工业用煤气燃烧装置二氧化硫减排方式的讨论

工业用煤气是工业生产中普遍采用的气体燃料,煤气燃烧过程会产生二氧化硫,减少煤气燃烧过程的二氧化硫排放可采用煤气脱硫和烟气脱硫两种方式。本文通过对煤气脱硫工艺及烟气脱硫工艺原理及参数进行对比的方式,讨论工业用燃气燃烧装置的两种二氧化硫减排方式的优缺点,为该类装置脱硫设计提供参考。     

脉动频率对低浓度瓦斯脉动燃烧的影响研究

本文将低浓度瓦斯与脉动燃烧结合,主要研究了脉动频率对低浓度瓦斯燃烧的影响。实验结果发现：频率为99Hz至120Hz之间的脉动燃烧不仅可以降低贫燃极限．实现瓦斯在5％浓度下稳定而充分的燃烧,而且在相同温度下提高了瓦斯燃烧效率,污染物的排放也得到了改善。     

上悬窗条件下通风控制腔室火灾温度的实验研究

随着建筑结构的发展,上悬窗日益成为城市建筑窗户的选择,但这种通风条件下腔室火灾的发展特性仍缺乏研究.利用1:8相似比例的缩尺寸腔室火灾实验台,实验研究了上悬窗不同开口尺寸、不同开窗角度下,通风控制的腔室火灾温度发展特性.实验结果表明,通风控制条件下,腔室火灾温度随着上悬窗开口尺寸和开窗角度的增加而增加,并通过能量平衡分...     

Research based on double coverage rate and reliability of gas detector layout optimization

The gas detector layout should be highly attuned to combustible gas leakage and attain a good reliability in avoiding detector malfunction, which is an important guarantee for the normal production of the chemical industry and other related enterprises. Herein, a gas detector layout optimization method based on double coverage and reliability is proposed. The key gas leakage monitoring area is determined through layout scene field investigation. To improve the detection probability and detection system reliability, the dual coverage target and voting mechanism are set, and the gas detector layout is determined with the ray-casting algorithm according to the coverage target. Combined with FLACS software to simulate a variety of typical leakage conditions under different layout scenarios, the relationship between the leaked gas concentration detected by gas detectors in each layout scheme and time is obtained, and the gas leakage detection probability in each layout scheme, number of detectors that can trigger the alarm, shortest time to trigger the alarm and reliability are comprehensively evaluated. The decision-maker selects the final gas detector layout plan according to the evaluation results and actual site needs. The study shows that the detection probability of each layout scheme set according to the double coverage is high, and multiple detectors can trigger the alarm (up to 100%), which ensures that the alarm can be triggered within 10 s under all applicable conditions. According to the evaluation results, the decision-maker can obtain a layout scheme that not only agrees with the actual site conditions but also attains a high detection probability, short detection time and strong reliability.     

ASE-气相色谱法测定油田区土壤中多种石油烃

采用气相色谱法测定油田区土壤中C_(10)～C_(40)的石油烃,通过优化加速溶剂萃取的条件,使方法在62 mg/L～3 100 mg/L范围内线性良好,方法检出限为4.8 mg/kg。用该方法测定石油区短期、中期、长期油井污染土壤样品,5次测定结果的RSD为1.3%～5.2%,加标回收率为84.8%～98.5%,有证标准样品测定结果在可信区间内。     

气相色谱法测定水质中的内吸磷

优化了气相色谱法测定水质中的内吸磷,当取样量为100 m L时,内吸磷-O方法检出限为0. 30μg/L,测定下限为1. 20μg/L;内吸磷-S方法检出限为0. 80μg/L,测定下限为3. 20μg/L。内吸磷-O和内吸磷-S标准曲线线性良好,相关系数分别为0. 999 2和0. 999 8。不同水质中内吸磷-O的加标回收率为90. 3%～104%,相对标准偏差为3. 6%～9. 2%;内吸磷-S的加标回收率为92. 1%～94. 9%,相对标准偏差为4. 6%～8. 7%。该方法灵敏度高,能有效分离内吸磷-O和内吸磷-S,同时能将内吸磷-O、内吸磷-S与其他有机磷农药类干扰物分离。     

气相色谱法测定土壤中37种有机磷农药残留

采用气相色谱法测定土壤中37种有机磷农药,当取样量为10 g时,37种有机磷农药方法检出限为0. 002～0. 015 mg/kg,测定下限为0. 008～0. 060 mg/kg。低含量加标样品中有机磷农药的加标回收率为72. 8%～104%,相对标准偏差为4. 2%～13. 8%;中含量加标样品中有机磷农药的加标回收率为71. 5%～101%,相对标准偏差为4. 3%～13. 5%;高含量加标样品中有机磷农药的加标回收率为74. 6%～109%,相对标准偏差为6. 8%～14. 6%。该方法灵敏度高、分离效果好、重现性好,能够满足土壤中37种有机磷农药残留检测的要求。     

污泥投配率对污泥中温厌氧消化效果影响的试验研究

试验装置采用半连续流污泥中温厌氧消化反应器,污泥培养接近成熟后开始每天按不同污泥投配率加泥和排泥.结果表明:污泥投配率在3%～10%时,有机物分解率先增大后减小,去除率均在30%以上;污泥投配率在15%和20%时,污泥的有机物去除率非常小;污泥投配率在5%时,有机物分解率最大为41.2%;单位VSS产气量随污泥投配率的增大而呈先急剧上升后逐渐下降的趋势,当污泥投配率为5%时,单位VSS产气量为0.60 L/g,符合美国污水处理厂设计手册标准,其他污泥投配率下该指标均小于0.4 L/g.因此,认为实验用污泥中温消化的最佳污泥投配率为5%,这时污泥的可消化性较好.     

气相色谱法测定空气和废气中8种烃类化合物

建立了针筒采样、大口径毛细管柱分离、气相色谱-氢火焰离子化检测器测定空气和废气中甲烷、乙烷、乙烯、乙炔、丙烷、异丁烷、正丁烷和正戊烷等8种烃类化合物的方法.优化了试验条件,方法线性良好,甲烷、乙烯、乙炔、乙烷、丙烷、异丁烷、正丁烷和正戊烷的检出限分别为0.09 mg/m3、0.20 mg/m3、0.18 mg/m3、0.29 mg/m3、0.28 mg/m3、0.37 mg/m3、0.16 mg/m3和0.56 mg/m3,RSD＜8.0%,加标回收率为80.5%～104%.     

Octanol–air partition coefficients of polybrominated biphenyls

The octanol–air partition coefficients (K_OA) for PBB15, PBB26, PBB31, PBB49, PBB103 and PBB153 were determined as a function of temperature using a gas chromatographic retention time technique with 1,1,1-trichloro-2,2-bis (4-chlorophenyl) ethane (p,p′-DDT) as a reference substance. The internal energies of phase change from octanol to air (Δ_OAU) were calculated for the six compounds and were in the range from 74 to 116 kJ mol⁻¹. Simple regression equations of log K_OA versus relative retention times (RRTs) on gas chromatography (GC), and log K_OA versus molecular connectivity indexes (MCI) were obtained, for which the correlation coefficients (r²) were greater than 0.985 at 283.15 K and 298.15 K. Thus the K_OA values of the remaining PBBs can be predicted by using their RRTs and MCI according to these relationships.