Fe2+-H2O2法处理DSD酸生产氧化母液的研究

为改善DSD酸氧化母液的可生化降解性,将废液先用有机絮凝剂TS-1(一种季胺盐)处理,TS-1的投加量为3g/L,其后用Fe²⁺-H₂O₂法氧化,Fe²⁺和H₂O₂的量分别为150mg/L,7g/L,废液COD和色度的去除率分别可达64%和62%。经处理后的废水,其BOD₅/COD≈0.3,可以认为已达到生化处理的要求。当H₂O₂的投量为2g/L,经Fe²⁺-H₂O₂氧化处理后的废液,再用FeCl₃进行两级混凝处理(FeCl₃的投加量分别为5g/L和2g/L),则COD和色度的去除率可达90%和95%。     

电解法处理活性染料废水的研究

某化工厂活性染料生产废水高CODCr值、高浓度、高色度、高盐分、成分复杂、有毒有害物质多、可生化性差。实验确定了废水经AS剂絮凝和电解预处理的研究方案。主要考察了电极极板材料、电解pH值、电解电压大小、电解时间和电极极板间距对CODCr去除效果的影响 ,从而确定了最佳电解条件 :采用石墨板电极 ,pH =3,电解电压 6 5V ,电解时间 5 0min ,电极极板间距 5cm。最佳条件下经放大实验 ,发现CODCr去除率高达 70 %以上。     

电化学法处理含盐染料废水

研究了电化学法处理含盐染料废水的可行性及其处理效果．结果表明,电化学法对废水的色度和COD具有良好的去除效果,电解过程中余氯的产生对色度和COD的去除有决定性作用．实验确定的高浓度含盐废水电化学处理条件为：电流密度0．017A/cm²,电压10．3V,平均电导率12．35ms/cm,电解60min,色度和COD的去除率分别为85％和99．8％．电解过程无难以继续反应的中间产物生成．     

Treatment of anthraquinone dye wastewater by hydrolytic acidification-aerobic process

Experiment on microbial degradation with two kinds of biological process, hydrolytic acidification-aerobic process and aerobic process was conducted to treat the anthraquinone dye wastewater with CODc, concentration of 400 mg/L and chroma 800. The experimental result demonstrated that the hydrolytic-aerobic process could raise the biodegradability of anthraquinone dye wastewater effectively. The effluent CODc, can reach 120-170 mg/L and chroma 150 which is superior to that from simple aerobic process.     

Photodegradation mechanism of two dyes: the influence of adsorption behavior on the novel TiO2 particles

The relationship between adsorption behavior and photocatalytic mechanism of the two dyes was investigated. Adsorption isotherms showed that the adsorption of cationic pink FG was Langmuir type behavior, while the reactive brilliant red k-2G was Freundlich type behavior. The increasing pH favored the adsorption of FG but have little effect on the photodegradation. The increasing pH favored the adsorption and the photodegradation of k-2G. The presence of scavenger of hvb^ and OH. radical potassium iodide inhibited the degradation of k-2G, free radicals scavenger tetranitromethane inhibited the photodegradation of FG. These results indicated that the photodegradation of FG mainly via free radicals in solution, and the photodegradation of k-2G was mainly on the catalysts surface or near the interface of solid and solution by react with hvb^ and surface-bound OH.. The different effect of SO4^2- , HCO3^- on the adsorption and photodegradation of two dyes confirmed these results.     

Indian dye yielding plants: Efforts and opportunities

The present review article deals with the information on the dye‐yielding plants of India. Dyes are intensively coloured compounds that are applied to a substrate such as fibre, paper, cosmetics, hair, etc. to give colours and can be extracted from the roots, fruits/berries, bark, leaves, flowers, and stem/wood, fungi, and lichens by various processes of extractions. In addition to their dye‐yielding characteristics, many of these plants possess medicinal values and can be used for multiple other purposes. Plant derived‐colours have an important role in human life because of their safe and eco‐friendly nature. But due to the availability of economically cheaper synthetic dyes, the indigenous knowledge of extraction, processing, and proper utilisation has been diminished. Nowadays, the demand for natural dyes has been increased worldwide due to awareness about their beneficial properties. It has been essential that proper documentation and measure of conservation should be undertaken to preserve these natural dye‐yielding plants. This review article is an aid to a collective inquiry into Indian dye plants.     

