零价铁和碱激发矿渣稳定/固定化处理铬渣研究

采用零价铁和碱激发矿渣对铬渣进行稳定/固定化处理,考察了处理后固化体的毒性浸出水平,矿物组成及Cr形态分布变化情况,并对铬渣的处置和利用的有效性进行评价.结果表明,还原固定化处理后的样品硫酸硝酸法浸出毒性可满足作为砖或砌块使用的标准,抗压强度均高于15 MPa,其中Cr主要以Fe/Mn氧化物结合态存在,可被用于采石场修复、封闭泻湖以及作为路基材料等一些特殊用途.     

磁性纳米铁对厌氧颗粒污泥特性及其微生物群落的影响

考察了磁性纳米铁(Fe3O4NPs)对厌氧颗粒污泥溶解性微生物产物(SMP)、疏松胞外聚合物(LB-EPS)、紧密胞外聚合物(TB-EPS)的影响,同时利用高通量测序技术对厌氧颗粒污泥内微生物群落结构的变化进行了分析.结果表明,在长期接触实验过程中,投加Fe3O4NPs的反应器对COD去除率为83.6%,与对照组相比降低了5.7%.对照组与实验组中厌氧颗粒污泥TB-EPS含量(以VSS计)分别为178.20 mg·g-1和138.24 mg·g-1,而SMP含量分别为34.88 mg·L-1和27.44 mg·L-1;同时投加Fe3O4NPs后,在LB-EPS三维荧光(EEM)光谱中,紫外光区类腐殖酸荧光峰消失,辅酶F420荧光峰强度有所降低.在长期接触实验后,甲烷杆菌属(Methanobacterium)所占比例从76.15%增至86.76%,而甲烷丝菌属(Methanothrix)所占比例从17.1%降至7.51%,Methanothrix对于Fe3O4NPs更为敏感;总细菌群落变化明显,其中变形菌门(Proteobacteria)所占比例从66.44%降至47.16%,放线菌门(Actinobacteria)所占比例从8.97%增至17.33%,拟杆菌门(Bacteroidetes)所占比例从8.07%增至17.74%,厚壁菌门和拟杆菌门比例的增加对有机物的厌氧水解过程发挥积极的作用.     

微波法处理含铬废渣的可行性分析

微波辐照解毒铬渣是一项新技术，为考察该技术应用的可行性，本文对铬渣解毒前后性状的变化进行了讨论。结果表明，该技术能较完全地使高价铬转化为低价铬，解毒渣中铬主要以三价形态存在，铬渣毒性得到消除；解毒渣浸出液中Cr^6＋浓度远低于国家危险废物鉴别标准，解毒渣已不属于危险固体废弃物，其在环境条件下可安全存放。说明该技术具有应用前景。     

镍渣制备建筑用微晶玻璃的初步研究

对从镍渣中提取铁同时制备建筑用微晶玻璃的进行了研究.结果表明,熔渣中铁的质量分数可以降到0.5%左右,满足制备微晶玻璃的要求.对微晶玻璃样品进行了显微镜、X射线衍射、扫描电镜分析.其主晶相是透辉石(CaO·MgO·2SiO2),晶体的形貌为短柱状,分布均匀.本文所介绍的制备工艺是可行的.     

高炉渣制备光催化剂及其催化活性的研究

以废弃的冶金高炉渣为原料,采用混酸酸溶-水热合成法制备了光催化剂,并对其进行了SEM、UV-Vis、XRD、比表面积等物性测试分析;通过处理甲基橙模拟废水,探讨了制备过程中渣酸比、混酸配比、渣用量、溶渣时间等条件对高炉渣制光催化剂活性的影响。将所制光催化剂与P25光催化剂进行对比分析,结果表明,高炉渣制光催化剂不仅具有较高的光催化活性,而且制备成本低廉,仅为P25光催化剂的1/10,这对于冶金高炉渣的循环再利用及光催化氧化技术的工业化应用具有重要的实际意义。     

Laboratory investigation of Waelz slag stabilization

Electric Arc Furnace dusts are considered hazardous waste due to their high heavy metals content (zinc, lead, etc.). The Waelz process is one of the most efficient technologies, in terms of capacity and quality, able to recover nearly the 90% of zinc contained in such EAF dusts. Unfortunately, the resulting slag still has eco-compatibility problems, although its mechanical and chemical properties are suitable for civil engineering applications. Stabilization tests, by quartz addition, were performed on EAF dusts in a laboratory furnace. Temperature, treatment time and cooling rate were varied in order to define the best conditions for regulating the formation of a stable microstructure able to hinder the release of substances. Microstructural characterization was carried-out using SEM and XRD analysis. Leaching tests were performed according to EN 12457-2 standards and water analyses were performed using ICP-OES. The best chemical stability was achieved when dust powders were mixed with 20% of silica and water-cooled.     

淋滤条件对矿物废渣中铊释放的影响

研究了淋滤时间、淋滤液pH值、粒径及滤速对沉灰渣中铊释放的影响，结果表明：上述因素均能影响废渣表面铁氧化物的水解，这种水解支配着铊释放的过程；滤速及碱性颗粒的参予能显著影响废渣表面的水解作用。     

A simple approach to modeling microbial biomass in the rhizosphere

Microorganisms make an important contribution to the degradation of contaminants in bioremediation as well as in phytoremediation. An accurate estimation of microbial concentrations in the soil would be valuable in predicting contaminant dissipation during various bioremediation processes. A simple modeling approach to quantify the microbial biomass in the rhizosphere was developed in this study. Experiments were conducted using field column lysimeters planted with Eastern gamagrass. The microbial biomass concentrations from the rhizosphere soil, bulk soil, and unplanted soil were monitored for six months using an incubation–fumigation method. The proposed model was applied to the field microbial biomass data and good correlation between simulated and experimental data was achieved. The results indicate that plants increase microbial concentrations in the soil by providing root exudates as growth substrates for microorganisms. Since plant roots are initially small and do not produce large quantities of exudates when first seeded, the addition of exogenous substrates may be needed to increase initial microbial concentrations at the start of phytoremediation projects.     

碱矿渣胶凝材料固化重金属污泥的研究

主要原材料为高炉矿渣的碱矿渣胶凝材料(HAS)、掺3%沸石的HAS、掺5%沸石的HAS、水泥等4种固化材料被用来固化人工合成含铅、镉、铬等重金属的污泥。污泥固化体中污泥与固化材的掺和比例为4:1。实验结果表明,HAS固化剂对重金属污泥的固化效果要好于水泥,其污泥固化体的无侧限抗压强度高于水泥固化体,同时其固化体的重金属浸出量明显低于水泥。沸石的掺入使HAS固化体的重金属浸出量减小,且随着沸石掺加量的增大,HAS固化体的重金属浸出量相应的减少。