Swine wastewater treatment in a two stage sequencing batch reactor using real‐time control

Abstract

A laboratory scale two‐stage sequencing batch reactor (TSSBR) was used to study the effectiveness of pH as a real‐time control parameter in swine wastewater treatment. A Ringlace media was inserted into the A/O (Anoxic/Oxic) reactor for bacteria immobilization. The TSSBR was subjected to three levels of organic loading. The pH and ORP (Oxidation Reduction Potential) patterns obtained were consistent with distinct features, enabling the real‐time control strategy to effectively set a flexible aeration time pending on influent concentration, hence resulting in flexible cycle time and HRT (Hydraulic Retention Time) for the system. The real‐time process ensured a removal efficiency of over 99% and 95%, respectively, for ammonia and TOC (Total Organic Carbon). For NO₃ ^‐‐N and PO₄ ^‐3, the run with influent TOC = 4,000 mg/L yielded the most efficient removal of 61% and 95%, respectively. Test results suggest that pH can be a viable tool for on‐line real‐time control of a biological treatment process.     

3种载体固定化菌藻共生系统脱氮除磷效果的对比

采用3种不同载体（海藻酸钠、聚乙烯醇、复合载体）,分别将小球藻和栅藻与活性污泥固定成菌藻共生系统,制成菌藻凝胶小球,单独菌、单独藻的凝胶小球,用于处理人工污水。结果表明,（1）复合载体固定的菌藻共生系统氮磷去除效果最好,PVA载体的脱氮除磷效果次于复合载体优于海藻酸钠;（2）固定化菌藻共生系统的脱氮除磷效果明显优于单独固定菌和单独固定藻,固定菌的效果较差;（3）3种载体包埋下的固定化小球藻的脱氮除磷效果均较相同载体固定化的栅藻效果好。     

Estrogen receptor mediated activity in bankside groundwater, with flood suspended particulate matter and floodplain soil - an approach combining tracer substance, bioassay and target analysis

Bankside groundwater is widely used as drinking water resource and, therefore, contamination has to be avoided. In the European Union groundwater protection is explicit subject to Water Framework Directive. While groundwater pollution may originate from different sources, this study investigated on impacts via flood events.Groundwater was sampled with increasing distance to the river Rhine near Karlsruhe, Germany. Samples were HPLC-MS-MS analyzed for the river contaminant carbamazepine to indicate river water infiltration, giving permanent presence in 250 m distance to the river (14-47 μg L⁻¹). Following a flood event, concentrations of about 16-20 μg L⁻¹ could also be detected in a distance of 750 m to the river. Furthermore, estrogenic activity as determined with the Yeast Estrogen Screen assay was determined to increase up to a 17β-ethinylestradiol equivalent concentration (E-EQ) = 2.9 ng L⁻¹ near the river, while activity was initially measured following the flood with up to E-EQ = 2.6 ng L⁻¹ in 750 m distance. Detections were delayed with increasing distance to the river indicating river water expansion into the aquifer.Flood suspended matter and floodplain soil were fractionated and analyzed for estrogenic activity in parallel giving up to 1.4 ng g⁻¹ and up to 0.7 ng g⁻¹, respectively. Target analysis focusing on known estrogenic active substances only explained <1% of measured activities.Nevertheless, river water infiltration was shown deep into bankside groundwater, thus, impacting groundwater quality. Therefore, flood events have to be in the focus when aiming for groundwater and drinking water protection as well as for implementation of Water Framework Directive.     

SBR法降解有机物规律的研究

本研究是以处理啤酒废水的试验为基础展开的。试验结果进一步验证了SBR法具有简易,快速、低耗等优点。除此之外,还得出以下结论:增加间歇反应时起始污泥浓度可以提高处理效率或减少反应时间;非限制曝气方式耐冲击负荷,需氧均匀,能缩短反应周期;间歇反应中微生物细胞的合成代谢占主导地位,对氮与磷的需要量大于传统的理论值。本文还指出SBR法是很适合我国国情的一种废水处理工艺,应当加强对它的研究和推广应用。     

基于SBR反应器的ANAMMOX工艺的启动运行

采用SBR反应器,接种好氧硝化污泥,在142 d内于较高负荷下成功启动了厌氧氨氧化反应器.反应器总氮容积负荷(以N计)为0.43 kg/m3·d,总氮去除率最高达到93.3%,平均为80.5%;氨氮和亚硝酸盐氮的去除率最高达到93.9%和99.8%,平均去除率为81.2%和85.7%.在稳定运行阶段,氨氮去除量、亚硝酸盐氮去除量、硝酸盐氮生成量三者之间的比值为1:1.38:0.18.反应器启动过程中,出水、进水pH差值的变化趋势由负到正,然后稳定在一定范围内;且污泥性状有较大变化,污泥中微生物所占比率有所提高,整个反应器中适应厌氧氨氧化运行方式的菌种增殖较快.     

