从自燃煤矸石中提取聚合铝铁(PAFC)的试验研究

采用盐酸酸浸的方法从自燃煤矸石中提取聚合铝铁，对煤矸石的粉碎粒径、酸浸盐酸的浓度及用量、酸浸的温度等工艺条件进行了试验研究。结果表明，从100g自燃煤矸石中，可提取19．85g固体聚合铝铁，成品的Al2O3含量33％、Fe2O3含量16％、盐基度70％。     

铁修饰的污泥生物炭对污泥脱水性能的改善效果

为改善城市污水处理厂污泥的脱水性能,采用铁修饰污泥生物炭作为助滤剂,与FeCl₃一起对污泥进行联合调理。以污泥净产率、污泥比阻和泥饼含水率评价污泥脱水性能;通过污泥Zeta电位、扫描电镜、EDS和泥饼可压缩性系数分析该方法的机理;同时,通过对污泥胞外聚合物、重金属以及总氯含量的分析,探究其调理污泥的环境风险,以明确该方法用于改善污泥脱水性能的可行性。结果表明,在500 ℃下制备的铁修饰污泥生物炭(30%)和FeCl₃(12.82%)联合调理时,污泥脱水的效果最佳;与仅用FeCl₃(12.82%)调理的污泥相比,污泥净产率升高了73.38%、污泥比阻降低了68.75%、泥饼含水率降低了9.03%。在较高温度下制备的铁修饰污泥生物炭,其孔隙结构更为发达、表面铁元素含量更高;与FeCl₃联合调理污泥时,更容易发生絮凝,从而使泥饼的渗透性能更好。而且,在联合调理的条件下,污泥中溶解型、松散结合型和紧密结合型胞外聚合物的含量均有所降低;污泥泥饼中重金属(Cd、Cr、Cu、Pb、Zn)更为稳定,泥饼热解固相产物和非固相产物中总氯含量降低,环境生态风险更小。采用铁修饰污泥生物炭作为助滤剂,可改善污泥脱水性能,并具有实际应用的潜力。     

聚合氯化铝铁去除微污染水体中藻类的研究

以聚合氯化铝铁(PAFC)为絮凝剂,H2O2为预氧化剂,用正交实验研究了PAFC处理微污染水体中藻类和降低浊度,得出正交实验中各因素的主次关系及对除藻和除浊度的影响,研究表明,ρPAFC是影响除藻和除浊度的重要因素.在最佳处理条件,即ρPAFC为20 mg/L,ρH2O2为6 mg/L,pH为7,搅拌时间为4 min,能使水体中藻细胞街度从9.4×107 cells/L降至3.16×106 cells/L,除藻率为96.6%,浊度降至0.70 NTU,除浊度率达93.0%.     

NaCl和KCl对厌氧污泥抑制的动力学研究

在厌氧颗粒污泥和厌氧絮状污泥系统中,进行盐质量浓度(NaCl或KCl质量浓度,下同)对厌氧污泥抑制动力学的研究,得到不同拟合的COD降解动力学方程及参数.实验结果表明:当盐质量浓度为10～30 g/L时,KCl对厌氧污泥的COD比降解速率的抑制程度大于NaCl;当盐质量浓度由0 g/L增至10 g/L时,半速率常数逐渐增加;当盐质量浓度由10 g/L增至30 g/L时,半速率常数逐渐减小;在厌氧污泥系统中,NaCl抑制作用下的盐抑制常数高于KCl,且颗粒污泥的盐抑制常数高于絮状污泥.     

钛白副产硫酸亚铁的综合利用研究

以钛白副产硫酸亚铁、氯化钾和氨水为原料，采用硫酸钾铵法制取硫酸钾。实验结果表明，该工艺生产的产品，其质量达到ZBG-21006-89国家标准，且此工艺流程简单、操作方便、条件易控制，无二次污染。     

高铁铝矾土制备聚合氯化铝铁及其在污水处理中的应用研究

利用含铁的低品位铝矾土为主要原料,添加适量铝酸钙粉,制备出絮凝剂聚合氯化铝铁.制备方法为酸溶两步法.对影响聚合铝铁制备的因素,如盐酸浓度、盐酸用量、温度和铝酸钙粉用量等进行了系统研究,得到了制备聚合铝铁的优化条件,同时将该絮凝剂用于实际工业污水的处理.研究结果表明：制备的絮凝剂絮凝效果明显优于一些传统的絮凝剂;不仅具有去浊性能好、沉降快的优点,而且具有原料易得,制备成本低的优势.     