过硫酸钠氧化脱色罗丹明B——影响因素和机理

采用过硫酸钠(PDS)直接氧化和催化活化氧化脱色罗丹明B(RhB),分别考察了PDS剂量、pH、催化剂、Cl-浓度对RhB脱色的影响.结果表明,PDS在无外加催化剂下能够有效脱色RhB,pH越低,脱色率越高;当pH 2.4,PDS用量为3.5 g·L^-1,在120 min内RhB的脱色率可达92%;自由基淬灭实验表明,酸性条件下主要为PDS直接氧化脱色RhB,并存在小部分硫酸根自由基(SO₄4·-)作用.在pH 5.6、pH 8.0条件下,外加活性炭纤维(ACF)、四氧化三铁(Fe₃O₄4)、Fe₃O₄4负载型催化剂(ACF/Fe3O₄4)可促进PDS对RhB脱色;在pH 2.4条件下,外加ACF对RhB脱色的促进作用较小,Fe₃O₄4、ACF/Fe₃O₄4对RhB脱色有一定抑制作用.不同pH和催化剂处理下,低浓度Cl-(0.01、0.04 mO₄l·L^-1)对RhB脱色速率都呈现抑制作用,高浓度Cl-(0.08 mO₄l·L^-1)相对于低浓度Cl-处理都呈促进作用.不同浓度Cl-处理在反应前60 min RhB脱色速率差异较大,而反应120 min后脱色率差异较小.提出Cl-通过调控SO₄4·-脱色RhB途径来影响RhB脱色速率的机理,Cl-竞争消耗SO₄4·-降低RhB脱色速率,但经一系列反应生成的Cl2·-能与RhB快速反应而提高RhB脱色速率;Cl-对RhB的脱色反应速率的影响存在抑制-促进双重机制,且与Cl-浓度相关.研究结果为基于PDS直接氧化和催化氧化处理含盐染料废水的研究和应用提供了一定的理论依据.     

Decolorization and degradation of acid dyes mediated by salt fractionated turnip ( Brassica rapa ) peroxidases

Peroxidases from turnip roots (524?U?g^?1 of vegetable) were highly effective in decolorizing acid dyes having wide spectrum chemical groups. Dye solutions, containing 40–170?mg?dye?L^?1, were treated by turnip peroxidases (TP) (specific activity of 122.0?U?mg^?1 proteins). These enzymes were able to decolorize most of the acid dyes in the presence of 2.0?mM 1-hydroxybenzotriazole (HOBT). Increasing concentration of enzyme and time in the absence of HOBT did not influence dye decolorization. The rate of decolorization was significantly enhanced when HOBT was added to the decolorizing solutions. The decolorization of all the used dyes was maximum at pH 5.0 and 40°C. Complex mixtures of dyes were significantly decolorized when treated with enzyme in the presence of HOBT (2.0?mM). Phytotoxicity test based on Allium cepa root growth inhibition has shown that majority of the TP-treated dye product were not more toxic than their parent dye. Kinetic parameters of the TP with various dyes showed that this enzyme has highest affinity for Acid Yellow 42. This study demonstrates that the peroxidase/mediator system was an effective biocatalyst for the treatment of industrial effluents from textile, dye manufacturing, dyeing and printing industries or complex mixtures of dyes.     

Removal of Remazol Brilliant Violet-5R dye using periwinkle shells

The purpose of this research is to obtain optimal processing conditions for the adsorption of Remazol Brilliant Violet-5R (RBV-5R) dye onto activated carbon prepared from periwinkle shells (PSAC) by chemical activation with KOH using response surface methodology. Central composite design (CCD) was used to determine the effects of three preparation variables; CO₂ activation temperature, CO₂ activation time and KOH:char impregnation ratio (IR) on two responses; percentage RBV-5R dye removal and PSAC yield. Based on the CCD, two quadratic models were developed for percentage RBV-5R dye removal and PSAC yield, respectively. The most influential factor on each experimental design response was identified from the analysis of variance (ANOVA). The optimum conditions for the adsorption of RBV-5R dye onto PSAC were CO₂ activation temperature of 811 °C, CO₂ activation time of 1.70 h and IR of 3.0, resulting in 81.28% RBV-5R dye removal and 28.18% PSAC yield. PSAC prepared under optimum conditions was mesoporous with a Brunauer–Emmett–Teller surface area of 1894 m²·g^?1, total pore volume of 1.107 cm³·g^?1 and average pore diameter of 2.32 nm. The surface morphology and functional groups of the activated carbon were respectively determined from the scanning electron microscopy and Fourier transform infrared analysis.     

Fe-C-H_2O_2协同催化氧化处理印染废水

用Fe-C-H2O2协同催化氧化体系对印染工业废水的降解脱色处理进行了研究。对影响印染废水降解的几种因素如铁屑/碳粒质量比、双氧水的质量分数、废水pH等进行考察。试验结果表明,对于色度为650度和ρ（COD）为468mg·L-1的印染废水,在废水pH=4.8的情况下,当铁屑/碳粒质量比为25∶1、H2O2用量为150mg·L-1、催化反应30min时,印染废水的脱色率达98%以上,CODCr去除率可达78%。与Fe-C微电解法相比,Fe-C-H2O2协同催化氧化方法对印染废水的脱色能力和去除COD,表现出了更好的处理效果。