固定化菌剂处理含油废水的试验研究

探讨了固定化菌剂的接种量、曝气强度及温度等因素对废水中CODer去除率的影响.试验结果表明:在采用适当的曝气方式和曝气强度下,温度为30℃时,采用10％的固定化颗粒接种量,4种固定化产品对含油废水中CODer降解均有较好的效果.     

多因素下小尺度油罐火燃烧速率的研究

以正庚烷为研究对象,开展了不同因素耦合作用下小尺度油罐火燃烧特性的实验研究。结果表明:在不改变其他工况条件下,开口因子直接影响燃料燃烧速率,发现不同开口因子下燃烧速率与全开口下燃烧速率之比始终正比于对应的开口面积之比,且之间存在着相应的关系式。在实验所测两种液位6cm和8cm下,其燃烧速率变化不大,由此可发现,在该实验液位下油罐火液位高度不是影响燃烧速率的主要因素。在不同的风速下,随着风速的增加燃烧速率逐渐增加并趋于一定值,且不同开口因子下风速对燃烧速率的影响程度不同。风速对开口因子大的油罐燃烧速率的影响小于开口因子较小的油罐。     

稠油废水处理工艺研究

介绍了稠油废水的来源与性质,提出3种处理技术,即"水解酸化-接触氧化-臭氧催化氧化",出水CODCr为48.6 mg/L,去除率达到86.55%,处理成本为6.03元/m3;"活性焦预吸附-厌氧-固定化微生物BAF-活性焦后吸附",出水CODCr为40.2 mg/L,去除率达到88.97%,处理成本为5.45元/m3;"强化絮凝-活性污泥MBR",出水CODCr为36.8 mg/L,去除率达到82.64%,处理成本为5.76元/m3。第2种工艺处理效率与处理成本略优。     

Development of HGAPSO-SVR corrosion prediction approach for offshore oil and gas pipelines

Managing the oil and gas pipelines against corrosion is one of the major challenges of the oil and gas sector because of the complexities associated with the initiation, stabilization, and growth of the corrosion defects. The present research attempts to develop a model for predicting the maximum depth of pitting corrosion in oil and gas pipelines using SVM algorithm. In order to improve the SVM performance, Hybrid PSO and GA was utilized. Monte Carlo simulation was used to determine the time lapse for the pit depth growth. In order to implement the above modeling approaches and to prove their efficiency and accuracy against a large database, a total of 340 data samples for corrosion depth and rate are retrieved from the Iranian Oilfields. The performance of the new algorithm shows that it has higher stability and accuracy. In addition, the forecasting results of the new algorithm are compared with the 11 intelligent optimization algorithms, it shows that the novel hybrid algorithm has higher accuracy, better generalization ability, and stronger robustness. The coefficient of determination (R²) value in the testing phase for SVM-HGAPSO was estimated by 0.99. Proposed hybrid model and Monte-Carlo simulations pitting corrosion based on Poisson square wave process have been used to predict the time evolution of the mean value of the pit depth distribution for different categories of maximum pitting rates (low, moderate, high and sever). The models was validated with 4 field data for each of the pitting corrosion categories and the results agreed well. The pipelines under severe pitting corrosion rate were, more conservatively predicted by HGAPSO-SVR than those under low, moderate and high pitting corrosion rates. The results obtained demonstrate the potentials of this technique for the integrity management of corroded aged pipelines.     

细水雾扑灭油池火过程中火焰强化现象的实验研究

在细水雾扑灭油池火的初期,某些油池火焰会有一个突然强化、剧烈燃烧的情况发生。通过实验研究证明,酒精等与水互溶的液体不会发生强化现象,汽油和柴油等不溶于水的液体则有明显的强化现象;同时,发生强化现象的根本原因是共沸使得细水雾到达燃料表面后急剧沸腾而强化燃烧。     

赤红壤、砖红壤矿物油污染效应研究

本研究采用盆栽试验法,研究了赤红壤、砖红壤中矿物油对水稻、花生的生理生态影响和矿物油在土壤中的净化。研究结果表明:矿物油对第一季水稻生长发育影响不大,对第二季则表现出明显的抑制作用,低浓度矿物油对花生生长发育有促进作用,高浓度则对其起抑制作用;收获后,水稻各部分及水稻土,花生根及花生土油残留均与投油量呈极显著的直线正相关关系,油在作物根部最易积累;种植两季水稻后,油在赤红壤、砖红壤中的净化率分别为80％以上和50％左右。最后,根据上述研究确定了赤红壤、砖红壤的矿物油临界含量分别为270.90mg/kg和318.92mg/kg。      

消泡剂硅油Ⅰ在苯胺测定中的应用

用预蒸馏－重氮偶合比色法测定印染废水中的苯胺时,蒸馏过程中大量的泡沫出现,是影响测定结果准确度的重要因素。本研究对色泽很深,含酚量较高的废水加入消泡剂硅油Ⅰ以抑制蒸馏产生的泡沫。结果表明,在１００ｍｌ水样中加硅油Ⅰ０．０５－０．５ｍｌ即可收到理想效果。硅油Ⅰ性质稳定,不随水蒸汽蒸出,对测定无干扰。标准加入回收率为９１．６％＝９７．３％,蒸馏得率平均为９６％。     

油田生产设施环境安全距离理论与估算--以胜利油田东辛采油厂为例

油田生产设施环境安全距离为减轻或避免生产设施的潜在环境危害．解决城市发展和油田企业之间的利益冲突,以及事故后的人群紧急疏散提供了科学的决策依据。以胜利油田东辛采油厂为例．对井场类、站库类和管线类三类主要油气生产设施的环境安全距离进行了研究和估算。对于井场类设施．主要研究估算了井喷H2S泄漏的环境风险安全距离;对于站库类设施,主要研究估算了噪声环境影响安全距离;对于管线类设施,主要研究估算了泄漏事故环境风险安全距离。通过现场测量和模拟实验证明．估算结果比较可靠。     

Magnetic composite prepared from palm shell-based carbon and application for recovery of residual oil from POME

Magnetic separation combined with adsorption by activated carbon has been found to be a useful method for removing pollutants. In this paper, the use of palm shell as a source of activated carbon for the removal and recovery of oil from palm oil mill effluent (POME) is studied. In the first part of the study, the properties of samples of activated carbon prepared from palm shell under a variety of different conditions were characterized for their hydrophobicity, surface areas and pore size distribution. The most effective of the activated carbon samples was prepared by impregnation with ZnCl(2) followed by combined physical/chemical activation under carbon dioxide flow at 800 °C. Four grams of these samples adsorbed 90% of the oil from 50 mL POME. In the second part, the palm shell-based carbon samples were given magnetic properties by the technique of iron oxide deposition. Ninety-four percent of the activated carbon/iron oxide composite containing the adsorbed oil could be extracted from the POME by a magnetic bar of 0.15 T. Four grams of the composite can remove 85% of oil from 50 mL POME and a total of 67% of the initial oil can then be recovered by hexane extraction. Powder X-ray diffractometry showed the presence of magnetite and maghemite in the activated carbon/iron oxide composite.     

含油污泥处理技术进展

对国内外含油污泥的处理技术作一简述,介绍了含油污泥的调质－机械分离处理技术,高温处理技术,溶剂萃取处理技术和综合利用技术。