Formation of dioxins from combustion of polyvinylidene chloride in a well-controlled incinerator

Polyvinylidene chloride (PVDC; polymer of 1,1-dichloroethylene) was combusted with paper in a well-controlled, small-scale incinerator at an average grate temperature of 700 °C, and then dioxins (PCDDs, PCDFs, and coplanar-PCBs) formed in the exhaust gases were analyzed by gas chromatography/mass spectrometry. PVDC lowered the combustion temperature due to its less flammable character. The amount of total dioxins (PCDDs + PCDFs + coplanar-PCBs) formed in the exhaust gas was 58.0 ng/g of a combustion sample and its toxicity equivalency quantity (TEQ) value was 0.64 ng-TEQ/g. The amount of PCDDs formed in the sample ranged from 2.33 ng/g (Cl₈-isomer) to 0.048 ng/g (Cl₁-isomer). The lower the number of chloride, the less production of PCDDs. On the other hand, there was no relation between the number of chloride and PCDF formation. The amount of PCDFs formed in the sample ranged from 8.02 ng/g (Cl₂-isomer) to 4.46 ng/g (Cl₈-isomer). A polyvinylchloride (PVC) sample produced 207 ng/g of total dioxins and a PVDC sample produced 57.4 ng/g of total dioxins when they were combusted under the same conditions. An approximately equal composition of dioxin isomers was formed from PVDC and PVC samples. Paper was found to contribute to PCDF formation when it was combusted with plastics.     

The influence of ClO− and acidity in the reaction between H2O2 and CuCl2

The potentially explosive reaction of hydrogen peroxide (H₂O₂) and copper chloride (CuCl₂) was investigated. Pressure tests revealed that the reaction was strongly temperature - dependent and can easily undergo runaway reaction. Nevertheless, there was only a slight pressure increase at the low temperatures studied or when using low concentrations of CuCl₂. Under the conditions generating the slight pressure increase, hypochlorite anions (ClO⁻) are generated and the acidity increases. As the reaction reaches completion, ClO⁻ disappears, and the acidity decreases. Interestingly, the addition of phosphate buffer to maintain the weakly acid conditions led to a runaway reaction, and the use of basic ClO⁻ promoted the exothermic reaction. Based on the results, acidity has a strong impact on the reaction behaviour.     

湖库型饮用水源蓝藻水华应急处置模拟实验

水源水体富营养化及造成的藻类水华是淡水生态系统面临的主要问题之一,严重威胁城市供水。以华南地区赤水水库为例,基于2019年5月暴发的蓝藻水华事件,开展了水库水质、蓝藻密度的监测分析及壳聚糖改性高岭土复合聚合氯化铝的应急除藻技术研究,确定了絮凝剂的最佳投加量并评估了除藻效果。结果表明: 水华暴发时取水口表层TN、TP浓度超过地表水III标准且水体主要限制性元素为磷,若集水区内磷的浓度继续增大,则水华暴发的频率继续增加;此次蓝藻水华的优势种为铜绿微囊藻,且垂向主要聚集在表层及水下5 m处,随水深的增加藻细胞密度逐渐降低,表层藻细胞密度高达6.87×10⁸ cells·L⁻¹;采用壳聚糖改性高岭土复合聚合氯化铝去除蓝藻效果较好,在改性黏土投加100 mg·L⁻¹,聚合氯化铝投加10 mg·L⁻¹时,1 h去除率约60%,且随着时间延长,去除率持续提高。改性黏土复合聚合氯化铝能在短期内使藻类沉降至水库底部,可应用于湖库型饮用水源蓝藻水华的应急处置。     

混凝-超滤工艺处理饮用水厂滤池反冲洗水和排泥水的效能

为探究饮用水厂滤池反冲洗水和排泥水的直接回用和处理后回用对水厂的影响及两类水处理过程中的差异,采用了污染负荷计算、实验室混凝小试和现场混凝-超滤中试装置对两类生产废水分别进行了研究。溶解性有机碳(dissolved organic carbon,DOC)、氨氮 (NH₄⁺-N)、Al³⁺和全氟类化合物(perfluorinated compounds,PFASs)的污染负荷计算结果表明生产废水直接回用会为水厂带来一定的额外负荷,其中排泥水和反冲洗水分别对PFASs和Al³⁺负荷贡献较大;通过对小试中浊度,UV₂₅₄以及5种荧光组分去除效果的对比,反冲洗水的混凝效果稍好于排泥水,同时10 mg·L⁻¹的聚合氯化铝为最佳混凝剂方案;在中试过程中,两类水中的浊度、有机物、Al³⁺和PFASs均可被有效去除,出水差异较小,但反冲洗水中的亲水性和小分子有机物使得其去除效果低于排泥水。总体来说,经过处理之后,两类生产废水均可回用,回用可有效减少废水排放量,提高水厂水资源利用率。