SBR法处理豆制品废水工艺条件的研究

用SBR法处理豆制品废水的试验表明,该系统具有较好的抗负荷冲击能力,进水COD在300～2000 mg/L之间变化,对系统不造成任何影响;考察了曝气时间、曝气量和污泥浓度等对去除效果的影响,试验结果表明,曝气时间和曝气量对处理效果影响很大,确定该反应系统最佳曝气时间是8 h,适宜的曝气量是800 L/h,而污泥浓度控制在4000 mg/L左右时,处理效率最高,采用进水顶出水的排水方式是可行的,确定系统的最佳排水比是3/5.厌氧段的插入可以减少剩余污泥的产量.     

一种新型复合球填料在低浓度污水再生回用中的应用研究

新型复合球填料为沸石与悬浮球填料的有机组合体,密度约为0.92～0.97g/cm3,比表面积为711～1185m2/m3,表面粗糙,物化性能稳定.在曝气量为20∶1,停留时间为6 h时,装有新型复合球填料的反应柱挂膜容易,成膜时间短,膜不易脱落,且生物相丰富.膜成熟时对生活污水中的氨氮和COD都有很好的去除效果,出水氨氮浓度≤2 mg/L,去除率≥93%;出水COD浓度≤22 mg/L,去除率≥80%.新型复合球反应柱在稳定状态处理低浓度的二级出水时,出水氨氮浓度≤2 mg/L,去除率≥89%,出水COD浓度为10～36 mg/L,去除率为48%～81%.出水水质符合GB50335-2002标准.     

SBR处理铁路洗涤废水试验研究

铁路洗涤废水中含有的主要污染物直链烷基苯磺酸钠(LAS)是我国环境标准中第2类污染物质.目前,铁路洗涤废水的处理以物理和化学法为主,存在效果不稳定、成本较高和工艺复杂等问题,急需寻求一种适合铁路洗涤废水特点的处理工艺.用SBR小试装置进行铁路洗涤废水处理实验研究,并且投加LAS降解菌于SBR中,进行了工艺参数的确定,处理效果考察和投菌前后对比等方面的初步研究.     

SBR法短程硝化处理纤维素乙醇废水的中试研究

针对纤维素产乙醇废水高有机物、高氨氮、难降解的特点,运用短程硝化反硝化脱氮工艺,基于序批式活性污泥反应器（SBR）的调试运行,研究反应器运行方式对COD去除和脱氮效能的影响,为日后纤维素乙醇废水处理的工程化提供借鉴。结果表明：通过控制DO（0.5 mg·L-1）、pH（7.6~8.5）和投加碳源等条件,可实现亚硝酸盐氮的积累和转化,最终三氮去除率稳定在70%以上;通过投加不同碳源对比实验,发现乙酸钠作为反硝化外加碳源比葡萄糖具有更高的效率;厌氧工艺处理过的纤维素乙醇废水经短程硝化反硝化工艺处理后,COD去除率维持在20%上下,表明废水可生化性极低,已不适应生物法处理,须利用化学氧化法才能进一步去除;通过周期实验,发现硝化阶段碱度过量对短程硝化进程影响并不明显,相反充足的碱度是保证硝化反应进行的必要条件。     

Ti-Si-Ox脱硝催化剂载体的组分优化及其性能研究

采用挤出成型法制备系列Ti-Si-Ox复合氧化物催化剂载体,研究了Ti-Si-Ox催化剂载体组分配比、酸量、比表面积与脱硝性能和抗压强度的关系。采用XRD、Raman spectra、N2-BET、Py-IR以及XPS等表征技术对催化剂载体进行表征。结果表明：Ti/Si元素摩尔比为9∶1时Ti0.9Si0.1Ox催化剂载体的轴向抗压强度适中且脱硝催化活性最高;在5 000 h-1空速条件下,催化剂载体最高脱硝活性在400 ℃时达到99.0%且起燃温度降至260 ℃;另外,Ti0.9Si0.1Ox催化剂载体的比表面积为75.4 m2·g-1,介孔最可几分布为8.1 nm,轴向抗压强度为1.4 MPa,符合工业应用条件,即Ti-Si-Ox载体具有较好的工业应用前景。