大体积垃圾露天堆肥试验

通过进行大体积露天垃圾堆肥试验，证明大体积鲜垃圾露天单元式堆肥，是在堆温、养分及卫生学等各项指标均达到国家标准的厌氧高温堆肥     

城市生活垃圾堆肥对水稻生长和土壤的影响

利用城市生活垃圾堆肥作为肥料,采用水培法和土培法对水稻生长和土壤的影响进行了试验研究。结果表明,施用城市生活垃圾堆肥明显提高了水稻的生长量,增加了水稻植株茎叶中硅的含量;降低了糙米中有毒元素镉的含量;改变了土壤的酸度,增强了土壤的肥力;水稻植株和土壤中某些有害元素的含量略有增加,但远低于环境的允许值。     

Effect of selected and non-selected urban waste compost on the initial growth of corn

Brazil produces approximately 242,000 t of waste per day, 76% of it being dumped outdoors and only 0.9% recycled, including composting, which is an alternative still little known in Brazil. In search of a better destination for residues produced by domestic activities, composting stands as a feasible alternative. Organic compost from waste may be used for various purposes, among which are soil recovery, commercial production, pastures, lawns and reforestry and agriculture. However, the quality of the compost determines the growth and the development of plants. The effect of compost made from urban waste on corn plant (Zea mays L.) growth was investigated. Two types of compost were used: the selected compost (SC), produced from organic waste selectively collected; and the non-selected compost (NSC), taken from a 15-year-old cell from the Canabrava land-fill, located in Salvador, Bahia, Brazil (altitude 51 m, 12°22′–13°08′S, 38°08′–38°47′W). Corn was seeded in polyethylene pots, with soil-compost mixing substrate in the proportion of 0, 15, 30, 45 and 60 t ha⁻¹ equivalent doses. Chemical analyses of the compost and growth properties of the plant like chlorophyll content; height and stem diameter; aerial and radicular dry biomasses, were used to evaluate compost quality. Plants cultivated with SC presented a superior gain, being of 52.5% in stem diameter, 71.1 and 81.2% in root and stem biomasses, respectively. Chlorophyl content alterations were observed in plants from treatments using 30 t compost ha⁻¹ dose onwards. Conventional and multivariate statistical methods were used to evaluate these results. The beneficial action of organic compost in plant growth was confirmed with this research.     

膨润土调质对污泥堆肥的脱毒及重金属钝化和雌酮消除作用

利用干基添加比例为0~10%钙基膨润土对污泥进行了调质,通过52 d的好氧堆肥研究了调质对堆体温度、pH、水溶性盐分(EC)、有机碳、总氮、铵态氮(NH_4~+-N)、硝态氮(NO_3~--N)的影响,并进一步分析了其对污泥脱毒(种子萌发)和重金属(Zn、Cu、Pb、Cd)钝化及雌酮(E1)消除的影响.结果表明,污泥经外加膨润土调质后,可以促进堆肥物料的热灭活无害化,能使有机碳矿化率达到15.27%~19.71%;堆肥过程中各处理堆肥pH先降低后升高,最终稳定在6.76~7.05之间,但膨润土调质堆肥pH的波动变缓;添加膨润土的堆肥EC显著低于对照处理(1 132μS·cm~(-1)),整个堆肥过程EC值随着膨润土添加比例的增加而稍有降低.堆肥过程中的总氮含量逐渐增加,但对照处理在堆肥初期存在一定的氮素损失,而污泥经过调质可减少堆肥初期氮素损失;整个堆肥中NH_4~+-N含量先增加后降低,各处理NO_3~--N均呈现出逐渐增加的趋势,表明污泥调质促进NO_3~--N的转化.虽然调质对种子发芽产生一定的抑制作用,但均不影响堆肥的腐熟,且能显著促进重金属的钝化,同时添加膨润土处理显著降低堆料E1含量,添加比例5%处理使E1含量由90.48μg·kg~(-1)降低至28.27μg·kg~(-1).研究表明,膨润土不高于5%的添加比例是适合的污泥调质措施,在污泥堆肥物料的安全化、脱毒及重金属钝化和雌酮消除方面具有较好的应用潜力.     

厌氧发酵处理庆大霉素菌渣的可行性及条件优化

采用厌氧发酵处理庆大霉素菌渣,考察了含固率、接种比、接种污泥、发酵底物等因素对庆大霉素菌渣厌氧发酵的影响,并用累积净甲烷产量衡量庆大霉素菌渣进行厌氧发酵的可行性及发酵程度。试验结果证实了庆大霉素菌渣进行厌氧发酵的可行性,其中含固率和接种比对发酵的影响较大,最佳条件为含固率5%,接种比1/3;对比试验所用3种接种污泥,发现接种某造纸厂污水处理IC反应器的厌氧颗粒污泥效果最优,在最优含固率和接种比的条件下,累积净产甲烷量为28.21 m3/t;此外,试验还证实,采用不同菌渣的联合发酵表现出了明显的协同作用,在最优条件下,庆大霉素菌渣与林可霉素菌渣按1∶2的比例联合发酵的产甲烷量可达到37.5 m3/t。     

