外磁场调控的聚合硫酸铁水解过程研究

基于聚合硫酸铁的UV-vis光谱学特征,利用外加电磁场对聚合硫酸铁进行磁化调控,研究了不同磁化时间和磁场强度对PFS中铁形态分布的影响.研究表明,水解过程中铁盐逐渐与羟基结合,存在由低聚态向相对较高聚态转化的趋势.整体来看,在一定范围内增加磁化时间和磁场强度可以有效促进絮凝剂的水解,但是在多工艺参数调控中,提升磁场强度能够获得更为明显的效果.通过上述研究表明,借助UV-vis光谱学特征变化的分析,可有效判断PFS在水解过程中的水解进程及转化.在相同磁场强度下,磁化4~6min时,由低聚态向高聚态转化速率更快.而在控制磁化时间相同的情况下,增大磁场强度相应水解产物的转化速率也会提高1.9%~12.3%.该研究为设计适当的磁场强度获得更好的磁絮凝效果以及PFS絮凝工艺的调控提供更为科学有效的理论指导.     

铁铝吸附剂对起爆药污染土壤中锑的稳定化研究

采用3种铁基吸附剂（FeSO₄•7H₂O、针铁矿、Fe⁰）和铝基吸附剂（Al（OH）₃）,对某起爆药污染场地土壤中锑（Sb）进行稳定化处理,通过等温吸附实验、批量浸出实验、比表面积测定以及BCR分析,研究了铁、铝单一和混合吸附剂的稳定化效果以及稳定化前后土壤比表面积及Sb形态的变化.结果表明：不同铁基吸附剂对Sb的等温吸附符合Freundlich模型,FeSO₄ （log K_f= 5.85）的吸附能力明显高于Fe⁰ （log K_f = 3.21）和针铁矿（log K_f = 4.32）;稳定时间为10d的条件下,不同铁基吸附剂对Sb的稳定化效率随添加量的增大而提高,且10%FeSO₄（97.1%） > 10% Fe⁰（72.3%） > 针铁矿（41.0%）;FeSO₄的添加明显促进了土壤中Zn、Cu、Pb的浸出,达到原土壤浸出浓度的1990.2、2.8倍和21.6倍,添加Al（OH）₃后能够显著降低Zn、Cu、Pb的浸出浓度,添加量为4%时,稳定化效率分别达到93.8%（Zn）、93.5%（Cu）和98.3%（Pb）;5%FeSO₄和4% Al（OH）₃混合吸附剂对Sb及Zn、Cu、Pb的综合稳定化效率最好,处理10d后稳定化效率最高可达94.6%、74.2%、82.2%和97.6%;进一步分析表明,混合吸附剂添加后比表面积能够达到原土壤的1.31~1.67倍,残渣态Sb比例增加0.037~0.197倍,与稳定化效果相一致,表明铁铝混合吸附剂是处理起爆药污染场地复合重金属污染土壤的有效途径.     

A.ferrooxidans对高硫煤矸石去除酸性水体中Cr(VI)的强化作用

本研究考察了Acidithiobacillus ferrooxidans（A.ferrooxidans）联合高硫煤矸石（富含FeS₂）对模拟煤矿酸性水体中Cr（VI）的去除效果.结果表明,处理Cr（VI）初始浓度为50mg/L的模拟煤矿酸性废水（pH=2.5）时,投配率为6.67~33.33g/L高硫煤矸石可使Cr（VI）去除达到良好效果.50mg/LCr（VI）在24h内即可完全被高硫煤矸石中的FeS₂还原成Cr（III）,且在反应终点时（120h）,6.67,13.33,33.33g/L高硫煤矸石对还原产物Cr（III）的吸附去除率分别为7.1%、20.2%、29.1%.然而,在高硫煤矸石的还原和吸附作用下,大部分的Cr仍以Cr（III）形式残留在酸性水体中,且高硫煤矸石的大量投加也给水体带来了Fe²⁺、Fe³⁺、SO₄^2-等二次污染物.在高硫煤矸石-Cr（VI）体系中引入A.ferrooxidans和9K培养基后,A.ferrooxidans介导的Fe²⁺生物氧化及产物Fe³⁺水解矿化过程可促进部分Fe²⁺、Fe³⁺、SO₄^2-等向次生铁矿物（包括施氏矿物和黄钾铁矾）转变,从而使模拟酸性水体中残留的Cr（III）通过次生铁矿物的吸附或共沉淀作用被清除.在A.ferrooxidans强化作用下,模拟煤矿酸性废水中Cr（VI）在96h即可达到99.4%的去除率.     

