Removal of Cs from water and soil by ammonium-pillared montmorillonite/Fe3O4 composite

To remove cesium ions from water and soil, a novel adsorbent was synthesized by following a one-step co-precipitation method and using non-toxic raw materials. By combining ammonium-pillared montmorillonite (MMT) and magnetic nanoparticles (Fe₃O₄), an MMT/Fe₃O₄ composite was prepared and characterized. The adsorbent exhibited high selectivity of Cs⁺ and could be rapidly separated from the mixed solution under an external magnetic field. Above all, the adsorbent had high removal efficiency in cesium-contaminated samples (water and soil) and also showed good recycling performance, indicating that the MMT/Fe₃O₄ composite could be widely applied to the remediation of cesium-contaminated environments. It was observed that the pH, solid/liquid ratio and initial concentration affected adsorption capacity. In the presence of coexisting ions, the adsorption capacity decreased in the order of Ca^2 + > Mg^2 + > K⁺ > Na⁺, which is consistent with our theoretical prediction. The adsorption behavior of this new adsorbent could be expressed by the pseudo-second-order model and Freundlich isotherm. In addition, the adsorption mechanism of Cs⁺ was NH₄⁺ ion exchange and surface hydroxyl group coordination, with the former being more predominant.     

A nanocomposite consisting of silica-coated magnetite and phenyl-functionalized graphene oxide for extraction of polycyclic aromatic hydrocarbon from aqueous matrices

In this study,graphene oxide was covalently immobilized on silica-coated magnetite and then modified with 2-phenylethylamine to give a nanocomposite of type Fe_3O_4@SiO_2@GO-PEA that can be applied to the magnetic solid-phase extraction of polycyclic aromatic hydrocarbons(PAHs) from water samples.The resulting microspheres(Fe_3O_4@SiO_2@GO-PEA) were characterized by Fourier transform-infrared spectroscopy(FT-IR),scanning electron microscopy(SEM),CHNS elemental analysis,and vibrating sample magnetometry(VSM) techniques.The adsorbent possesses the magnetic properties of Fe_3O_4 nanoparticles that allow them easily to be separated by an external magnetic field.They also have the high specific surface area of graphene oxide which improves adsorption capacity.Desorption conditions,extraction time,amount of adsorbent,salt concentration,and pH were investigated and optimized.Following desorption,the PAHs were quantified by gas chromatography with flame ionization detection(GC-FID).The limits of detection(at an S/N ratio of 3) were achieved from 0.005 to0.1 μg/L with regression coefficients(R~2) higher than 0.9954.The relative standard deviations(RSDs) were below 5.8%(intraday) and 6.2%(inter-day),respectively.The method was successfully applied to the analysis of PAHs in environmental water samples where it showed recoveries in the range between 71.7%and 106.7%(with RSDs of 1.6%to 8.4%,for n = 3).The results indicated that the Fe_3O_4@SiO_2@GO-PEA microspheres had a great promise to extraction of PAHs from different water samples.     

Magnetic pulse welding: Interface of Al/Cu joint and investigation of intermetallic formation effect on the weld features

This paper attempts to highlight emerging issues when joining dissimilar metal pairs by magnetic pulse welding. For this purpose, joint of Al/Cu and Al/Al welded with the same parameters are compared. Al/Cu combination involves a formation of an interfacial intermetallic phase whereas Al/Al joint is bonded by metal continuity at the interface. The intermetallic is found to be amorphous, nanoporous, and damaged by a multi-directional cracks. The formation of such features is respectively explained by a melting confined at the interface followed by high rate cooling, cavitation phenomenon and solidification shrinkage. Mechanical characterizations of the Al/Cu joint show brittle fracture at the interface with fragmentation of the [0] intermetallics (glass type rupture). The intermetallic defects such as pores and cracks strongly reduce the breaking load level when compared to the Al/Al case. On the other hand, the Al/Al joint shows ductile fracture with plastic deformation of the interface.     

高梯度磁除尘的实验研究

对磁性粉尘和非磁性粉尘进行了磁分离实验研究。结果表明,对磁性粉尘,磁除尘效率可达99％以上,而对非磁性粉尘,通过粉尘上磁,磁除尘效率可达90％以上。     

Coupling magnetic particles with flocculants to enhance demulsification and separation of waste cutting emulsion for engineering applications

Magnetic particles were coupled with a flocculant to enhance the demulsification and separation of waste cutting emulsions. The optimal magnetic particle size and critical magnetic field conditions were investigated to achieve large-scale engineering application of magnetic demulsification separation for waste cutting emulsion treatment. The micro-scale magnetic particles were found to show comparable effects to nano-scale magnetic particles on enhancing the demulsification and separation of cutting emulsions, which are beneficial for broadening the selectivity of low-cost magnetic particles. The critical magnetic separation region was determined to be an area 40 mm from the magnetic field source. Compared to the flocculant demulsification, the magnetic demulsification separation exhibited a significant advantage in accelerating flocs–water separation by decreasing the separation time of flocs from 180–240 min to less than 15 min, compressing the flocs by reducing the floc volume ratio from 60%–90% to lower than 20%, and showing excellent adaptability to the variable properties of waste cutting emulsions. Coupled with the design of the magnetic disk separator, continuous demulsification separation of the waste cutting emulsion was achieved at 1.0 t/hr for at least 10 hr to obtain clear effluent with 81% chemical oxygen demand removal and 89% turbidity reduction. This study demonstrates the feasibility of applying magnetic demulsification separation to large-scale continuous treatment of waste emulsion. Moreover, it addresses the flocs–water separation problems that occur in practical flocculant demulsification engineering applications.     

