超滤组合工艺应急处理苯胺水源水污染研究

以太湖水为原水,模拟突发苯胺类水污染时,探索超滤工艺对苯胺类污染物质的去除效果。研究了粉末活性炭、高锰酸钾对苯胺去除效果的投加量和反应时间,以及两者联用时的药剂投加顺序以及在超滤工艺下的投加量优化。研究表明:粉末活性炭和高锰酸钾对苯胺均有一定的去除效果,应急处理的最佳反应时间是30 min;当发生苯胺类水污染时,先投加粉末活性碳,再投加高锰酸钾,超滤去除苯胺类污染物质的效果最优,去除率可以达到85%;实验表明:粉末活性炭—高锰酸钾—超滤组合工艺技术作为苯胺的应急处理措施是可行的,粉末活性炭与高锰酸钾投加量的比约为55 mg:2.4 mg;同时,与传统常规水处理工艺相比,超滤具有去除颗粒粒径范围广,抗粉末活性碳负荷强,可以避免砂率层被穿透的优点。     

流体剪切与超声空化破解剩余污泥的参数优化

为提高剩余污泥的破解效果并降低能耗,采用FS（fluid shear,流体剪切）、UC（ultrasonic cavitation,超声空化）、FS和UC联合工艺（FS-UC,UC-FS）破解剩余污泥,并应用单因素试验结合响应面法对联合工艺进行优化.结果表明:FS对剩余污泥破解效果一般,只在开始阶段具有较好效果,随作用时间延长,破解效果未有显著提高甚至下降.UC对剩余污泥破解效果明显,随作用时间延长,破解效果显著提升,但能耗也随之增大,EDR（energy disintegration ratio,效能比）明显下降.相同作用时间下,UC破解效果优于FS破解效果,UC破解剩余污泥的DD_COD（degree of disintegration,破解率）与EDR均明显高于FS方法.单因素试验得出的较优FS作用时间范围为2~8 min,较优UC作用时间范围为5~15 min.响应面法试验结果显示,联合工艺的剩余污泥破解效果和能量利用率均优于单一方法,联合工艺中FS-UC工艺的破解效果优于UC-FS工艺.FS-UC工艺的最佳参数:FS处理5.6 min再UC处理15.0 min,该条件下剩余污泥实际DD_COD为50.8%,EDR为26.8%.UC-FS工艺的最佳参数:先UC作用15.0 min再FS作用7.8 min,该条件下剩余污泥实际DD_COD为36.5%,EDR为17.1%.研究显示,以DD_COD和EDR为指标,4种工艺的高效性顺序为FS-UC > UC-FS > UC > FS,其中FS-UC工艺具有能耗低、破解效率高的特点,是4种工艺中剩余污泥破解效果最好的一种工艺.      

河北平原潮土中微生物对氮降解特征

了解土壤中微生物对氮素降解规律,对于土壤氮污染修复具有重要现实意义.从河北平原潮土中筛选出8种高效氨化细菌、硝化细菌、异养硝化好氧反硝化细菌,对所筛菌种进行16S r DNA分析,选出最适菌株通过固定化载体将菌种制成菌剂.探讨了用加入所筛菌种及拮抗菌的菌液和地表水分别滴灌小白菜对土壤中的氮降解产生的影响,并测定土样磷脂脂肪酸(PLFA)的值.结果表明:以硅藻土为载体硝化细菌的氨氮降解率达到38%,硝态氮合成率为205%;以硅藻土为载体的氨化细菌氨氮合成率为1 711%,异养硝化好氧反硝化细菌的硝态氮降解率达到367%.加所筛菌液滴灌对土壤总氮和氨氮的降解效果较好,硝化作用也较强,加菌后土壤中微生物量明显增加,且更快到达峰值.对不同土样不同时间磷脂脂肪酸数据分析发现,在白菜生长过程中,土壤中的微生物含量均产生了1次峰值,且加入所筛菌的先到达峰值.对于任丘和阜城土样来说,加入所筛菌后,土壤中微生物种类相应增多,对土壤微生物环境有所改善,微生物也比较活跃.     

流化床焚烧含盐苯胺废液的NOx排放特性

在流化床焚烧实验装置上进行含盐苯胺(C6H5NH2)废液的焚烧实验研究,用IMR-IMR2800P废气分析仪对焚烧尾气成分进行了在线监测,考察了焚烧工艺条件对NOx排放浓度的影响规律.结果显示:采用分级燃烧工艺和提高焚烧温度,可以降低NOx浓度;增大进料速率却导致NOx排放浓度的增加.当过剩空气系数(α)低于1.0时,NOx排放浓度随着α的增大急剧上升;大于1.1时,NOx排放浓度随α增加而减小.苯胺废液高温焚烧时添加氯化钠能降低NOx排放.     

链霉菌FX645对偶氮染料红AR30的降解机制研究

从印染厂污泥中筛选到1株对偶氮染料红30(AR30)具有较强脱色降解作用的菌株Streptomyces sp.FX645.通过降解产物的紫外-可见吸收光谱、LC-MS分析及各降解产物在发酵体系中浓度随时间变化的规律,探讨了菌株FX645对AR30的可能降解途径,首先在偶氮还原酶的作用下AR30发生偶氮键的裂解,生成4-硝基-2,6-二氯苯胺与2-[(4-胺苯基)-(2-氰乙基)-氨基]乙酸乙酯,然后分别发生硝基还原、氨基酰化、氰基水解作用,生成一系列的苯胺类化合物.     