Novel synthesis of aluminum hydroxide gel-coated nano zero-valent iron and studies of its activity in flocculation-enhanced removal of tetracycline

A newly designed aluminum hydroxide gel-coated nanoscale zero-valent iron(AHG@NZVI)with enhanced activity and dispersibility of NZVI was successfully synthesized.The AHG@NZVI composite was synthesized via control of the surface AHG content.AHG@NZVI-1,AHG@NZVI-2 and AHG@NZVI-3 were prepared under centrifugal mixing speeds of 1000,2000 and 4000 r/min,respectively.The activity of AHG@NZVI was evaluated by its tetracycline(TC) removal efficiency.The effects of AHG content,pH value,reaction temperature,and presence of competitive anions on TC removal were investigated.TC could be removed by both adsorption and chemical reduction on AHG@NZVI-2(centrifugal speed 2000 r/min) in a short time with high removal efficiency(≥98.1%) at the optimal conditions.Such excellent performance can be attributed to a synergistic interaction between aluminum hydroxide gel and NZVI:(1) AHG could enhance the stability and dispersity of NZVI;(2) aluminum hydroxide gel could absorb a certain amount of TC and Fe~(2+)/Fe~(3+),which facilitated the mass transfer of TC onto the NZVI surface,resulting in acceleration of the reduction rate of TC by the AHG@NZVI composite;and(3) AHG-Fe~(2+)/Fe~(3+)could absorb a certain amount of TC by flocculation.The kinetics of TC removal by AHG@NZVI composite was found to follow a two-parameter pseudo-first-order model.The presence of competitive anions slightly inhibited the activity of AHG@NZVI systems for TC removal.Overall,this study provides a promising alternative material and environmental pollution management option for antibiotic wastewater treatment.     

A collaborative strategy for enhanced reduction of Cr(VI) by Fe(0) in the presence of oxalate under sunlight: Performance and mechanism

Nanometer-size zero-valent iron (NZVI) is an efficient reducing agent, but its surface is easily passivated with an oxide layer, leading to reaction inefficiency. In our study, oxalate (OA) was introduced into this heterogeneous system of NZVI, which could form ferrioxalate complexes with the NZVI surface-bound Fe³⁺ and dissolved Fe³⁺ in the solution. Photolysis of ferrioxalate complexes can facilitate the generation of Fe²⁺ from Fe³⁺ and CO₂^?- radical, both species have strong reduction capacity. Hence, a “photo-oxalate-Fe(0)” system through sunlight induction was established, which not only prohibited the formation of a surface passivation layer, but also displayed a synergetic mechanism of ferrioxalate photolysis to enhance reduction, exhibiting remarkably higher degradation activity (several times faster) toward the model pollutant Cr(VI) than the mechanism with NZVI alone. Factor tests suggested that both NZVI dosage and OA content markedly affected the reduction rate. Low pH was beneficial to the reduction efficiency. Moreover, recyclability experiment showed that the reduction rate decreased from 0.21706 to 0.03977 min^?1 after three cycles of reuse due to the NZVI losing reaction activity generally, but the system still maintained considerable reduction capacity. Finally, a mechanism was revealed whereby NZVI would transform to Fe oxides after the exhaustion of its reductive power, and the photolysis of ferrioxalate to promote the cycling of iron species played the predominant role in providing extra reduction ability. These features confirm that introduction of OA into Cr(VI) reduction by NZVI through sunlight induction is advantageous and promising.     

废铁屑对剩余污泥厌氧消化特性的影响

为探明废铁屑（RSI）对中温厌氧消化特性的影响,利用RSI为外源添加剂研究其投加对剩余污泥厌氧消化水解酸化、产气效率以及污泥表面形态的影响.结果表明:①剩余污泥酸化水解产物VFAs的主要成分是乙酸,其含量随RSI投加量的增加呈先升后降的趋势.②RSI投加量适中（不超过20 g/L）时可促进乙、丁酸型发酵,抑制丙酸型发酵,进而提高剩余污泥厌氧消化效率.③当RSI投加量分别为0、1、5、10、20和30 g/L时,累积甲烷产率分别为135.4、141.9、159.2、178.9、209.3和180.7 mL/g（以VS计）,甲烷含量分别为51.2%~56.4%、53.9%~58.6%、58.1%~62.5%、59.5%~68.3%、61.1%~71.2%和51.9%~61.4%.RSI最佳投加量为20 g/L,与空白组相比,累积甲烷产率和甲烷含量分别提升了54.6%和23.0%.④结合扫描电镜-X射线能谱（SEM-EDX）分析方法发现,在厌氧消化过程中微生物可促进RSI的溶解,且随RSI投加量的增加,消化污泥表面的铁元素含量也随之增加.⑤RSI的投加会提高蛋白酶和纤维素酶的活性,但若投加量过高则会产生负面效应.研究显示,外源添加剂RSI投加量适中（不超过20 g/L）时可促进剩余污泥厌氧消化效率.      

