秸秆发酵乳酸菌复合系SFC-2的构建及其组成多样性研究

为了获得促进作物干秸秆乳酸发酵的微生物,以玉米秸秆和水稻秸秆的自然发酵物为菌种来源,用MRS蔗糖培养基,通过连续定向继代培养,筛选出pH下降迅速、乳酸含量高、组成稳定的乳酸菌复合系SFC-2.DGGE分析表明,SFC-2经过连续继代培养,从第25代开始其微生物组成基本稳定.SFC-2 培养12 h后pH下降至3.8,乳酸含量达10.64 mg/mL,其中64%为L-(+) 乳酸.通过平板分离获得4株细菌,全部为Lactobacillus,其近缘种分别为L. fermentum、L. plantarum、L. paracasei和L. paracasei sub sp.;通过16S rDNA克隆文库分析获得7个克隆,其近缘种主要为L. fermentum、L. plantarum及L.paracasei;在16S rDNA的克隆文库中,76.3%为L. fermentum的近缘种,20.3%为L. plantarum的近缘种,3.4%为L. paracasei的近缘种.     

秸秆发酵产氢的影响因素研究

以加热预处理的厌氧活性污泥为接种物,以秸秆（稻草、麦杆）为发酵底物进行微生物产氢实验,研究了不同秸秆粒径、纤维素酶用量、预处理方法、发酵液pH值对秸秆发酵产氢速率以及产氢气量的影响.其中颗粒粒径为170 μm的稻草经过NaOH预处理,按照底物与纤维素酶用量1∶1的比例酶解,进而发酵产氢的单位总产氢量为90.5 mL/g,最大单位产氢速率为0.58 mL/(h·g).     

Anaerobic tapered fluidized bed reactor for starch wastewater treatment and modeling using multilayer perceptron neural network

Anaerobic treatability of synthetic sago wastewater was investigated in a laboratory anaerobic tapered fluidized bed reactor(ATFBR) with a mesoporous granular activated carbon(GAC)as a support material.The experimental protocol was defined to examine the effect of the maximum organic loading rate(OLR),hydraulic retention time(HRT),the efficiency of the reactor and to report on its steady- state performance.The reactor was subjected to a steady-state operation over a range of OLR up to 85.44 kg COD/(m~3.d).The COD removal efficiency was found to be 92% in the reactor while the biogas produced in the digester reached 25.38 m~3/(m~3·d) of the reactor. With the increase of OLR from 83.7 kg COD/(m~3.d),the COD removal efficiency decreased.Also an artificial neural network(ANN) model using multilayer perceptron(MLP)has been developed for a system of two input variable and five output dependent variables. For the training of the input-output data,the experimental values obtained have been used.The output parameters predicted have been found to be much closer to the corresponding experimental ones and the model was validated for 30% of the untrained data.The mean square error(MSE)was found to be only 0.0146.     

Effect of sulfate on the methanogenic activity of a bacterial culture from a brewery wastewater during glucose degradation

The maximum specific methanogenic activity （SMA） of a sludge originating from a brewery wastewater treatment plant on the degradation of glucose was investigated at various levels of sulfate on a specific loading basis. Batch experiments were conducted in serum bottles at pH 7 and 35℃. A comparison of the values indicates that the SMA of this mixed culture was increased and reached its highest level of 0.128 g CH4 gas COD/（g VSS.d） when biomass was in contact with sulfate at a ratio of 1：0.114 by weight.     

ABR处理硫酸盐有机废水的相分离特性研究

为了考察厌氧折流板反应器(ABR)处理含硫酸盐有机废水的相分离特性,采用有效容积为32L的五隔室ABR,通过为期132d的启动试验,研究了启动运行过程中各隔室COD和SO24-降解情况、VFA和S2-分布规律及颗粒污泥微生物相变化状况.结果表明,采用低负荷低增幅方式启动,在132d内成功启动ABR并达到稳定,COD和SO24-的负荷分别由1.5kg·(m3·d)-1逐渐提高到3.3kg·(m3·d-1)和由0.07kg·(m3·d-1)逐渐提高到0.18kg·(m3·d-1),COD和SO24-的去除率分别为95%和85%左右.各隔室COD沿程呈递减趋势,其去除主要由第1、4、5隔室完成,SO42-的去除主要由前面三隔室承担,前面三隔室的VFA和S2-浓度较高,到最后两隔室则急剧降低;随负荷的增加,承担COD及SO42-主要去除作用的隔室后移,前面三隔室的VFA和S2-最高点及最后两隔室的VFA和S2-的急剧降低位置也后移;各隔室的微生物经长期运行驯化后表现出良好的种群配合和高度的特异性,具有明显的产酸相与产甲烷相、硫酸盐还原相与硫单质生成相的分离特征.     