氟虫双酰胺在水稻和稻田中的残留动态研究

采用超高效液相色谱法(UPLC)测定了氟虫双酰胺19.8%悬浮剂(SC)在水稻及稻田环境中的残留动态.结果表明,当氟虫双酰胺及其代谢产物NNI-des-iodo的添加量为0.05～1.0 mg·kg-1时,其在水稻田土壤、田水、稻秆、稻米和稻壳中的平均回收率为78.2%～104.8%,变异系数为1.1%～4.4%.氟虫双酰胺在2011年三地(福建福州、天津、江苏南京)的稻田水中的降解半衰期为9.8～17.3 d,土壤中10.8～22.4 d,植株中7.6～17.3 d,其在稻田水样品中检出了代谢产物NNI-des-iodo,而在土壤和植株样品中未检出.在推荐使用剂量下,于末次施药10 d后,氟虫双酰胺在水稻稻米中的残留量均低于美国规定的在稻谷上的最大残留允许量(0.5 mg·kg-1).     

扑草净降解菌的分离、筛选与鉴定及降解特性初步研究

从安徽农药厂废水处理系统的活性污泥中筛选扑草净(prometryne)降解菌.通过富集驯化和选择性培养筛选纯化细菌,分离到2株细菌,分别命名为P-1、P-2.根据表型特征、生理生化特性和16S rDNA序列同源性分析:P-1为G-,鉴定为苍白杆菌属(Ochrobactrum);P-2为G+,鉴定为芽胞杆菌属(Bacillus).GenBank登录号分别为HM004554和HM004555.通过12 d液体降解实验,菌株P-1、P-2对40 mg.L-1扑草净降解率分别达到46.5%和65.4%.该研究为扑草净的生物降解与污染土壤的生物修复提供了依据.     

Degradation of direct azo dye by Cucurbita pepo free and immobilized peroxidase

Enzymatic decolourization of the azo dye, Direct Yellow (DY106) by Cucurbita pepo (courgette) peroxidase (CP) is a complex process, which is greatly affected by pH, temperature, enzyme activity and the concentrations of H₂O₂ and dye. Courgette peroxidase was extracted and its performance was evaluated by using the free-CP (FCP) and immobilized-CP (ICP) forms in the decolourization of DY106. Immobilization of peroxidase in calcium alginate beads was performed according to a strategy aiming to minimize enzyme leakage and keep its activity at a maximum value by optimizing sodium alginate content, enzyme loading and calcium chloride concentration. The initial conditions at which the highest DY106 decolourization yield was obtained were found at pH 2, temperature 20℃, H₂O₂ dose 1 mmol/L (FCP) and 100 mmol/L (ICP). The highest decolourization rates were obtained for dye concentrations 50 mg/L (FCP) and 80 mg/L (ICP). Under optimal conditions, the FCP was able to decolorize more than 87% of the dye within 2 min. While with ICP, the decolourization yield was 75% within 15 min. The decolourization and removal of DY106 was proved by UV-Vis analysis. Fourier transform infrared (FT-IR) spectroscopy analysis was also performed on DY106 and enzymatic treatment precipitated byproduct.     

Biodegradation of 2-methylquinoline by Enterobacter aerogenes TJ-D isolated from activated sludge

Bacterial strain Enterobacter aerogenes TJ-D capable of utilizing 2-methylquinoline as the sole carbon and energy source was isolated from acclimated activated sludge under denitrifying conditions. The ability to degrade 2-methylquinoline by E. aerogenes TJ-D was investigated under denitrifying conditions. Under optimal conditions of temperature (35℃) and initial pH 7, 2-methylquinoline of 100 mg/L was degraded within 176 hr. The degradation of 2-methylquinoline by E. aerogenes TJ-D could be well described by the Haldane model (R² > 0.91). During the degradation period of 2-methylquinoline (initial concentration 100 mg/L), nitrate was almost completely consumed (the removal efficiency was 98.5%), while nitrite remained at low concentration (< 0.62 mg/L) during the whole denitrification period. 1,2,3,4-Tetrahydro-2-methylquinoline, 4-ethyl-benzenamine, N-butyl-benzenamine, N-ethyl-benzenamine and 2,6-diethyl-benzenamine were metabolites produced during the degradation. The degradation pathway of 2-methylquinoline by E. aerogenes TJ-D was proposed. 2-Methylquinoline is initially hydroxylated at C-4 to form 2-methyl-4-hydroxy-quinoline, and then forms 2-methyl-4-quinolinol as a result of tautomerism. Hydrogenation of the heterocyclic ring at positions 2 and 3 produces 2,3-dihydro-2-methyl-4-quinolinol. The carbon-carbon bond at position 2 and 3 in the heterocyclic ring may cleave and form 2-ethyl-N-ethyl-benzenamine. Tautomerism may result in the formation of 2,6-diethyl-benzenamine and N-butyl-benzenamine. 4-Ethyl-benzenamine and N-ethyl-benzenamine were produced as a result of losing one ethyl group from the above molecules.     

纳米Fe_3O_4/膨润土的制备、表征及光催化降解焦化废水

以铝柱撑膨润土负载纳米Fe_3O_4制备出性能良好的复合型催化剂。结合X射线粉末衍射(XRD)、扫描电镜(SEM)和比表面孔隙分析(BET)对催化剂的晶相、比表面积和粒度进行表征。负载的纳米Fe_3O_4粒径约为20～30nm,均匀分散到膨润土表面,未发生明显的团聚。在紫外光作用下用该催化剂对焦化厂二沉池出水进行深度处理。结果表明,在催化剂投加量为0.7 g/L,pH为2.5,温度40℃,H_2O_2初始浓度为17.6mmol/L的反应条件下,二沉池出水(化学需氧量COD=140mg/L,色度=400度)经催化氧化降解后,COD和色度可分别降低到54.44 mg/L和10度,达到国家工业再生用水水质标准GB/T 19923-2005(COD≤60 mg/L,色度≤30度)。催化剂重复使用4次时,废水COD和色度去除率保持稳定。