Experimental analysis of thermal performance of evacuated tube and flat-plate solar air collectors at different air flow rates

The thermal performances of an evacuated tube collector (ETC) and flat-plate solar air collector (FPC) are experimentally investigated at different air flow rates. To investigate the performance of the ETC and FPC, experimental set-ups were fabricated. Air was used as a working fluid and tested at the same climatic conditions. The ETC had 15 evacuated tubes with a surface area of 1.66 m². The experimental set-up consisted of a header with a hollow pipe (square pipe) in the centre through which the air flowed. The flat-plate collector had a surface area of 1.35 m². The FPC had a black painted absorber sheet which divides the collector into two sections. The air flowed through the upper and the lower sections parallel to the collector to minimize the overall heat loss. The temperature of the outlet air depends on several factors along with the airflow rate and the intensity of the solar radiation. It was found that during the day at high flow rates, the efficiency of the ETC varies from 0.12 to 0.5, and for the flat plate it was from 0.29 to 0.68. The maximum temperature of the air was 56.7°C for the ETC and 25.7°C for the FPC.     

比较FDS和FLUENT在池火灾模拟中的应用

热辐射是池火灾燃烧的主要危害之一,可能导致人员伤亡或设备设施损坏。油罐火灾是典型的池火灾。本文通过对无风情况下油罐火灾火焰形状进行理论模型分析,建立了各自的物理模型和几何模型。应用计算流体动力学软件Fluent和火灾动力学模拟软件FDS,对无风情况下池火灾对周围大气环境的热辐射强度进行模拟,得到了火焰周围入射热流密度分布图,运用软件Statistica拟合得出热辐射强度与距离火焰中心的水平距离的对应关系,分别计算出轻伤半径区域下的最小安全距离。数值模型模拟结果与池火灾经验模型进行比较,发现FDS辐射强度结果与经验模型结果吻合较好。分析了利用这两种模型模拟油罐火灾各自的优点和缺点,最后提出了运用FDS软件模型模拟油罐火灾时的优势。     

氨法烟气脱硫工艺在燃煤锅炉的应用

介绍了氨法脱硫技术在国内外的应用情况以及氨法烟气脱硫工艺的工作原理和工程应用难点;分析了热电厂煤粉锅炉烟气脱硫的工艺路线特点及新型氨法脱硫工艺应用后取得了的显著效果;提出了氨法脱硫工艺存在的问题和发展前景。     

Human Impacts to River Temperature and Their Effects on Biological Processes: A Quantitative Synthesis1

Hester, Erich T. and Martin W. Doyle, 2011. Human Impacts to River Temperature and Their Effects on Biological Processes: A Quantitative Synthesis. Journal of the American Water Resources Association (JAWRA) 47(3):571‐587. DOI: 10.1111/j.1752‐1688.2011.00525.x Abstract: Land‐use change and water resources management increasingly impact stream and river temperatures and therefore aquatic organisms. Efforts at thermal mitigation are expected to grow in future decades. Yet the biological consequences of both human thermal impacts and proposed mitigation options are poorly quantified. This study provides such context for river thermal management in two ways. First, we summarize the full spectrum of human thermal impacts to help thermal managers consider the relative magnitudes of all impacts and mitigation options. Second, we synthesize biological sensitivity to river temperature shifts using thermal performance curves, which relate organism‐level biological processes to temperature. This approach supplements the popular use of thermal thresholds by directly estimating the impact of temperature shifts on the rates of key biological processes (e.g., growth). Our results quantify a diverse array of human thermal impacts, revealing that human actions tend to increase more than decrease river temperatures. Our results also provide a practical framework in which to quantify the sensitivity of river organisms to such impacts and related mitigation options. Finally, among the data and studies we synthesized, river organisms appear to be more sensitive to temperature above than below their thermal maxima, and fish are more sensitive to temperature change than invertebrates.     

硝基苯气相氟代脱硝反应热安全性的理论研究

为研究硝基苯气相氟代脱硝反应的热安全性,采用Gaussian98软件,运用密度泛函理论(DFT)B3LYP,在6-31G(D)基组水平上,全优化计算气相条件下氟离子对硝基苯进攻的氟代脱硝反应的微观机理,得到反应路径并通过IRC验证,并对反应过程中反应物,各中间体、过渡态、产物进行分子几何构型优化,标准热力学函数计算。理论计算研究表明:该反应属于SN2亲核取代反应;反应能垒较低,反应所需能量可以从过程R→IM1和TS3→P所释放的能量(279.06 kJ/mol,143.34 kJ/mol)中获得;与席曼反应相比较,该反应速率下降3个数量级,热安全性更高,符合化工工程设计的本质安全化要求,具有广阔的应用前景。     

Investigation of the propensity of sulfide concentrates to spontaneous combustion in storage

