基于ASPEN的酸性水泄漏应急处置装置设计与优化

针对厂区的含硫化氢酸性水泄漏设计了一套应急处置装置,以氢氧化钠溶液为吸收剂,采用Aspen Plus标准大型通用流程模拟软件对受限空间内硫化氢洗消装置的洗消过程进行模拟,分别考察液气比、操作气速、硫化氢进口浓度、洗消液浓度、填料比表面积等因素对硫化氢脱除效率的影响。结果表明:综合考虑洗消效果、功率消耗等,所设计的硫化氢洗消装置液气比宜选择为6~7L/m3、进气量为300Nm3、硫化氢入口浓度不大于2 000ppm、洗消液质量分数不大于4%、填料比表面积在350m2/m3以上,在此优化条件下,硫化氢的出口浓度可降低到满足30ppm的应急排放标准要求。该研究可为酸性水泄漏应急处置装置的设计与优化提供技术支持。     

酸性水储罐安全性研究

为预防酸性水储罐气相空间闪爆事故的发生,取样分析了某炼厂酸性水罐气相空间组成,根据气相组成配制了3种混合可燃气体,利用5 L爆炸极限测试仪测定了混合可燃气体在不同氧含量条件下的爆炸极限,根据爆炸极限数据计算出3种混合可燃气体的极限氧含量。结果表明:随着体系中氧含量增加,爆炸上限明显升高,爆炸下限无明显变化;烃类物质含量高时,混合可燃气体的爆炸上下限均降低,爆炸极限宽度变小;硫化氢和氢气含量高时,混合可燃气体爆炸上下限均升高,爆炸极限宽度变大;3种气相组成的极限氧含量分别为:8.1%、9.9%和10.3%,为防止罐顶气相组成发生闪爆,建议氧含量浓度控制在4%以内,当氧含量浓度到达5%时建议启动氮气联锁进行惰化和稀释。     

碱性高炉矿渣制备多孔混凝土掺合料及其净化酸性水的试验研究

碱性高炉矿渣和多孔混凝土都有良好的净水性能,将碱性高炉矿渣作为掺合料制成掺高炉矿渣多孔混凝土(BSPC),对其处理模拟酸性水的效果进行研究。结果表明:经BSPC处理后,进水p H由2~3变成8.5~9.1。与普通多孔混凝土相比,添加高炉矿渣的混凝土对酸性水浊度、CODcr、TP和Cd的平均去除率依次提高了6.2%,8.8%,5.2%和4.5%,分别达到74.3%,74.5%,91.7%和86.5%。同时,BSPC孔隙率在处理酸性水前后有所下降,下降幅度较小,为6.2%,不影响BSPC对酸性水的处理。实验最后对混凝土表面白色絮状物进行了红外和XRD表征,初步分析其中含有CaCO_3、SiO_2和水化硅酸钙(C-S-H)等无机物,初步判定来源于BSPC的溶出物。     

模拟染料废水电凝聚脱色过程主导机理研究

通过采用不同阳极电凝聚方法对三种模拟染料废水开展处理,并对反应过程进行分析,对废水主要脱色机理进行了判断。结果表明,脱色过程主要是由于金属电解后产生的金属离子絮凝剂的絮凝和电解气浮作用,而不是直接或间接电氧化或还原过程。     

Ag-AgI/CN/MA复合物的制备及其可见光催化性能

采用沉淀法和热聚合法分别将AgI、氮化碳(CN)负载在介孔γ-Al_2O_3(MA)上,并通过光还原银离子成功制备了等离子体诱导可见光催化剂Ag-AgI/CN/MA.利用X射线衍射(XRD)、X射线光电子能谱(XPS)、场发射扫描电子显微镜(FESEM)、紫外可见漫反射光谱(UV-vis DRS)和透射电子显微镜(TEM)对Ag-AgI/CN/MA复合材料进行表征,并对其在可见光照射下(λ420 nm)的光催化性能进行了研究,考察了初始溶液pH值及催化剂投加量等条件对光催化反应的影响.结果表明,表面银以Ag+和Ag0形式共存,并且Ag和AgI均匀地分散在CN的表面.与CN和Ag-AgI/MA相比,Ag-AgI/CN/MA复合物对甲基橙(MO)具有更高的可见光催化降解效率,且反应过程中Ag+的释放量显著减少,显示出良好的稳定性.当溶液pH值为7、催化剂投加量为1 g·L~(-1)时,Ag-AgI/CN/MA-2显示出最优的催化性能.同时,其对罗丹明B(Rh B)、甲基红(MR)和刚果红(CR)等不同电性的染料均体现出良好的催化性能.     