京津冀钢铁行业节能、SO2、NOx、PM2.5和水协同控制

建立自下而上的综合动态优化模型,在节能、大气污染物（SO₂、NO_x和PM_2.5）减排和节水的综合约束下,研究京津冀地区2015~2030年钢铁行业48项节能减排技术优化发展路径,并预测该地区钢铁行业能耗、大气污染物排放和水耗.结果表明,国家应优先鼓励推广干熄焦,小球烧结技术等22项技术,此类技术可以有效协同控制能耗、大气污染物排放和水耗.京津冀地区钢铁行业具有很大的节能、大气污染物减排和节水潜力,到2030年在实现大量节能、大气污染物减排潜力的同时可以实现节水10.08亿m³.虽然计算得到的购水成本仅约占总成本的2%,但是京津冀地区面临着严重大气污染和极度的水资源短缺问题,仍然需要兼顾节能减排技术对水资源的影响.     

多聚物吸附纳米零价铁在多孔介质中的迁移

针对纳米零价铁在多孔介质中的迁移特点,本文通过实验室柱实验和腐蚀实验分析了不同聚丙烯酸（PAA）包覆浓度下的纳米零价铁（nZVI）在石英砂介质中的迁移和其接触不同电解质溶液6h的反应活性.利用迁移距离和穿出率,表征了不同纳米铁材料的迁移性能.应用pH值、氧化还原电位（ORP）、Fe²⁺浓度、X射线衍射（XRD）和Fe⁰含量随时间变化图像表征纳米零价铁腐蚀程度.实验结果表明,PAA显著提高了纳米零价铁材料的迁移距离.10%聚丙烯酸包覆浓度下,实验室合成纳米零价铁的迁移效果最佳,穿出率可达58.65%.在6h的腐蚀实验中,10%聚丙烯酸包覆的零价铁含量有一定的降低,但是零价铁损失相对于20% PAA包覆的零价铁少.综合考虑迁移性和反应活性,10% PAA包覆浓度下实验室合成纳米零价铁是适用于地下水污染原位修复的最佳材料.     

含铝铁硅固废制备PSAF混凝剂RSM优化与结构表征

研究了以粉煤灰和氧化铁皮为原料制备聚硅酸铝铁混凝剂的影响因素及产品微观结构和形貌,选取碱化度、nAl：nFe、聚合温度、反应时间对透光率进行4因素3水平响应面实验.得出制备优化方案：碱化度为0.5,nAl：nFe为1.38,聚合温度为39.2℃,反应时间为1.36h,透光率预测值达90.24%,验证试验均值相对误差1.20%,表明RSM优化模型可靠.结合产品表征测试,XRD分析主要物相为氯化钠,大范围衍射驼峰预示着浸出液聚合形成了新的无定形物;FT-IR测试表明聚硅酸与Al³⁺、Fe³⁺之间存在较多金属-OH等非离子键络合态;TEM测试结果显示产品为高聚集度和枝化度的网状结构;TG分析表明产品在400℃以前失去结合水和羟基,700℃左右产品主要化学键断裂,对应DSC图中均出现较强吸热峰,产品具有较好的稳定性.     

Combined zero valent iron and hydrogen peroxide conditioning significantly enhances the dewaterability of anaerobic digestate

The importance of enhancing sludge dewaterability is increasing due to the considerable impact of excess sludge volume on disposal costs and on overall sludge management. This study presents an innovative approach to enhance dewaterability of anaerobic digestate(AD) harvested from a wastewater treatment plant. The combination of zero valent iron(ZVI, 0–4.0 g/g total solids(TS)) and hydrogen peroxide(HP, 0–90 mg/g TS) under pH 3.0 significantly enhanced the AD dewaterability. The largest enhancement of AD dewaterability was achieved at 18 mg HP/g TS and 2.0 g ZVI/g TS, with the capillary suction time reduced by up to 90%. Economic analysis suggested that the proposed HP and ZVI treatment has more economic benefits in comparison with the classical Fenton reaction process. The destruction of extracellular polymeric substances and cells as well as the decrease of particle size were supposed to contribute to the enhanced AD dewaterability by HP + ZVI conditioning.