Spontaneous combustion of sulfide concentrates can cause many serious problems during storage. In this study, two representative samples (sulfur-rich sulfide concentrate and iron-rich sulfide concentrate) were investigated for the self-heating behavior using the crossing-point temperature (CPT) method. The corresponding apparent activation energies were determined, 13.7366 kJ/mol for iron-rich sulfide concentrate and 21.3817 kJ/mol for sulfur-rich sulfide concentrate. Furthermore, the surface temperatures of sulfide concentrate stockpiles in different seasons were also measured by a thermal image apparatus. It was found the temperature for iron-rich sulfide concentrate stockpile was higher than that for rich-sulfur sulfide concentrate stockpile. These research results show iron-rich sulfide concentrate exhibits stronger propensity to spontaneous combustion than sulfur-rich sulfide concentrate. Particular attention should be paid to the fire hazard of iron-rich sulfide concentrate in daily safety check work. The combination of the CPT method with the infrared thermal image measurement provides a new approach for the risk assessment on the propensity of sulfide concentrates to spontaneous combustion during the production, storage and transportation. The useful data and experience achieved in this investigation can be also referenced in similar cases later.     

水库水体热分层的水质及细菌群落分布特征

作为重要的城市饮用水源地,水库是人工筑坝形成的特殊类型的水体,其水质直接影响居民的饮用水安全.为揭示北京市饮用水源地密云水库的秋季分层特征和细菌群落的垂直变化,于水体稳定分层期(秋季)在水库进行采样,应用16S rDNA末端限制性片段长度多态性(T-RFLP)和定量PCR等方法研究了密云水库水体细菌群落的垂直分布特征,并利用聚类分析、多元统计分析揭示细菌群落与环境因子之间的响应关系.结果表明:(1)密云水库水体温跃层位于水深20～30 m处,水温范围在15～19℃,聚类分析将7个采样水层划分为好氧区(上层)和缺氧区(下层)两类,温度、DO、pH在15 m以下逐渐降低,电导率、氨氮、硝态氮、亚硝态氮及总氮在15 m后发生显著变化,水体水质表现出明显的垂直分布特征;(2)RDA分析结果显示,上下水层的溶解氧、pH、电导率、氨氮、硝态氮和亚硝态氮存在较为明显的垂向变化,是影响密云水库细菌群落垂直分布的主要环境因子;(3)总细菌的数量随水深变化的波动较为明显,其中好氧区细菌的Shannon-Wiener指数和T-RFs片段数明显高于缺氧区,说明秋季密云水库水体中细菌群落分布存在显著的分层现象.本研究探究了水体热分层对水库水质及细菌群落的影响,可为预测水质变化和水库管理提供科学依据.     

炼化浓盐水处理与资源化工艺探讨＊

炼化污水深度处理回用是各炼化企业节水减排的主要措施之一。炼化企业反渗透(简称RO)污水脱盐回用装置在运行中暴露出末端高含盐污水的处置难题,影响了污水回用生产的连续运行。文章阐述近年来炼化企业高含盐污水处置现状、存在问题、国内外处理技术及发展趋势,在此基础上针对炼化企业特点,提出以热法、膜法为核心技术的浓盐水处理工艺耦合方案,为炼化企业解决污水回用瓶颈技术难题、实施污水"零排放"与发展循环经济提供借鉴与参考。     

季铵盐离子液体改性活性炭及其热安全性研究*

为进一步提高活性炭对VOCs的吸附性能和热安全性,采用铵盐类离子液体改性原始活性炭,优化其理化性质。结果表明:改性活性炭表面生成新的无机盐化合物,C=O、-OH、C-O、-COOH和C-S基团增加;孔隙结构增多且分布均匀,比表面积及微孔体积增大;改性后活性炭对甲苯的吸附量提高3.14倍,吸附效率明显提升;在固定碳的燃烧阶段,改性活性炭活化能为54.44 kJ·mol-1,是改性前活性炭的1.38倍,活化能增大,物质稳定性增强;当粒径为120~150目及200目以上时,改性前后活性炭的自燃温度分别从328.4 ℃、319.3 ℃增长至355.1 ℃、345.7 ℃。因此,负载季铵盐离子液体可有效提高活性炭吸附性能和热安全性,研究结果可为优化VOCs处理工艺提供参考。     

喷射火对输油管道热影响实验平台设计与验证*

为研究油气并行管道中,天然气管道喷射火对相邻输油管道内流体与管壁的热影响,设计并搭建天然气喷射火对输油管道热影响实验平台。实验平台由环道及冷却系统、火焰系统、控制及数据采集系统3个部分组成。完成平台搭建并验证环道系统气密性后,以0#柴油为介质,开展验证实验。研究结果表明:火焰系统工作可靠且可控,冷却系统能够将柴油温度控制在初馏点以下,数据采集系统能够正常采集油品压力、温度、流量、管壁温度、火焰温度等预定数据,实验平台具备一定可行性与安全性。实验平台可进行在不同管道规格及材质、火灾形式、油品介质及流速条件下的热影响实验。实验平台结合材料性能进行测试,可研究喷射火对管材性能的影响,为油气并行管道的安全运行提供相关实验依据。