城市煤气化综合效益实例分析

本文以煤气化工程的典型实例分析为基础，通过对气源厂经济效益的分析，提出了以气化替煤量和节煤量两项指标，进行宏观经济效益、社会效益和环境效益的综合效益分析的步骤及相应的计算公式与方法。     

高温煤气脱硫剂研究进展

系统地介绍了国外高温煤气脱硫剂的研究开发现状,指出我国重点研究开发铁系、锰系、锌系、铜系和钙系脱硫剂。     

基于模糊贝叶斯网络的煤气化职业健康风险分析

针对煤气化行业职业健康风险影响因素不确定及模糊的特点,建立了职业健康风险计算模型。该模型将模糊数学与贝叶斯网络相耦合,模拟事件概率,找出导致风险的主要因素。通过分析煤气化行业中存在的多种风险因素,应用问卷调查法和模糊集理论模拟了根节点的发生概率,得出职业健康风险概率的预测值;应用贝叶斯网络反向推理的功能计算根节点后验概率并排序,确定了薄弱环节。该模型不仅能解决概率缺失情况下的风险量化推算问题,定量进行职业健康风险评估,还可以实现关键因素的识别,并能有针对性地提出改进措施,为职业健康风险预防提供决策依据。     

Analysis of energy recovery potential using innovative technologies of waste gasification

In this paper, two alternative thermo-chemical processes for waste treatment were analysed: high temperature gasification and gasification associated to plasma process. The two processes were analysed from the thermodynamic point of view, trying to reconstruct two simplified models, using appropriate simulation tools and some support data from existing/planned plants, able to predict the energy recovery performances by process application. In order to carry out a comparative analysis, the same waste stream input was considered as input to the two models and the generated results were compared. The performances were compared with those that can be obtained from conventional combustion with energy recovery process by means of steam turbine cycle. Results are reported in terms of energy recovery performance indicators as overall energy efficiency, specific energy production per unit of mass of entering waste, primary energy source savings, specific carbon dioxide production.     

Waste plastics recycling by an entrained-flow gasifier

We studied an entrained-flow gasification process which efficiently converts waste plastics to energy at a high energy recovery rate. Waste plastics, after being shredded to <8 mm or <14 mm, were fed into an entrained-flow gasifier with air and oxygen. In the gasifier, organic substances were pyrolyzed, partially combusted, and then converted into synthetic gas (CO, H₂) at a high temperature (over 1600 K). The clarified gasification characteristics were that the lower heat value (LHV) of the product gas was over 4.2 MJ/Nm³ and the cold gas efficiency was approximately 60%. Other inert substances in the wastes such as ashes and metals were melted into slag and condensed on bag filters. The bag filters and a water scrubber removed impurities such as dusts, heavy metals, and hydrogen halides from the product gases. Solid hydrocarbons, which include char and soot, were removed at a hot cyclone and on the bag filters. Received: July 19, 2000 / Accepted: October 3, 2000     

褐煤地下气化过程汞析出规律的研究

在褐煤地下气化模型试验的基础上 ,研究了褐煤中汞的赋存形态 ,褐煤地下气化煤气中汞含量的变化及存在形态 ,以及气化工艺的影响 ;分析了地下气化过程中汞的析出及反应机理 .实验结果表明 ,汞在试验褐煤中主要以硫化物结合态和残渣态形式存在 ;褐煤地下气化煤气中汞含量随气化时间的变化而变化 ,且主要以Hg0 (g)的形态存在 ;水蒸汽的存在会降低Hg0 (g)被其它气体氧化为Hg2 (g)的趋势 ;与地面气化及燃煤过程不同 ,煤地下气化产物中 ,气态汞占总汞比例低于 2 0 % ,明显低于地面气化及燃煤     

煤气化炉渣研究现状及利用技术展望

煤气化技术的应用是我国能源战略的重要一环,但同时也会产生大量的煤气化炉渣,亟需研究可批量消纳的资源化利用技术。煤炭灰分中各种矿物相在气化炉内会随温度发生变化,通过对该变化的研究和总结,描述了煤炭灰分中各种矿物相在气化炉内的物化反应过程,并指出煤炭灰分对煤气化炉渣的最终形态特点具有决定性的影响;对煤气化炉渣中残碳的组成及其变化特点的研究表明,残碳对煤气化炉渣的最终利用途径具有重要影响;此外,通过分析煤气化炉渣利用技术研究现状,指出建材化利用技术和掺烧循环流化床原料技术是目前的主流途径;最后,展望了煤气化炉渣利用技术的发展方向,并提出了煤气化炉渣用于混凝土和水泥原料以及井下回填的技术途径。     

废轮胎流化床气化特性试验研究

为了掌握废轮胎在流化床内的气化特性,利用自行设计的小型流化床试验装置系统,对废轮胎在不同的过量空气系数下在400～700℃温度范围内进行了空气气化实验.分析了废轮胎气化效率、固定碳转化率、气化气热值、产气量以及气化气成分随气化温度、过量空气系数的变化规律.结果表明,废轮胎气化的最佳运行条件为气化初始温度700℃,过量空气系数α=0.4.在此条件下得到的气化气成分主要包括CH₄、CO、H₂、C₂H₆和高分子有机化合物,此时的气化效率为47.96%,气化气低位热值为4 804kJ/m³.     

臭氧氧化—包埋菌流化床生物处理组合工艺深度处理煤气化废水

采用臭氧氧化—包埋菌流化床生物处理组合工艺对煤气化废水进行深度处理。实验结果表明：当臭氧的质量浓度20 mg/L、臭氧进气流量1.5 L/min、臭氧通气时间30 min、包埋菌流化床水力停留时间24 h时,臭氧氧化工序的COD去除率达到30.0%~40.0%,总酚去除率达到100.0%;包埋菌流化床工序的COD去除率达到60.0%以上,氨氮的去除率大于95.0%;经组合工艺处理后,出水COD<60 mg/L,ρ（氨氮）<1.0 mg/L,ρ（总酚）未检出,色度小于50倍,达到GB8978—1996《污水综合排放标准》中的一级排放标准。     

辽河油田稠油泥砂综合处理工艺的研究*

稠油污泥作为含油污泥的典型代表,其成分极为复杂、处理难度极大,由于目前国内外尚无成熟工艺可完全实现其"减量化、资源化、无害化处理",给油田生产和环境保护带来了严重影响。文章分析了稠油污泥的组成及性质,根据稠油污泥来源不同实施分类预处理,利用热风干化技术将其减量,经热解气化焚烧和热能利用,为实现含油污泥无害化处理进行了有益探索。