几种碱性废渣脱硫性能的比较研究

以吸收瓶为实验装置研究了几种碱性废渣的脱硫容量。实验结果表明 ,电石渣、碱渣、废大理石和石灰石的脱硫容量分别为 0 85、0 75 ,0 6 2和 0 5 8gSO2 g脱硫剂。旋流板塔试验主要参数对脱硫率的影响结果表明 ,入塔浆液pH值越大 ,液气比L G越大 ,脱硫率η也越高 ;入塔SO2 浓度y0 越高 ,脱硫率η越低。模拟工业试验结果表明 ,对电石渣和碱渣 ,控制浆液pH >7,L G =2～ 3L m3时 ,η可达 6 5 %以上 ;对废大理石和石灰石 ,控制浆液pH为 6 5 ,L G =4～6L m3时 ,η可达 6 0 %以上。从以上结果来看 ,作为脱硫剂 ,电石渣脱硫效果最好 ,碱渣次之 ,最后是废大理石和石灰石。电石渣和碱渣显示了良好的应用前景     

喷雾吸收法处理烟气中S02的试验

在内径300mm的塔内,采用旋涡式压力喷嘴作雾化器,以石灰作为吸收剂进行烟气脱硫模拟试验研究。试验考察了吸收液PH值、吸收浆液浓度、循环浆液停留时间、液气比、空塔气速及进气SOZ浓度等对脱硫率的影响。结果表明:单级喷雾可获得39％以上的脱硫率,整个试验过程中,喷嘴引起的塔压降很小。此外,还观察了脱硫过程中吸收塔内的结垢情况。通过烟气脱硫模拟试验,为进一步利用喷雾法对国内现有中小型锅炉麻石水膜除尘器的改造,提供了必要的基础数据。     

旋流板塔价廉脱硫剂湿法烟气脱硫工艺

以旋流板塔为脱硫塔，对几种价廉吸收剂的湿法烟气脱硫工艺进行了实验研究，并分析了传质反应机理，试验了不同液气比（L／G）、吸收液pH值和进气SO2浓度等主要参数对脱硫率的影响，并对实验结果进行了分析；结合其传质反应机理，得出了回归方程式，这些吸收剂均来自于工业废料，达到了废治废的效果，价廉脱硫剂的旋流板塔湿法脱硫工艺已用于苏州热电厂35t/h锅炉的烟气脱硫。     

烟气脱硫除尘设备和技术的研究及应用

论述了文氏栅洗涤器及其配套系统的研究和应用，介绍了新研制的采用双碱法结合的湿式脱硫除尘一体化设备——文氏栅洗涤器对工业炉窑的烟气进行脱硫除尘的工程应用情况。与同类工业窑炉烟气脱硫除尘设备相比。文氏栅洗涤器具有体积小，效率高，设备阻力低，耐腐蚀，抗结垢，适用不同的烟气量。组合性好，造价低等特点。是用于工业炉窑烟气脱硫除尘的理想设备。     

旋风水膜除尘器的捕尘性能和结构设计

借助于Leith和Licht的边界层分离理论 ,对轴向出风旋风水膜除尘器的捕尘性能进行了分析 ,得出了捕尘效率的理论公式、径高比等无量纲准数     

The Impact of Scrubber Sludge on Ground Water Quality at an Abandoned Mine Site

A sulfate-rich flue gas desulfurization scrubber sludge was used as a substitute backfill material in reclamation of an abandoned coal strip mine. The site was surrounded by monitor wells and the material was characterized for leaching behavior using open column experiments. A drain was placed directly beneath the 45 000 ton fill to enable sampling before dilution or attenuation. The column studies indicated that the scrubber sludge would adsorb manganese, iron, aluminium, cobalt, nickel, thallium and zinc contaminants from the water. Changes in pH appear inadequate to explain the removal by precipitation. The groundwater cleaning phenomenon has been confirmed on a field scale by the drain samples. Boron and molybdenum leach from the fly ash was used to fix the scrubber sludge and serve as marker elements enabling calibration of the dispersivity in computer models of the groundwater system at the site. The leachate front appears to be diluted by a factor of 8 : 1 within the first 15 meters. Since boron and molybdenum release are associated only with the first flush, environmental impacts will be minimal. Columns appear to create a time compression effect on the duration of leaching phenomenon. The effect for this site appears to be at least 5 : 1. The columns were effective in predicting which elements would leach or adsorb in the field and in predicting the actual source concentrations. Other shake tests such as the TCLP and the ASTM shake test were found to be less effective at predicting which elements would leach and were not helpful in predicting field concentrations.     

Atmospheric Volatile Organic Compound Monitoring. Ozone Induced Artefact Formation

Assessment of population exposure to VOC in ambient atmospheres is receiving heightened interest as the adverse health effects of chronic exposure to certain of these compounds are identified. Active (pumped) and passive samplers are the most commonly used devices for this type of monitoring. It has been shown, however, that these devices, along with all other preconcentration techniques, are susceptible to ozone interference. It is demonstrated that this interference occurs even at low ozone concentrations and that it may result in the under-estimation of population exposure. A convenient and effective ozone scrubbing method is identified and successfully applied and validated for both active and passive samplers for a range of VOC.     

文丘里除尘器喉管结构的优化设计

应用文献中计算压降的公式,得出压降随喉管长度变化的关系;应用WilliamLicht效率公式,得出效率及效率、压降比随喉管长度和喉管气速的变化关系。根据这些关系,得出了在给定效率下压降最小时相应的喉管直径和管长的最佳组合。该结果对于优化文丘里除尘器喉管结构设计、降低能耗和运行成本具有重要意义。     

Evaluation of offline sampling for atmospheric C3-C11 non-methane hydrocarbons

The concentration variation of C3-C11 non-methane hydrocarbons(NMHCs) collected in several types of commercial flexible bags and adsorption tubes was systematically investigated using a gas chromatography-flame ionization detector(GC-FID) system. The percentage loss of each NMHC in the polyvinyl fluoride(PVF) bags was less than 5% during a 7-hr storage period; significant NMHCs loss was detected in aluminum foil composite film and fluorinated ethylene propylene bags. The thermal desorption effic...     

Characterising the performance of a tapered scrubber for controlling particulate emission

The performance of a modified tapered scrubber using water is presented in this article. The column is fabricated with internals so as to improve the performance of a simple tapered bubble scrubber. Experimentation indicates that the system developed can obtain almost 100% particulate (fly ash) removal efficiency under certain hydrodynamical conditions and the removal efficiency has been found to be higher than the existing similar systems. An empirical correlation is put forward for the prediction of removal efficiency as a function of relevant variables of the system. Experimental results agree very well with the correlation.