石材废水处理工程实例

介绍了石材废水集约化处理的一个成功实例,分析、总结了混凝沉淀法处理石材废水的可行性及注意事项,并通过比较得出石材废水集约化处理较分散治理具备明显优势的结论.     

含重金属水处理污泥的固化和浸出毒性研究

工业危险固体废物在进行安全填埋前需要进行固化稳定处理。针对电镀厂和皮革厂含重金属的水处理污泥 ,用不同比例的水泥、粉煤灰进行固化稳定处理。考虑酸雨环境 ,浸出实验采用TCLP标准。电镀厂污泥单独固化时 ,其浸出液中铜离子浓度由 78 0mg/L下降到 1 5mg/L ;镍离子浓度由 2 2 4 5mg/L下降到 2 2 2mg/L ,高于危险废物允许进入填埋区 15mg/L的控制限值。电镀厂污泥与皮革厂污泥混合后固化 ,浸出液毒性明显降低。铜离子的浸出浓度降低到1 98mg/L ,镍离子降低到 4 10mg/L ,总铬降低到 0 4 0mg/L ,各项指标均低于国家危险废物允许进入填埋区的控制限值 ,可安全填埋。     

堆肥法处理含油污泥研究进展

含油污泥是炼油厂和石油化工厂的日产固体废弃物 ,是当前石化行业所面临的污染问题。本文给出了近期国内外对含油污泥的处理方法 ,并对堆肥法处理含油污泥进行了综述。含油污泥的堆肥处理需提供氧气、菌种和营养 ,为保持油泥的疏松状态 ,还需加入填充剂。本文对高速生物反应器的结构、运行、调控进行了详细介绍 ,并从经济核算角度指出了其运营可行性     

固定化微生物脱氮技术

在废水生物脱氮中 ,利用载体固定、形成颗粒污泥等固定化微生物技术可在增加生物脱氮速度、节省碳源、减少后曝气等方面提供有效的方法 ,并实现单级生物脱氮     

有机负荷和溶解氧的变化对SBR污泥膨胀的影响及控制方法

本文研究SBR工艺处理汽车电泳废水在不同有机负荷、溶解氧条件下污泥膨胀的现象 ,分析膨胀发生机理 ,分别提出控制方法。实验结果表明 ,在低、中、高负荷时 ,只要溶解氧发生变化 ,均有可能发生膨胀。低负荷、正常溶解氧时发生的膨胀可以通过前联好氧生物选择器加以控制 ;中负荷、低溶解氧及高负荷、低溶解氧活性污泥发生膨胀时可以通过强化曝气得到控制     

微氧膜生物反应器同时去除有机物和氮的研究

采用微氧颗粒污泥膜生物反应器处理生活污水,进行同时去除有机物和氮的研究。结果表明,膜出水COD不受水力停留时间变化的影响一直稳定在较低值,为15~35mg/L,去除率在94%以上。氮通过发生同时硝化反硝化反应而去除。在水力停留时间为16h以上时, 系统总氮去除率为65% ~92%,平均去除率为77%。     

Growth of Plants on TBT-contaminated Harbour Sludge and Effect on TBT Removal (10 pp)

Background Worldwide, large amounts of sediments have to be dredged annually from waterways and harbours. These sediments are sometimes polluted with a variety of toxic compounds. In some countries, including Belgium, the load with the biocide tributyltin (TBT) from ship coatings prohibits the dumping of harbour sludge into the sea. Land-based dumping is a commonly used alternative. Objective This research investigated the feasibility to use land-deposited harbour sludge for plant production. In a field trial, the growth of 38 more or less salt-tolerant plant species on low and high TBT-contaminated sediments was studied. The elimination of TBT from sludge with and without vegetation was compared. The uptake of TBT and its degradation products di- and monobutyltin (DBT and MBT) into harvest products under field conditions was determined. - Experimental Set-up. Sediments dredged in May 2003 from the brackish waters of the port of Antwerp were analysed in the laboratory for soil texture, pH, electroconductivity, sodium, magnesium, potassium, calcium, ammonium, nitrate, total nitrogen, chloride, sulphur and the organotins TBT, DBT and MBT. The sediments were lagooned for one year to dewater, desalinate and improve their structure. Salt-tolerant domestic and wild plants were selected and sown in May 2004. In August 2004, plants were harvested and the produced biomass was determined. Samples were taken from vegetated and non-vegetated top and bottom sediments and from plants growing above soil and analysed for TBT, DBT and MBT. Results The fresh sediments showed a good supply with nutrients and a neutral pH, but were rather saline (EC 14 mS cm-1 of the saturated paste extract). The salinity decreased to 3.7 mS cm-1 during lagoonation. The high and the low contaminated sediment had initially 43 and 1.6 mg TBT kg-1 dry weight, respectively. Besides TBT, several other contaminants were present in the sediments at critical levels. The biomass production of the plant species from the field trial ranged from 0.2 to 13 tons dry mass per hectare. Plants performing excellently were barley, sorghum, rape seed, a clover/grass mix and reed. If at all, a positive influence of TBT on plant growth was seen. TBT was degraded significantly faster (>40%) below barley. The uptake of TBT, DBT and MBT into stem and leaves of reed, grass and clover was very low, but measurable and not related to concentrations in soil. No uptake of TBT or its metabolites into corn of barley was found. Discussion This study confirmed former results: the toxicity of TBT to higher plants is low, and even high levels in soils would not be a hindrance for crop production. The removal of TBT seemed to be increased by both lagooning and plant growth, although the target values for sea dumping in use in certain European countries were not reached. A plausible explanation for the faster degradation of TBT under vegetation is that oxygen is a limiting factor, and plants dewater the soil, thus aerating it. The uptake of the organotins TBT, DBT and MBT into harvest products is probably due to attached soil particles. Conclusions To summarize, barley was the optimal species: it grew very well despite the salinity of the dredged sediments, it had a significantly positive effect on TBT removal; it showed no measurable uptake of TBT or the other butyltins into the harvested product; and it is a cash crop well established in European agriculture. Outlook The amounts of dredged sediments are high, and good soils are becoming increasingly rare. The feasibility of using dredged sediments for non-food production, such as energy crops, should be investigated by a critical risk assessment.     

两种曝气设备的清水曝气充氧实验研究

根据清水充氧实验计算,比较了微孔雾化软管曝气和射流曝气的充氧动力效率和氧利用率.以及后续实验的结果,最终得出微孔曝气软管曝气是高效节能的河流整治方法.     

污泥的粘度与浓度、温度三者关系式的实验推导

通过融合污泥粘度与污泥浓度关系式、污泥粘度与温度关系式,得到一个新的关系式:污泥粘度与污泥浓度、温度的关系式,并通过实验数据拟合出各项参数,拟合效果比较理想.得出的污泥粘度与污泥浓度、温度的关系式对了解污泥的粘度变化非常有帮助,同时,该关系式也将为污泥处理、处置方案的制定提供参考依据.     

卧式螺旋污泥好氧动态堆肥技术的研究

利用卧式螺旋式污泥好氧堆肥装置进行间歇式动态堆肥,对污水厂厌氧消化污泥进行了中温堆肥试验研究.通过控制各组堆肥的含水率、物料配比和通气量,重点探讨各种条件下堆体温度与有机物降解的关系.试验结果表明,厌氧消化污泥以木屑为调理剂在装置中可以实现好氧堆肥处理,其适宜的物料控制参数为:污泥:木屑=10:1～1.5(湿重比),堆肥含水率50%～60%;过程控制参数为:通风量为6.7～8.3 m3/h·t,发酵周期为8 d,温度45℃.