Weak magnetic field accelerates chromate removal by zero-valent iron

Weak magnetic field(WMF) was employed to improve the removal of Cr(VI) by zero-valent iron(ZVI) for the first time. The removal rate of Cr(VI) was elevated by a factor of 1.12–5.89 due to the application of a WMF, and the WMF-induced improvement was more remarkable at higher Cr(VI) concentration and higher p H. Fe2+was not detected until Cr(VI) was exhausted, and there was a positive correlation between the WMF-induced promotion factor of Cr(VI) removal rate and that of Fe2+release rate in the absence of Cr(VI) at pH 4.0–5.5. These phenomena imply that ZVI corrosion with Fe2+release was the limiting step in the process of Cr(VI) removal. The superimposed WMF had negligible influence on the apparent activation energy of Cr(VI) removal by ZVI, indicating that WMF accelerated Cr(VI)removal by ZVI but did not change the mechanism. The passive layer formed with WMF was much more porous than without WMF, thereby facilitating mass transport. Therefore,WMF could accelerate ZVI corrosion and alleviate the detrimental effects of the passive layer, resulting in more rapid removal of Cr(VI) by ZVI. Exploiting the magnetic memory of ZVI, a two-stage process consisting of a small reactor with WMF for ZVI magnetization and a large reactor for removing contaminants by magnetized ZVI can be employed as a new method of ZVI-mediated remediation.     

Magnetic resonance imaging of the fetus: A study of 20 cases performed without curarization

Twenty patients underwent magnetic resonance imaging (MRI) at a mean gestational age of 32 weeks. There were 12 patients with suspected fetal brain abnormality and four with intrauterine growth retardation (IUGR), while the remaining four cases were studied for other reasons. The MRI examinations were performed on a 0.5 Tesla machine, with surface coils. One minute acquisition time T1 sequences were used. All the studies were performed without fetal curarization, and only under maternal sedation using flunitrazepam given per os 1 h before MRI examination. Three examinations were incomplete because of fetal movement artefacts. In the remaining cases, MRI allowed the examination of fetal brain anatomy. In five cases, it helped to differentiate isolated hydrocephalus and corpus callosum agenesis. Sub-ependymal nodules were depicted in a case of fetal tuberous sclerosis. One suspected arachnoid cyst was proved to be an ultrasound artefact. Decreased fetal fat on MR images was correlated with low birth weight in cases of IUGR. Due to its better spatial resolution, ultrasonography was more accurate for the diagnosis of facial and lumbar anomalies. Fetal MRI may be performed without curarization. Surface coils allow the detailed analysis of brain parenchyma, and thus MRI is especially useful in the difficult prenatal diagnosis of fetal brain abnormalities.     

催化裂化催化剂的磁分离及再生回用技术的发展

重点介绍了国内外关于催化裂化平衡催化剂的化学再生方法（ＤＥＭＥＴ工艺）与物理分离方法（磁分离工艺）的机理、工艺及应用现状，提出了上述工艺在我国应用的前景及方向。     

Prenatal diagnosis of a craniopharyngioma using ultrasonography and magnetic resonance imaging

We report an infant with a craniopharyngioma which was detected in utero. Maternal uterine ultrasonography, done at 27 weeks because of polyhydramnios, revealed a 4 cm midline mass near the base of the fetal skull. At 31 weeks, magnetic resonance imaging of the maternal abdomen confirmed the presence of a mass in the region of the third ventricle and revealed hydrocephalus. Two days post-partum a computed tomography (CT)-guided needle biopsy of the mass was performed and recovered tissue which was histologically consistent with a craniopharyngioma. The infant' s postnatal period was complicated by seizures, which were treated with phenobarbital, and by progressive hydrocephalus, necessitating placement of a ventriculo-peritoneal shunt. He also received therapy for central hypothyroidism and diabetes insipidus. The infant' s parents refused permission for attempted resection of the tumour and he died at 8 weeks of age. This represents the second reported case of an antenatally detected craniopharyngioma. Four other cases of different intracranial tumours have been detected in utero using ultrasound, with no reported survivors past 3 days of age. There is a uniformly poor prognosis of such infants, but earlier diagnosis and intervention may change this result.     

利用铁粉与磁粉载体流化床反应器处理染料废水

研究了铁粉和磁粉为流化床载体,对模拟染料废水和实际染料废水进行处理,取得了不同实验条件下染料废水的脱色效果。结果表明,经铁粉处理30min后,其色度去除率达98%左右,实际染料废水的CODcr去除率为56%左右;经磁粉处理30min后,其色度去除率为95%左右,实际染料废水的CODcr去除率为34%。