Lower flammability limits of flammable ternary organic mixtures: Synergistic behavior

Organic flammable liquids and their mixtures, which possess high risk of combustion and explosion, are widely used as raw materials and solvents in chemical and pharmaceutical industries. Lower flammability limits (LFL) is one of the most important parameters to characterize the combustion and explosion hazards of combustible gases and liquid vapors. The LFL of various ternary organic mixtures consist of ketone (acetone and butanone), ester (ethyl acetate) and alcohol (ethanol and isopropanol) were tested at 25 °C and atmospheric pressure. The results showed that resulted LFL values of the experiment were always lower than those calculated by volume fraction weighting method when the volume fraction of alcohol was less than 20 vol% but more than 10 vol%. The co-existence of alcohol and ethyl acetate had synergistic effect on reducing the LFL values of ternary organic mixtures and thus increased their explosive risk. The mechanism of synergistic effect was analyzed, and the results showed that the OH· and H· radicals produced by the oxidation decomposition of alcohols and esters accelerated the oxidation process of ternary organic mixtures, which led to the decrease of experimental LFL values and thus corresponding increased of their explosive risk. This study would be expected to provide some guidance for designing or choosing safer and more suitable ternary organic mixtures prior to their applications for engineering.     

高温炭化法处理工业废盐工程方案研究

针对工业废盐成分复杂、精制难度高的现状,本文提出了一种工业废盐的资源化工程方案,技术经济分析表明,该工程化方案在技术上、经济上能够实现满足投资、运营要求,具备较好的推广前景。     

铝材Sn-Ni混合盐电解着枪色参数研究

首先对铝片试样进行预处理,随后在恒定的电流密度和相同的氧化时间下,在铝材表面形成厚度均匀的阳极氧化膜,然后采用方波交流电,对铝试样进行电解着色处理,通过改变铝材电解着色工艺的着色时间、电流密度、正负电流比、占空比等因素来研究这些因素与铝材明度值和色差之间的关系。实验结果表明获得枪色的最佳工艺条件是:着色时间6m in左右,着色电流密度为1.40 A/dm2左右,正向电流比负向电流大7%左右,占空比55%左右。     

利用废渣盐石膏制作轻型墙体材料

研究利用海盐化工产生的废渣盐石膏经过一定工艺处理,生产轻型墙体材料盐石膏空心条板,该产品与天然石膏空心条板相比,原料采用及生产工艺都有较大改进,生产成本却大幅度下降。经测试,该产品完全可替代天然石膏空心条板,技术性能指标达到了国家规定的相关标准。     

Metals in vineyard soils of the Penedès area (NE Spain) after compost application

The application of organic wastes to improve soil physical characteristics in mechanized vineyards planted after land levelling is becoming a common practice in Mediterranean areas. It may be useful as an additional source of organic matter and nutrients, but these wastes could also have negative effects due to their metal content. The aim of the study was to evaluate the influence of compost application on soil metal contents in mechanized vineyard soils of the Spanish Mediterranean area, where this practice is repeated every three years. The study was carried out in a ten-year-old vineyard where the main soil type is Typic Calcixerept. Composted cattle manure was applied in alternate rows, at a rate of 40 Mgha(-1) dry-weight. Nine sampling points were located along the slopes of two plots: a levelled plot prepared for mechanization with large soil disturbance movements within the plot, and a plot of undisturbed soil. At each location, soil samples were taken in both treated and untreated soils. Total concentrations (digestion with aqua regia) and the extractable DTPA (Diethylene-triaminepentacetic)-CaCl2-TEA (Triethanolamine) fractions of Cu, Zn and Mn were analyzed in each sample. For Cu and Zn, the initial concentration was higher in the undisturbed plot. In both cases, total Cu and total Zn were positively affected by manure input and the concentration in treated soils was significantly higher than in untreated soil. For Mn, the initial concentration was higher in disturbed soils than in undisturbed ones, and although in both scenarios the concentrations increased with manure, no significant differences were found between treated and untreated soils. The extractable fraction also increased in treated versus untreated soils, although for Cu and Mn the extractable/total metal ratio was similar in treated and untreated soils. After one compost application, total metal contents increased significantly, particularly for Zn. Most of those metals are accumulated in the soil, due to the soil characteristics.     

