Environmental Technology Verification (ETV) test of dioxin emission monitors

The performance of four dioxin emission monitors, including two long-term sampling devices, the Dioxin-MonitoringSystem (DMS) and AMESA (the adsorption method for sampling dioxins and furans), and two semireal-time continuous monitors, the resonance ionization with multimirror photon accumulation time-of-flight mass spectrometer (RIMMPA-TOFMS) and the jet resonance-enhanced multiphoton ionization (jet-REMPI) system were tested. A package boiler burning a simulated chlorinated hazardous waste was used for a total of nine tests. Reference samples were collected during each test and analyzed for polychlorinated dibenzodioxins and dibenzofurans (PCDDs/Fs) using gas chromatography mass spectrometry. The PCDD/F concentrations of the reference samples measured by EPA Method 23 ranged from 0.9 to 6.0 ng toxic equivalence (TEQ)/dry standard cubic meter. The relative accuracies achieved by DMS, AMESA, and jet-REMPI varied from 22.6% to 78.2%, with 100% data completeness. The RIMMPA-TOFMS produced no quantifiable results due to various difficulties associated with the instrument during the testing. The two long-term samplers were easy to install and operate and provided a cumulative, averaged emission for the sampling period. The operations of the two semi-real-time continuous monitors were relatively complex, but one of them provided on-site, real-time data for PCDD/F emissions from measurement of a TEQ correlative indicator compound. This article summarizes results from the individual Environmental Technology Verification reports for the four dioxin monitors. This work was presented, in part, at the Fourth International Conference on Combustion, Incineration/Pyrolysis and Emission Control (i-CIPEC)     

生活垃圾焚烧发电厂周边环境二噁英污染水平及人群暴露评估

选取某典型生活垃圾焚烧发电厂为研究对象,监测其周边环境空气、土壤、地下水、农作物等环境介质中二噁英的浓度水平,初步评估周边人群二噁英暴露水平。研究结果表明,该厂周边环境空气、土壤、地下水中二噁英测定值分别为0. 236 pg TEQ/m3～0. 331 pg TEQ/m3、1. 94 ng TEQ/kg～2. 71 ng TEQ/kg、0. 17 pg TEQ/L～0. 26 pg TEQ/L,企业排放的二噁英对周边环境影响较小;成人和儿童在暴露介质中摄入二噁英总量分别为0. 959 pg TEQ/(kg·d)和1. 59 pg TEQ/(kg·d),均低于4 pg TEQ/(kg·d)的标准,经大米和面粉摄入二噁英的量超过总暴露量的90%,提示食物是人群二噁英暴露的主要介质。     

火化过程中二噁英类污染物减排技术研究

为减少火化过程中二噁英类污染物的排放,研究了"热交换器 布袋除尘器 活性炭纤维毡"三级组合对火化遗体烟气中二噁英类污染物的去除效果.利用急冷技术将二次燃烧室排出的火化烟气温度降到90～130℃.实验表明,布袋除尘器去除火化烟气中二噁英类污染物的效率为57.4%;布袋除尘器分别与厚度为5、15 mm的活性炭纤维毡组合去除火化烟气中二噁英类污染物的效率分别为64.0%和89.2%.     

钢铁企业排放的烟气及厂区土壤中二噁英类污染研究

对国内某钢铁企业厂区内土壤和烧结厂排放烟气中二噁英类物质进行了采样研究,得出土壤中二噁英类物质浓度范围是1.05~6.91pgⅠ-TEQ/g,平均值为3.22pgⅠ-TEQ/g;烟气中的浓度范围是0.23~0.48 ngⅠ-TEQ/Nm3,平均值为0.32 ngⅠ-TEQ/Nm3,给出了土壤和烟气中二噁英类物质形态分布特点,并根据形态分布存在的相似性推断出土壤中二噁英类物质主要来源于烧结厂烟气的排放。     

Decreased PCDD/F formation when co-firing a waste fuel and biomass in a CFB boiler by addition of sulphates or municipal sewage sludge

Polychlorinated dibenzo-p-dioxins (PCDDs) and polychlorinated dibenzofurans (PCDFs) are formed during waste incineration and in waste-to-energy boilers. Incomplete combustion, too short residence times at low combustion temperatures (<700 °C), incineration of electronic waste and plastic waste containing chlorine are all factors influencing the formation of PCDD/Fs in boilers. The impact of chlorine and catalysing metals (such as copper and iron) in the fuel on PCDD/F formation was studied in a 12 MW_th circulating fluidised bed (CFB) boiler. The PCDD/F concentrations in the raw gas after the convection pass of the boiler and in the fly ashes were compared. The fuel types were a so-called clean biomass with low content of chlorine, biomass with enhanced content of chlorine from supply of PVC, and solid recovered fuel (SRF) which is a waste fuel containing higher concentrations of both chlorine, and catalysing metals. The PCDD/F formation increased for the biomass with enhanced chlorine content and it was significantly reduced in the raw gas as well as in the fly ashes by injection of ammonium sulphate. A link, the alkali chloride track, is demonstrated between the level of alkali chlorides in the gas phase, the chlorine content in the deposits in the convection pass and finally the PCDD/F formation. The formation of PCDD/Fs was also significantly reduced during co-combustion of SRF with municipal sewage sludge (MSS) compared to when SRF was fired without MSS as additional fuel.     