水热法制备BiVO4及其可见光催化降解糖蜜酒精废水

以Bi(NO3)3•5H2O为铋源,NH4VO3为钒源,采用简单的水热法制备了BiVO4 光催化剂,并用X-射线衍射(XRD)、扫描电子显微镜(SEM)、红外光谱(IR)和紫外-可见光漫反射光谱(UV-vis)对产品进行了结构表征。同时,在BiVO4光催化降解糖蜜酒精废水反应中考察了催化剂用量、通氧量、溶液pH值、双氧水用量及光照强度对糖蜜酒精废水脱色率的影响。实验结果表明,水热产品属于单斜晶系BiVO4,其带隙能为2.398 eV,并具有良好的可见光催化活性。当降解经30倍稀释的糖蜜酒精废水,BiVO4添加量为3.0 g•L−1 ,通氧量为120 L•h-1,助氧化剂H2O2添加量为9 %,不改变废水pH值,在400W镝灯离液面11cm照射反应180 min的条件下,糖蜜酒精废水的脱色率为88.60 %,COD去除率为25.84%,而添加5g•L−1的FeSO4•7H2O后其脱色率和COD去除率分别提高到90.90 %和91.26%。单斜晶型BiVO4晶体的可见光催化糖蜜酒精废水过程符合一级动力学反应。     

垃圾渗滤液的膜生物反应器与传统生物工艺述评

采用文献调研法比较评价了膜生物反应器与传统生物工艺对垃圾渗滤液的处理效果。结果表明,渗滤液的水质特征(主要指COD)主要由渗滤液年龄决定,B/C值和渗滤液年龄对COD去除有重要影响。传统生物处理常采用多级组合工艺,渗滤液特性、工艺单元数、水力停留时间和有机负荷率等是影响COD去除的重要参数。近年来,MBR工艺的应用日益广泛,对于B/C值较低的老龄渗滤液,MBR工艺可获得更好的COD去除效果,也有利于废水的膜深度处理。     

A~2/O工艺厌氧池有机物降解动力学模型对比研究

试验考察了东阿县污水处理厂一期A2/O工艺厌氧池去除有机污染物效能,当进水ρ(COD)为548.3 mg/L时,厌氧池平均去除率达78.7%。同时探讨了几种常见数学模型模拟厌氧池去除有机物规律情况,根据实际工程监测数据确定有机底物降解动力学常数,得出Grau模型、Stover-kincannon模型和改进的Monod模型较适合模拟厌氧池去除有机物的规律,并对模型进行了检验。     

酸化液对厌氧释磷好氧吸磷速率的影响研究

采用序批式试验研究了酸化液对聚磷菌厌氧释磷好氧吸磷速率的影响。同一活性污泥混合液中聚磷菌的释磷潜力相当,混合液中挥发性脂肪酸越多则越有利于激发聚磷菌的释磷潜能。酸化液投加量越大,对应的混合液中聚磷菌的平均释磷速率也越大。当酸化液投加量为30 mg/L(以TOC计)时,聚磷菌的平均释磷速率达0.137 mg/(mg.d),是未投加酸化液工况的3.26倍。聚磷菌厌氧释磷过程中,活性污泥的MLVSS值逐渐增大,而MLSS值却不断减小,这是由聚磷菌释磷反应过程中聚磷颗粒和糖原的消耗,以及PHB的生成而产生的。碳源充足与否,对聚磷菌的平均好氧吸磷速率影响不大,研究各工况中,聚磷菌的平均吸磷速率在0.129~0.160 mg/(mg.d)内。碳源越充足,则聚磷菌在好氧吸磷反应持续的时间越长,因此,具有更强的超量吸磷能力。酸化液投加量为20 mg/L时(以TOC计),聚磷菌在好氧吸磷结束时,出水的SP浓度能减少到0.5 mg/L以下。     

Enhancement of thermophilic anaerobic digestion of thickened waste activated sludge by combined microwave and alkaline pretreatment

Pretreatment of thickened waste activated sludge (TWAS) by combined microwave and alkaline pretreatment (MAP) was studied to improve thermophilic anaerobic digestion efficiency. Uniform design was applied to determine the combination of target temperature (110–210°C), microwave holding time (1–51 min), and NaOH dose (0–2.5 g NaOH/g suspended solids (SS)) in terms of their effect on volatile suspended solids (VSS) solubilization. Maximum solubilization ratio (85.1%) of VSS was observed at 210°C with 0.2 g-NaOH/g-SS and 35 min holding time. The effects of 12 different pretreatment methods were investigated in 28 thermophilic batch reactors by monitoring cumulative methane production (CMP). Improvements in methane production in the TWAS were directly related to the microwave and alkaline pretreatment of the sludge. The highest CMP was a 27% improvement over the control. In spite of the increase in soluble chemical oxygen demand concentration and the decrease in dewaterability of digested sludge, a semi-continuous thermophilic reactor fed with pretreated TWAS without neutralization (at 170°C with 1 min holding time and 0.05 g NaOH/g SS) was stable and functioned well, with volatile solid (VS) and total chemical oxygen demand (TCOD) reductions of 28% and 18%, respectively, which were higher than those of the control system. Additionally, methane yields (L@STP/g-CODadded, at standard temperature and pressure (STP) conditions of 0°C and 101.325 kPa) and (L@STP/g VSadded) increased by 17% and 13%, respectively, compared to the control reactor.