 2, 3, and 4 h). The results demonstrated that 3 wt.% NaOH at 121°C without presoak resulted in 83.5% lignin removal, with a cellulose to lignin ratio of 3.0. Moreover, the treated samples showed cracking and irregular patterns at optimal conditions.     

用次氯酸钠法处理选矿废水

采用次氯酸钠法处理铅锌硫化矿选矿废水,考察了废水初始pH、NaClO加入量及反应时间对选矿废水COD去除率的影响。在废水pH为4、NaClO加入量为100g/L、反应时间为30min的条件下,选矿废水的COD去除率可达到98．3％;当pH为11、反应时间为10min、NaClO加入量为1g/L时,选矿废水的COD去除率为39．4％。     

利用隆线溞趋光行为检测水体中五氯酚钠和镉的研究

采用自主选育的隆线溞单克隆体作为试验生物,研究了五氯酚钠(PCP-Na)和镉对隆线溞趋光指数的影响,并与急性毒性试验方法进行了比较.结果表明,在试验浓度范围内,水溞的趋光指数分别随五氯酚钠和镉浓度的升高而降低,呈极显著线性关系,说明隆线溞趋光指数的变化可以指示水体中这2种毒物的生物有效浓度.PCP-Na使隆线溞趋光指数(3h)发生显著改变的下限浓度为0.18 mg·L～,远低于LC50(96 h)(0.59 mg·L-1),上限浓度大于3.20 mg·L-1,也远高于LC50(24h)(0.73 mg·L-1),表明隆线溞趋光指数法比急性毒性试验法的灵敏度高,检测范围大,耗时短.在试验溶液范围内,五氯酚钠和镉之间不存在明确的相互作用关系.     

负压二次曝气二氧化氯发生器的研制与应用

以氯酸钠和工业盐酸为基本原料,采用独特的负压二次曝气工艺,在催化剂作用下,经氧化还原反应产生以二氧化氯为主的混合消毒气体,经吸收后形成一定浓度的二氧化氯混合消毒液,与待处理水充分混合,达到杀菌消毒的目的。     

二氯异氰脲酸钠和二氯异氰脲酸对棕囊藻细胞去除的研究

研究了二氯异氰脲酸钠和三氯异氰脲酸对球形棕囊藻的灭杀和控制作用,及其投药时间对除藻效果的影响,并比较2种药剂的除藻效果,初步探讨了除藻机理.结果表明,这2种除藻剂可以缓释次氯酸,提高其稳定性,有较长的药效期.当有效氯浓度达到4.5mg/L时,2种药剂均能有效地控制和灭杀球形棕囊藻,具有高效、低毒的优点.有效氯浓度为5.0mg/L,藻细胞去除率在24h可达到90%以上.在等于和大于5.0mg/L有效氯浓度时,三氯异氰脲酸的除藻效果优于二氯异氰脲酸钠,通过对2种药剂除藻率的t检验进一步证实了这一结论.     

水杨酸法检测水质氨氮的改进方法

该氨氮检测方法是对水杨酸分光光度法的改进,通过将50 g/L的水杨酸改为150 g/L的水杨酸钠,将有效氯为3. 5 g/L的次氯酸钠溶液改为5 g/L的二氯异氰尿酸钠溶液,增加了检测试剂的稳定性和贮存时间,同时将氨氮测定上限从1 mg/L提高至2. 5 mg/L,并将显色时间从60 min优化为30 min,使得此方法更为便捷。该方法的氨氮标准曲线线性关系良好,相关系数为0. 999 6,准确性和精密度高,加标回收率良好,适用于不同类型水质中氨氮的检测。     

用改性海泡石处理含磷废水

以海泡石为原料,经盐酸活化、水热活化,再加入氯化镁、氯化铁复合制得除磷剂原粉;再用聚氯乙烯将除磷剂原粉黏合成粒状除磷剂。用粒状除磷剂对废水中的磷（PO4^3-）进行吸附、洗脱,考察除磷剂的循环使用性能。实验结果表明：除磷剂对废水中磷的吸附容量可达92m g/g以上;以碳酸钠为洗脱剂,磷的洗脱率可达90%以上;除磷剂可重复使用,且性能优良。