覆盖处理对猪粪秸秆堆肥中氮素转化和堆肥质量的影响

为了探讨覆盖措施对堆肥化中氮素转化与堆肥质量的影响,在自制的强制通风静态堆肥箱中,模拟研究了覆盖腐熟堆肥后,下层猪粪秸秆堆肥及覆盖层中氮素形态和其他腐熟度指标的变化.结果表明:覆盖处理降低了下层堆肥中的含水率、种子发芽指数(GI值)、升温期和高温期的pH值,增大了降温期后的堆肥电导率EC值,而对堆温影响不大.覆盖处理未改变堆制初期下层堆肥中氨气的释放总量,只延缓了氨气的释放时间,但明显增加了降温期后堆肥中硝态氮和有机氮的含量.在堆制期间,覆盖处理的下层堆肥中硝态氮、有机氮、总氮和总磷含量的增幅分别比对照高66.7％、33.8％、32.7％和138.6％;而有机碳降解率、铵态氮和腐殖质含量的降幅则分别比对照低1.1％、8.0％和3.7％.覆盖层中pH值、铵态氮和硝态氮含量的变化说明腐熟堆肥能够吸收下层堆肥释放的氨气并进行硝化作用;覆盖层的腐熟堆肥总体上进行了矿化作用,从而影响了下层堆肥的氮素转化过程及质量.     

磺胺甲噁唑对猪粪堆肥过程中堆料性质与酶活性的影响

以猪粪、小麦秸秆为材料,研究了磺胺甲噁唑（SMZ）对高温堆肥过程中理化性质（温度、pH值、E₄/E₆）和酶活性（纤维素酶、磷酸酶、脲酶、多酚氧化酶）的影响.结果表明：SMZ对堆肥理化性质的影响与其浓度有关.高浓度（95 mg·kg^-1）SMZ会对微生物活性产生显著抑制作用,表现出堆肥温度难以达到无害化标准,堆料pH值较低（<9.0）.但高浓度（95 mg·kg^-1）SMZ能激活多酚氧化酶活性,且水提浸液E₄/E₆值较低.在堆肥过程中,SMZ对纤维素酶和脲酶活性呈现出“抑制-激活-抑制”的作用,50 mg·kg^-1的SMZ对纤维素酶产生不同程度的激活作用.相比之下,脲酶活性对SMZ的敏感性比纤维素酶更敏感,5 mg·kg^-1的SMZ即能显著抑制脲酶活性,中浓度（50 mg·kg^-1）的SMZ对碱性磷酸酶活性产生了显著的抑制作用.综上,SMZ通过影响酶活性而影响堆肥过程的物质转化.此外,SMZ浓度越大,种子发芽指数越低.当SMZ≥50 mg·kg^-1时,堆肥难以腐熟而对植物毒性较大.     

Quantitative analysis of microbial biomass yield in aerobic bioreactor

We have studied the integrated model of reaction rate equations with thermal energy balance in aerobic bioreactor for food waste decomposition and showed that the integrated model has the capability both of monitoring microbial activity in real time and of analyzing biodegradation kinetics and thermal-hydrodynamic properties. On the other hand, concerning microbial metabolism, it was known that balancing catabolic reactions with anabolic reactions in terms of energy and electron flow provides stoichiometric metabolic reactions and enables the estimation of microbial biomass yield (stoichiometric reaction model). We have studied a method for estimating real-time microbial biomass yield in the bioreactor during food waste decomposition by combining the integrated model with the stoichiometric reaction model. As a result, it was found that the time course of microbial biomass yield in the bioreactor during decomposition can be evaluated using the operational data of the bioreactor (weight of input food waste and bed temperature) by the combined model. The combined model can be applied to manage a food waste decomposition not only for controlling system operation to keep microbial activity stable, but also for producing value–added products such as compost on optimum condition.     

三阶段温度控制堆肥接种法对有机氮变化规律的影响

利用原生生活垃圾,通过三阶段温度控制技术进行堆肥试验,探讨在堆肥过程中有机态氮组分的动态变化规律.结果表明,全氮、酸水解有机态氮、氨基酸态氮均在堆肥的前期呈明显的下降趋势,呈较好的相关性.与CK（对照组）处理相比,在堆肥的后期,三阶段温度控制堆肥酸水解有机态氮、氨基酸态氮、氨基糖态氮及酸解未知态氮含量呈不同程度的上升趋势,增加幅度依次为：10.67%、16.17%、7.17%、22.44%.表明三阶段温度控制技术能减少堆肥中氮素的损失,堆肥产品施入土壤后,可提高土壤的供氮潜力.     

低温复合菌剂对牛粪堆肥发酵影响的研究

为了探明低温复合菌剂对牛粪堆肥发酵的影响,开发出适合东北寒区堆肥发酵的微生物菌剂.本研究在0℃以下以牛粪、秸秆为原料,分别设置接种低温复合菌剂堆肥、接种常温菌剂堆肥和自然堆肥3个处理,测定了堆肥过程中温度、p H、C/N、全磷、铵态氮、硝态氮和种子发芽指数的动态变化.试验结果表明,接种低温复合菌剂组第11 d进入高温期(50℃),比接种常温菌剂组提前了14 d,最高温度达62℃,高温期维持了9 d,而自然堆肥组一直未进入高温期.至堆肥结束时,接种低温复合菌剂组和接种常温菌剂组的最终p H分别为7.17、7.24;C/N均降到20以下,分别为16.10、15.67;全磷的变化无明显差异;种子发芽指数分别为92%和85%.添加菌剂组较自然堆肥组铵态氮含量明显降低,硝态氮含量增高.综上所述,接种低温复合菌剂可以在低温下促进堆肥迅速起温,并保证了堆肥的腐熟质量.