PCDD/Fs in ambient air collected in Zagreb, Croatia

Levels of PCDD/Fs were measured at four different sites in Zagreb, capital of Croatia. Also one sample was taken during spontaneously initiated open fire on a landfill and one sample where garden waste of unknown content was burnt. Over period 1997–2000, 28 samples were collected and levels ranged between 9 and 306 fg I-TEQ m⁻³, except in the sample collected during landfill fire. Air PCDD/F levels in Zagreb at four sites were different and the highest levels were observed in industrial area. Seasonal variation of levels is also evident with higher levels in winter than in summer. Our results show that PCDD/F levels in ambient air collected in Zagreb are at lower end of the published data range. In general, homologue profiles were quite similar for all locations, the concentration of PCDD homologues increased while the concentration of PCDF homologues decreased with increasing degree of chlorination. PCDD/F levels in the landfill fire sample was 13 200 fg I-TEQ m⁻³ which are much higher than levels in garden waste burning sample or in sample collected at industrial site. During landfill fire, the concentration of 2,3,7,8-TCDF becomes even higher than the concentration of OCDF and is equal to the concentration of 1,2,3,4,6,7,8-HpCDF.     

国内外二恶英研究初探

总结了国际上近年来环境中二恶英的研究成果及进展概况。主要分挤二恶英的毒性及来源，综合国内外有关二恶英的绝大部分研究成果，并简要提出二恶英的防治措施。     

二(噁)(口英)类污染物排放的农业面源分析

以三种树叶焚烧测定结果为例,分析了植物燃烧过程中产生的二类。研究结果表明,不同植物焚烧排放的二类浓度不同,含氯高时排放二类浓度也较高。二类对生态环境和人类健康有巨大的危害,分析二类污染物的农业面源情况,对于进一步有效控制和降低二类的排放,有重要的现实意义。     

Evaluation of the optimal washing conditions for dioxin-contaminated soils from the circumference of an incinerator

 The optimal soil-washing conditions for dioxins were estimated on a soil sample from the circumference of an incinerator in Nose City, Osaka, Japan. The solvents ethanol, methanol, and acetone, together with a surfactant (100% of each) could extract 40% of the dioxins from contaminated soil at room temperature. From among these solvents, ethanol was chosen for a study on how to optimize the extraction conditions because of its low toxicity and its economic advantages. The time-course of the agitation showed that the extraction rate increased for 1 min, and thereafter the rate decreased. Therefore, the agitation time was fixed at 1 min. To estimate the effect of temperature on the extraction rate, the extraction temperature was changed. The amount of dioxins extracted was largest at the boiling point of ethanol (78.3°C), giving about 76% extraction. Furthermore, at this temperature, almost 100% of the dioxins in the contaminated soil were extracted when the ratio of water to ethanol was 20%. Received: March 6, 2002 / Accepted: September 9, 2002     

Distribution of polychlorinated dibenzo-p-dioxins, polychlorinated dibenzofurans, dioxin-like polychlorinated biphenyl and polycyclic aromatic hydrocarbons in the sediment of Temsah lake, Suez Canal, Egypt

Lake Temsah is one of the main wetlands in the Suez Canal region, and the main source for fish for the area. The lake is the end-point of several wastewater effluents. In the present study, residues of polychlorinated dibenzo-p-dioxins (PCDDs) and polychlorinated dibenzofurans (PCDFs), dioxin-like polychlorinated biphenyl (PCB) and polycyclic aromatic hydrocarbons (PAH) were monitored in the sediment of the lake. Samples were collected from six different sampling stations around the lake using a box-corer sampler, then kept frozen. Samples were extracted and cleaned up before residue determination was conducted using an HRGC/HRMS. An HP 6890 plus gas chromatograph was coupled to a Micromass Autospec Ultima mass spectrometer operating in EI mode at 35 eV and with a resolution of 10.000 (5% valley). PCDDs and PCDFs were detected in all sediment samples collected from various sampling stations. Results showed some progressive increase in PCDDs concentrations relevant to increase in chlorination. In the PCDD group of congeners, 1, 2, 3, 4, 6, 7, 8, 9 octa-CDD had the highest detected concentrations in all samples, while 2, 3, 7, 8 tetra-CDD showed the lowest concentrations. The World Health Organization toxicity equivalents ranged from 0.387 to 11.20 ng kg^-1 d.w. For PCDD homologues, hexa-CDD was the most dominant homologue in all sediment samples analysed. Regarding dioxin-like PCBs, results showed that IUPAC No. 118 congener, 2, 3, 4, 4, 5, pentachlorobiphenyl was the most concentrated of all detected congeners, with concentrations ranging between 0.039 and 43.201 µg kg^-1. For polycyclic aromatic hydrocarbons, benzo(b+k+j)fluoranthene had the highest concentrations in almost all sampling stations. However, fluorene was the smallest detected concentration in almost all stations. This result would indicate that PAH contamination of the lake seems to be coming from one main source in all sampling stations. The present work is the first record of PCCDs, PCCFs, and dioxin-like PCBs in the Temsah lake. The concentrations of the contaminants monitored in this study, especially those of PAHs, are rather alarming. Efforts should be made to stop point sources that contaminate the lake.