磷石膏制硫酸钾中试研究

以湿法磷酸副产的磷石膏和工业品氯化钾为原料 ,采用两步法 ,常温常压下 ,在 5 0 0 0t a工业化装置中 ,生产符合国标ZBG2 10 0 6 89农用一级品硫酸钾。整个过程流程较简单 ,能耗低 ,投资省 ,基本无“三废”排放。钾的收率达70 %。工艺条件稳定 ,产品质量稳定。中试结果与小试有较好的重复性 ,放大效果好。     

Fenton反应中氧化还原电势的变化规律

Fenton反应中,由于各种介质价态及形态的改变,氧化还原电位(ORP)也随之发生变化．在滴加H2O2过程中,H2O2／[Fe^2 ]0的摩尔比小于0．75时,ORP的升高是一个快速过程;大于0．75后,ORP的变化趋于缓慢．当体系中没有加入有机物时,随着过量H2O2的加入,Fe^2 以微量且较稳定的浓度存在,体系的ORP也保持较稳定的状态;当加入石油烃后,伴随着H2O2浓度降至微量,少量Fe^3 能被有机自由基还原成Fe^2 ,相对应的ORP也出现下降．不同H2O2浓度对应不同的ORP曲线,H2O2浓度愈高,ORP最大值出现得也愈迟．通过研究ORP的变化规律,进一步揭示了Fenton反应的机理．     

Oxidative treatment of simulated dyehouse effluent by uv and near-UV light assisted Fenton's reagent

UV/Fenton, near-UV-visible/Fenton, dark Fenton, and H₂O₂/UV reactions have been used to treat simulated dyehouse effluents representing wastewater from the textile dyeing and rinsing process. Experiments were carried out in a lab - scale photochemical reactor using concentrations of 0.5–25 mM H₂O₂, 0.04-0.5 mM Fe²⁺-ion and different dilutions of textile wastewater. To assess the extent of mineralization, decolourization kinetics and the effect of different fight sources on treatment efficiency, DOC, optical density at 254 nm and 600 nm wavelength and residual H₂O₂ concentrations were measured during the course of the advanced oxidation reactions. Comparative evaluation of the obtained results revealed that the decolourization rate increased with applied H₂O₂ and Fe²⁺-ion dose as well as the strength of the synthetic textile wastewater. The best results were obtained by the near - UV/visible/Fenton process with a decolourization rate constant of 1.57 min⁻¹, a UV_254nm reduction of 97% and a DOC removal of 41% at relatively low doses of the H₂O₂ oxidant and Fe²⁺-ion catalyst within 60 min treatment time.     

卤素类阻燃剂的阻燃基础理论

本文从阻燃化学反应,化学键能,热传递和反应动力学角度分析勖类阻燃剂的阻燃机理。     

聚合氯化铁对浊度和腐殖酸的絮凝特性研究

采用聚合氯化铁(PFC)絮凝剂在不同pH条件下处理高岭土悬浮液和腐殖酸溶液, 测试了絮凝过程中的Zeta电位、浊度和腐殖酸的去除率变化.结果表明:pH=4时, PFC投加量最小, 剩余浊度最大,投加范围最窄;pH=7时次之;pH=10时由于Fe(Ⅲ)离子的正电荷减弱, 电中和能力不强, 而且同时产生Fe(OH)₃(s)的吸附作用使得剩余浊度最低, 投加范围最宽, 但投加量很大;在酸性条件下腐殖酸与Fe(Ⅲ)离子最容易发生络合反应;腐殖酸的存在并没有影响PFC的絮凝效果.     

电解对氯苯酚稀水溶液中脱氯降解机理研究

利用石墨电极进行了多种条件下对氯苯酚水溶液的电解研究。研究结果表明,CODCr去除率和脱氯率随电压的升高呈先升高后下降的趋势、随对氯苯酚质量浓度的升高呈指数下降、随溶液pH的升高而升高。碱性条件下电解效果明显优于中性和酸性条件。在电压为10V,pH≈12,电解100mg L的对氯苯酚溶液2h后,CODCr去除率可达52 94%,脱氯率达52 8%。由脉冲辐解瞬态吸收光谱可知,中性、酸性条件下降解机制均为OH·自由基的作用,经过瞬态分子OH-adducts(OH加合物)的中间产物进一步氧化降解;碱性条件下通过OH·自由基和对氯苯酚氧基负离子的阳极直接失电子氧化作用2种降解机制,经过瞬态分子氯代酚氧自由基中间产物氧化降解对氯苯酚,产物分析结果显示生成了对苯二酚和苯醌等中间产物。      

Fenton试剂催化氧化--混凝法处理焦化废水的实验研究

用Fenton试剂结合自制聚硅硫酸铝对焦化废水进行了催化氧化—混凝试验研究 ,选择了最佳的工作条件。结果表明 ,经氧化—混凝处理后废水的COD从 1 1 73mg/L降至 38.2mg/L ,去除率达 96 .7%。研究中还发现 ,Fenton试剂具有将废水的 pH值调节为 2 .5～ 3的特性 ,为该工艺实际处理焦化废水提供了科学依据     

粉煤灰--Fenton法处理酸性红印染废水

以美尔雅酸性红废水为研究对象 ,采用粉煤灰—Fenton法进行处理研究。确定了絮凝剂及其最佳浓度、粉煤灰和Fenton试剂处理的最佳条件。经处理后废水COD的去除率达 97%以上 ,色度去除率达 99%以上。     

渗滤液生化特性在Fenton处理过程中的变化

采用电解呼吸仪分析早、晚期渗滤的生化特性在Fenton过程前后的变化。根据BOD累积曲线 ,由非线性最小二乘法求解出第一阶段生化需氧量BODu 和一级生化动力学常数K。结果表明早期渗滤液易于生化降解 ,经Fenton氧化后 ,由于产生了毒性更强的中间产物 ,渗滤液的驯化时间反面延长 ,K值也略有下降。晚期渗滤液很难生化降解 ,经Fenton处理后其生化特性得到很大的改善。     

Evaluation of activated sludge properties’ changes in industrial-wastewater pre-treatment: role of residual aluminum hydrolyzed species with different polymerization degree

● Medium poly Al salts dominated the PAC residual salts with a rational dosage. ● Settlement flocculation effect under medium poly Al salts showed a better trend. ● Complex of medium poly Al salts and enzymes promoted cell activity. ● Medium poly Al salts were beneficial to the effluent indexes. With the widespread introduction of pre-coagulation prior to the biological unit in various industrial wastewater treatments, it is noteworthy that long-term accumulation of residual coagulants has certains effect on both micro and macro characteristics of activated sludge (AS). In this study, the morphology distributions of residual aluminum salts (RAS) and their effects on the removal efficiency of AS were investigated under different PAC concentrations. The results showed that the dominance of medium polymeric RAS, formed under an appropriate PAC dose of 20 mg/L enhanced the hydrophobicity, flocculation, and sedimentation performances of AS, as well as the enzymatic activity in cells in the sludge system, improving the main pollutants removal efficiency of the treatment system. Comparatively the species composition with monomer and dimer / high polymer RAS as the overwhelming parts under an over-dosed PAC concentration of 55 mg/L resulted in excessive secretion of EPS with loose flocs structure and conspicuous inhibition of cellular activity, leading to the deterioration of physico-chemical and biological properties of AS. Based on these findings, this study can shed light on the role of the RAS hydrolyzed species distributions, closely relevant to Al dosage, in affecting the comprehensive properties of AS and provide a theoretical reference for coagulants dosage precise control in the pretreatment of industrial wastewater.