基于SVM的CO2驱油藏输油管道脆弱性评价研究

CO2驱油在全国范围内的广泛开展导致内外扰动对输油管道的威胁大大增加,为指导企业发现输油管道的薄弱点从而预防事故发生,提出CO2驱油藏输油管道脆弱性概念及研究思路。将脆弱性分为5个等级并确定各级脆弱性的取值范围。深入分析脆弱性要素,从致灾因子、承灾体和灾害响应3个方面建立脆弱性评价指标体系,并确定各等级脆弱性对应的指标范围。利用MATLAB R2013a的SVM回归方法,构建脆弱性评价模型并进行实例应用。结果表明:模型训练的输出与期望输出拟合较好,均方误差为9.98052×10-7;训练好的SVM模型具有较强的泛化能力和较高的准确性,其对检验样本脆弱性进行预测的最大相对误差为0.027。利用模型得到研究区域某输油管道的脆弱性值为0.381,其脆弱性程度为不太脆弱。     

An experimental and modeling study of continuous liquid fuel spill fires on water

The spread of burning fuel spilled from oil product containers during offshore storage and transportation may cause large damage and trigger further accidents. Some analytical models already exist to predict the spread and burning behavior of liquid fuel spill fires, however, few experimental studies have been conducted to verify the model results. In this paper, continuous n-heptane spill fire experiments were conducted in a rectangular trench covered with water. The burning area, fuel spread rate, and thermal flux with different discharge flow rates and ignition delay times were investigated by both experimental and modeling means. The spill fire burning area, with 5 typical phases during burning, has a quasi-steady value which is directly proportional to the discharge rate but irrelevant to the ignition delay times. The steady burning rate, as the ratio of discharge rate over burning area, was estimated. A spread model was modified to simulate the spread of continuous liquid fuel spill fires in a one-dimensional channel, based on the balance between gravity and viscous forces. A cuboid solid flame model was used to compute the thermal flux from spill fires. The burning fuel spread and the heat flux calculated by the models agree with the experimental results.     

Evaluation of beech for production of bio-char,bio-oil and gaseous materials

Evaluation of Oriental beech (Fagus orientalis L.) was investigated with aspect of thermo-chemical conversion to obtain bio-char, bio-oil and gaseous. When the pyrolysis temperature increased, the bio-char yield decreased. A high temperature and smaller particles increase the heating rate resulting in a decreased bio-char yield. The bio-char obtained are carbon rich, with high heating value and relatively pollution-free potential solid biofuel. The liquefaction yield sharply increased with increasing the temperature near critical temperature and after that. In the pyrolysis, increases of liquid yields are considerably sharply for all of the samples with increasing of pyrolysis temperature from 690 K to 720 K. The beechnut oil was converted to biodiesel in supercritical methanol without using the catalyst. Experiments have been carried out in an autoclave at 493, 523 and 593 K, and with molar ratios of 1:6–1:40 of the oil to methanol. The yield of alkyl ester increased with increasing the molar ratio of oil to alcohol.     

氮化油管工艺危害识别及液氨槽事故树分析

对氮化油管工艺和设备存在的问题进行了危险分析,用事故树分析了液氨槽的爆炸危险性,并提出安全对策。     

分子碰撞与惯性分离原理在油烟净化中的应用

应用分子碰撞和惯性分离原理,对油烟烟气进行分离是一种新的油烟净化方法.阐述了该方法的净化过程、基本原理和装置的最佳条件.研究结果表明：该方法是一种新型、高效、实用的油烟净化方法,提出了进一步完善该方法的研究内容.     

玉门矿区污染黄土中原油的解吸研究

用振荡平衡法研究了玉门矿区原油污染黄土中原油的解吸行为，测得了解吸常数，绘出了解吸等温线。结果表明，Freundlich方程可较好地描述黄土中原油的解吸状况；黄土中原油的解吸行为受温度、溶液pH值和表面活性剂的影响；温度和pH值越高，原油解吸量越大；阴离子表面活性剂的加入有助于原油的解吸，在相同条件下使解吸率提高了5倍，阳离子和非离子表面活性剂的加入不利于原油解吸，但是阳离子表面活性剂的加入有利于原油在土壤中的截留以及回收再利用。本研究为修复玉门原油污染黄土提供了理论依据。     

基于多维云模型的埋地并行油气管道风险评价研究*

为提高风险评价准确性以有效支撑管道完整性维护,保证油气管道在多管并行敷设下安全运行,提出1种基于博弈论-多维云模型的风险评价方法。首先,从并行间距、土壤压实度、土壤导热系数、介质流速、管径、埋深、应急响应时间、上下游截断阀间距等方面建立并行管道风险评价指标体系,为降低传统赋权方法的主观性,通过结合熵权法改进层次分析法（AHP）,从而确定主客观权重,再经博弈论组合赋权法综合计算指标权重;其次,运用多维云模型理论确定风险等级,通过修正各风险评分项的等级区间结合指标权重,计算出各级的综合确定度,并进行等级评判;最后,将该方法应用于工程实例。研究结果表明:所评价管段的指标风险处于中等风险水平,风险可接受,管段的整体风险评价结果良好,有利于并行管道安全管理;实例证明该评价方法具有较好的适用性。     

基于Shear Damage模型的剪切闸板防喷器剪切性能研究

为揭示剪切闸板在纯剪切工况条件下(无压差、无悬重)剪切钻杆时剪切力特征,以及悬重、内外压差等复杂工况条件对剪切钻杆时剪切力和油压的影响规律。本文基于Shear Damage断裂损伤模型,通过显示动力学方法开展剪切过程仿真研究。研究结果表明:在纯剪切工况条件下,剪切力随时间增加先逐渐增加再急剧下降为0;在有悬重工况条件下,剪切力和油压随悬重增加而呈减小趋势;在钻杆内压大于外压工况条件下,剪切力和油压均随压差增大而增大;在钻杆内压小于外压工况条件下,剪切力随压差增大而减小,57/8 in(壁厚14.50 mm)、5 in(壁厚12.70 mm)规格钻杆油压随压差增大呈先增加后减小趋势,51/2 in(壁厚10.54 mm)规格钻杆油压随压差变化不明显,其余钻杆油压随压差增大均呈上升趋势。研究结果可为剪切闸板防喷器油压配置、结构优化、关井工艺改进等提供关键技术支撑。     

采油厂HSE管理体系运行存在问题及对策

分析了采油厂HSE管理体系实施过程中出现的问题,提出了增强体系有效性的对策。     

固定化曝气生物滤池处理采油废水

采用一种特殊载体固定复合微生物B350M在曝气生物滤池反应系统中处理采油废水.废水中的盐度>0.5%,N、P营养缺乏,有机物浓度较低.在HRT为4h、COD容积负荷为1.07 kg/(m³·d)的条件下,小试反应装置稳定运行142d,处理效果良好,石油类、TOC、COD和H₂S的平均降解效率分别达到90.5%、74.4%、85.6%和100%.GC-MS分析表明,进水中含有机物27种,其中烷烃类23种,芳烃类4种.此反应系统可以将大分子量烷烃类物质(C₁₈H₃₈至C₂₈H₅₈),尤其是其中的支链烷烃切碎形成小分子量物质,并有效地处理菲等多环芳烃.反应系统中,生态多样性丰富,载体为微生物提供了良好的水、气环境,抵御盐度、有机污染物的毒害作用,并可以固定丝状菌,因而避免出现污泥膨胀,出水SS过高等影响出水水质的情况.