微生物-化学水解联合作用下烟嘧磺隆的降解

从被烟嘧磺隆污染的人工湿地土壤中分离出1株能够在葡萄糖存在下降解烟嘧磺隆的微生物,通过16S rDNA序列同源相似性分析,初步鉴定该微生物为Klebsiella sp..它能够以烟嘧磺隆为唯一氮源生长,其最适生长条件为:温度35℃,初始pH为中性偏酸.水解试验表明,烟嘧磺隆在中性和碱性条件下比较稳定,在酸性条件下水解较快.生物降解试验发现,当培养液中葡萄糖浓度为5 g.L-1时,在温度35℃、初始pH为7的条件下培养10 d后烟嘧磺隆有99.4%得到降解,同时溶液的pH从7.0降低至4.0;而降低葡萄糖浓度分别为500 mg.L-1和100 mg.L-1时,培养10 d后烟嘧磺隆的降解率仅为11.7%和6.6%,溶液的pH始终在7左右.进一步研究表明烟嘧磺隆的降解是由于微生物代谢葡萄糖产生了酸性环境,pH降低引起了烟嘧磺隆水解,菌种对烟嘧磺隆降解的实质是微生物-化学水解联合作用.     

Degradation of direct azo dye by Cucurbita pepo free and immobilized peroxidase

Enzymatic decolourization of the azo dye, Direct Yellow (DY106) by Cucurbita pepo (courgette) peroxidase (CP) is a complex process, which is greatly affected by pH, temperature, enzyme activity and the concentrations of H₂O₂ and dye. Courgette peroxidase was extracted and its performance was evaluated by using the free-CP (FCP) and immobilized-CP (ICP) forms in the decolourization of DY106. Immobilization of peroxidase in calcium alginate beads was performed according to a strategy aiming to minimize enzyme leakage and keep its activity at a maximum value by optimizing sodium alginate content, enzyme loading and calcium chloride concentration. The initial conditions at which the highest DY106 decolourization yield was obtained were found at pH 2, temperature 20℃, H₂O₂ dose 1 mmol/L (FCP) and 100 mmol/L (ICP). The highest decolourization rates were obtained for dye concentrations 50 mg/L (FCP) and 80 mg/L (ICP). Under optimal conditions, the FCP was able to decolorize more than 87% of the dye within 2 min. While with ICP, the decolourization yield was 75% within 15 min. The decolourization and removal of DY106 was proved by UV-Vis analysis. Fourier transform infrared (FT-IR) spectroscopy analysis was also performed on DY106 and enzymatic treatment precipitated byproduct.     

酸性矿山废水的治理技术现状及进展

酸性矿山废水(AMD)是矿山废水中危害最严重的一类废水,其产生原因和治理技术引起了广泛的重视。介绍了酸性矿山废水的主要产生原因,综述了国内外治理酸性矿山废水技术的研究现状,包括化学法、物理法、生物法、湿地法等,讨论了相关技术存在的问题,并总结了酸性矿山废水技术的新进展和发展趋势。     

Adsorption of Cr(Ⅲ) from acidic solutions by crop straw derived biochars

Cr（Ⅲ） adsorption by biochars generated from peanut, soybean, canola and rice straws is investigated with batch methods. Adsorption of Cr（Ⅲ） increased as pH rose from 2.5 to 5.0. Adsorption of Cr（Ⅲ） led to peak position shifts in the FFIR-PAS spectra of the biochars and made zeta potential values less negative, suggesting the formation of surface complexes between Cr^3＋ and functional groups on the biochars. The adsorption capacity of Cr（Ⅲ） followed the order： peanut straw char 〉 soybean straw char 〉 canola straw char 〉 rice straw char, which was consistent with the content of acidic functional groups on the biochars. The increase in Cr^3＋ hydrolysis as the pH rose was one of the main reasons for the increased adsorption of Cr（Ⅲ） by the biochars at higher pH values. Cr（llI） can be adsorbed by the biochars through electrostatic attraction between negative surfaces and Cr^3＋, but the relative contribution of electrostatic adsorption was less than 5%. Therefore, Cr（Ⅲ） was mainly adsorbed by the biochars through specific adsorption. The Langumir and Freundlich equations fitted the adsorption isotherms well and can therefore be used to describe the adsorption behavior of Cr（Ⅲ） by the crop straw biochars. The crop straw biochars have great adsorption capacities for Cr（Ⅲ） under acidic conditions and can be used as adsorbents to remove Cr（Ⅲ） from acidic wastewaters.     

凹凸棒石基复合材料处理印染废水的研究

以凹凸棒石为载体,钛酸四丁酯为原料,通过溶胶-凝胶法,制成TiO2/凹凸棒石基复合材料(TiO2/ATT),并对所制得的复合材料进行了XRD和BET表征。在波长为254 nm的16 W紫外灯光照下,以活性黑KN-B印染废水为脱色对象,分别探讨了TiO2/凹凸棒石复合材料的煅烧温度、投加量、活性黑KN-B染料的初始浓度、溶液的pH值和反应温度等因素对印染废水脱色率的影响。实验结果表明:用煅烧温度500℃的TiO2/凹凸棒石基复合材料处理活性黑KN-B印染废水,催化剂的投加量为15 g/L、活性黑KN-B的初始浓度为10 mg/L、pH小于7、反应温度为20℃时,光催化反应4 h内即能达到较高的去除率,对活性黑KN-B的脱色率可达95%以上。