再生聚丙烯的洁净化和高质化应用

聚丙烯以其优异的机械性能、高的性价比和多重改性方式成为重要的通用树脂之一,这些产品废弃后产生了种类繁多和数量巨大的再生聚丙烯.通过将再生聚丙烯根据性能和来源进行分类,然后分类阐述各再生聚丙烯物料特点,结合再生聚丙烯改性方式,为高质化应用提出方向.     

Effect of humic substances on the precipitation of calcium phosphate

For phosphorus （P） recovery from wastewater, the effect of humic substances （HS） on the precipitation of calcium phosphate was studied. Batch experiments of calcium phosphate precipitation were undertaken with synthetic water that contained 20 mg/L phosphate （as P） and 20 mg/L HS （as dissolved organic carbon, DOC） at a constant pH value in the range of 8.0-10.0. The concentration variations of phosphate, calcium （Ca） and HS were measured in the precipitation process; the crystalline state and compositions of the precipitates were analysed by powder X-ray diffraction （XRD） and chemical methods, respectively. It showed that at solution pH 8.0, the precipitation rate and removal efficiency of phosphate were greatly reduced by HS, but at solution pH ≥9.0, the effect of HS was very small. The Ca consumption for the precipitation of phosphate increased when HS was added; HS was also removed from solution with the precipitation of calcium phosphate. At solution pH 8.0 and HS concentrations ≤3.5 mg/L, and at pH ≥ 9.0 and HS concentrations ≤ 10 mg/L, the final precipitates were proved to be hydroxyapatite （HAP） by XRD. The increases of solution pH value and initial Ca/P ratio helped reduce the influence of HS on the precipitation of phosphate.     

安徽省升金湖湿地土壤有机碳储存及分布

文章研究了安徽省升金湖湿地土壤有机碳储存和分布特征及其与土壤氮素的关系。结果表明,供试湿地土壤全土1m深有机碳密度达10.82±1.90kg.m-2,表层土壤(0—30cm)有机碳密度为5.19±0.68kg.m-2,高于报道的人工湿地——水稻土的碳密度;有机碳(SOC)含量分布随土壤深度(H)的递降符合幂函数方程,湿地土壤有机碳的表层积累强度和积累深度高于稻田;湿地土壤氮素是土壤固碳的有利因子,其氮素对土壤有机碳积累的效应高于水稻土;因湖泊沉积受河流动力学、土壤水分和植物生长条件的影响,湿地土壤有机碳含量存在显著的水平空间变异性。看来,长江中下游淡水湿地在陆地生态系统碳氮储存上具有重要意义。     

孔隙水压力消散试验在尾矿坝安全施工中的应用

尾矿库设计的主要控制条件是坝体的稳定性。在尾矿坝施工中还需要考虑强度、渗水性等影响因素。以锡冶山尾矿坝工程为例,探讨了数值法在尾矿库坝体岩土孔隙水压力消散试验中的应用。对提高试验精度、减少试验开支、指导工程安全施工具有现实意义。     

咸阳地裂缝成因分析

咸阳地裂缝出现于1992年,以近东西向为主,局部发育为近南北向,水平拉张位移最明显,垂直位移次之,水平扭动位移最小,为拉张兼具左旋地裂缝。咸阳地裂缝的出现位置与区域构造线吻合,说明与区域地质构造环境密切相关,构造带的存在与活动为地裂缝的发育提供了空间条件和力学薄弱界面,而承压水头的急剧下降,最终使地裂缝的出现成为可能。     

印染废水中铬的活性炭吸附及资源化研究

在实验室条件下利用活性碳柱对印染废水进行了铬的吸附,对活性碳柱进行逐级加热、逆流漂洗再生,达到了较好的处理效果,同时还回收了铬盐。     

某水电站进水口边坡变形特征及稳定性评价

某水电站是澜沧江中、下游梯级开发的关键工程,其进水口高边坡地质条件复杂。通过对该电站进水口边坡的物质组成、结构特征、以及边坡开挖等因素的综合分析研究,阐述了其变形机理,说明此高边坡存在如下变形破坏形式:①楔形体滑动破坏;②扩展式的平面型塌滑和滑移型崩塌破坏;③卸荷松弛变形破坏。采用三维块体分析和有限元数值模拟,分析了这类边坡在开挖过程中的应力变形特征及其变化规律。     

环境对冲压发动机烟火点火器性能影响研究

为促进某型冲压发动机烟火点火器生产工艺的定型,在海南进行了高温、高湿热带海洋气候自然环境对点火器长期贮存性能影响的研究。点火器采取无包装的暴露试验和密封包装贮存试验2种方法,分别在户外暴露场、棚库和库房等3种环境条件下进行试验。通过试验得到环境温度变化对密封包装储存的点火器的绝缘电阻值、电阻性能均无明显影响,点火性能良好,玻璃钢、涂层等贮存性能良好,点火器的环境适应性良好等结论。     

Research based on double coverage rate and reliability of gas detector layout optimization

The gas detector layout should be highly attuned to combustible gas leakage and attain a good reliability in avoiding detector malfunction, which is an important guarantee for the normal production of the chemical industry and other related enterprises. Herein, a gas detector layout optimization method based on double coverage and reliability is proposed. The key gas leakage monitoring area is determined through layout scene field investigation. To improve the detection probability and detection system reliability, the dual coverage target and voting mechanism are set, and the gas detector layout is determined with the ray-casting algorithm according to the coverage target. Combined with FLACS software to simulate a variety of typical leakage conditions under different layout scenarios, the relationship between the leaked gas concentration detected by gas detectors in each layout scheme and time is obtained, and the gas leakage detection probability in each layout scheme, number of detectors that can trigger the alarm, shortest time to trigger the alarm and reliability are comprehensively evaluated. The decision-maker selects the final gas detector layout plan according to the evaluation results and actual site needs. The study shows that the detection probability of each layout scheme set according to the double coverage is high, and multiple detectors can trigger the alarm (up to 100%), which ensures that the alarm can be triggered within 10 s under all applicable conditions. According to the evaluation results, the decision-maker can obtain a layout scheme that not only agrees with the actual site conditions but also attains a high detection probability, short detection time and strong reliability.     

Study of the influence of melamine polyphosphate and aluminum hydroxide on the flame propagation and explosion overpressure of aluminum magnesium alloy dust

When aluminum magnesium alloy dust floats in the air, a certain ignition energy can easily cause an accidental explosion. To prevent and control the occurrence of accidental explosions and reduce the severity of accidents, it is necessary to carry out research on the explosion suppression of aluminum magnesium alloy dust. This paper uses a vertical glass tube experimental device and a 20 L spherical explosive experimental device to carry out experimental studies on the suppression of the flame propagation and explosion overpressure of aluminum magnesium alloy dust with melamine polyphosphate (MPP) and Al(OH)₃. With increasing MPP and Al(OH)₃ concentrations, the flame brightness darkened, the flame velocity and propagation distance gradually decreased, and P_max and (dp/dt)_max decreased significantly. When the amount of MPP added reached 60%, the flame propagation distance decreased to 188 mm, which is a decrease of 68%, and the explosion overpressure decreased to 0.014 MPa, effectively suppressing the explosion of aluminum magnesium alloy dust. The experimental results showed that MPP was more effective than Al(OH)₃ in inhibiting the flame propagation and explosion overpressure of the aluminum magnesium alloy dust. Finally, the inhibitory mechanisms of the MPP and Al(OH)₃ were further investigated. The MPP and Al(OH)₃ endothermic decomposition produced an inert gas, diluted the oxygen concentration and trapped active radicals to terminate the combustion chain reaction.