铬盐废水蒸发系统腐蚀突变与缓蚀工况研究

针对铬盐废水蒸发系统运行过程中的腐蚀问题,采用失重法、pH值检测、扫描电镜(SEM、EDS)和XRD等手段,模拟研究了温度、Cr3+质量浓度对20#碳钢腐蚀速率、腐蚀产物的影响,并从废水pH值和形貌分析角度探索腐蚀速率发生突变的原因.研究表明:废水Cr3+质量浓度在150～180 mg/L范围,碳钢腐蚀速率发生突增,废...     

污泥中重金属的形态及在小麦幼苗中的富集

采用BCR连续提取法研究了污泥中Cd、Pb和Zn的化学形态分布,并通过室内土培实验研究了其在小麦幼苗中的富集效应。研究结果表明,Pb和Cd在污泥中主要以残渣态存在,相对比较稳定;Zn则主要以可交换态和可还原态存在,具有较强的潜在生物有效性。污泥中3种金属的潜在生物有效性由强到弱的顺序为:Zn>Cd>Pb。比较污泥中的Zn、Pb、Cd在小麦根和叶中的富集系数(EC),可发现3种金属在根中的富集系数均大于其在叶中的富集系数,说明小麦根部对这3种金属的富集能力大于其茎叶部分。3种金属在小麦中富集能力的强弱顺序在茎叶中为Zn>Cd>Pb,此结果与金属形态分析的结果相吻合。     

填埋垃圾腐殖质组成在填埋场稳定度表征中的应用

通过对上海老港生活垃圾填埋场1991-2004年封场单元填埋垃圾腐殖质组成的分析,考察了填埋垃圾中腐殖质组成随填埋龄的变化规律.研究结果表明,填埋垃圾腐殖质的总可提取率和胡敏酸(HA)与富里酸(FA)比值(HA/FA)分别随填埋龄呈线性下降和上升趋势.因此,填埋垃圾总可提取率和HA/FA可用来有效表征填埋场和填埋垃圾稳定度.     

渤海海冰Modis影像中"伪海冰像元"消除方法的探讨

"伪海冰像元"对渤海海冰范围分布信息的提取产生影响,消除伪海冰像元需要得到一些传感器、大气状况等参数,但往往很难全部得到满足.本文研究了在不知道传感器、大气状况等参数的条件下,通过对数字影像进行实验分析,提取传感器、大气状况引起的脉冲响应函数,并利用该函数结合频域逆滤波和维纳滤波器求解消除非理想脉冲响应的反卷积函数,在空域利用反卷积函数对图像进行逆处理的"伪海冰像元"消除方法.试验结果表明,该方法能够达到降低"伪海冰像元"与其邻域海水像元之间分离度的目的,从而较好的在渤海海区Modis影像中实现分离出"伪海冰像元"的效果.     

西北地区水资源—生态可持续发展的若干问题探讨

基于对西北地区大开发的关键性难题与一些违背自然规律的不良倾向的讨论 ,认为大开发的实施需要在系统科学思维的基础上综合考虑资源—环境—经济的协调发展。近年来 ,许多科学家从各种角度揭示了我国西北乃至北半球中纬度地区持续干旱的发展规律 ,对干旱化趋势与水盐失衡的分析表明 ,西北地区气候干旱化将长期存在 ,生态将继续退化 ,这种趋势是人力不可抗拒的。人为活动尤其是水资源的开发利用 ,对土壤生态的影响是非常明显的 ,应该在严格控制水资源利用总量的前提下 ,调整用水格局 ,发展节水经济 ,科学确定社会经济用水和生态用水的比例 ,保证必须的生态用水 ,大力发展生态植被。指出在分析西北生态环境问题时过于强调人为活动而忽视自然因素作用的倾向 ,讨论了水库兴修、灌溉、土地利用与改良、深层水利用、水环境脆弱性等水资源—生态建设与可持续发展中的若干关键性问题