The influence of ClO− and acidity in the reaction between H2O2 and CuCl2

The potentially explosive reaction of hydrogen peroxide (H₂O₂) and copper chloride (CuCl₂) was investigated. Pressure tests revealed that the reaction was strongly temperature - dependent and can easily undergo runaway reaction. Nevertheless, there was only a slight pressure increase at the low temperatures studied or when using low concentrations of CuCl₂. Under the conditions generating the slight pressure increase, hypochlorite anions (ClO⁻) are generated and the acidity increases. As the reaction reaches completion, ClO⁻ disappears, and the acidity decreases. Interestingly, the addition of phosphate buffer to maintain the weakly acid conditions led to a runaway reaction, and the use of basic ClO⁻ promoted the exothermic reaction. Based on the results, acidity has a strong impact on the reaction behaviour.     

Fe和Fe2+对混合细菌产氢发酵的影响

在研究Fe粉剂量和Fe²⁺浓度对混合细菌产氢发酵的影响基础上,确定Fe和Fe²⁺促进混合细菌产氢能力的最佳阈值,并对乙醇型发酵菌群在不同Fe粉和Fe²⁺浓度下的产氢量和最大比产氢速率进行考察和对比.结果表明,Fe粉和Fe²⁺对乙醇型发酵菌群的产氢能力均有明显的促进作用.以葡萄糖为底物,投加Fe²⁺试验中,Fe²⁺浓度200mg/L获得最大产氢量143.7mL/g,较对照组提高32%;Fe²⁺浓度50mg/L获得单位VSS最大比产氢速率21.2 mL/(h·g),较对照组提高33%.投加单质Fe试验中,Fe粉剂量1000mg/L获得最大产氢量156.1mL/g,较对照组提高44%;Fe粉剂量500mg/L获得单位VSS最大比产氢速率23.5mL/(h·g),较对照组分别提高47%.单质Fe浓度高于50mg/L时,对发酵菌群产氢的促进作用要优于同浓度下的Fe²⁺.同时对混合细菌中铁的全量和形态分布进行了考察.     

阻挡放电联合金属氧化物催化降解H2S的研究

采用介质阻挡放电联合金属氧化物催化降解气态H2S,考察了单组分及复合金属氧化物催化剂、催化剂与低温等离子体结合方式对H2S及副产物O3去除性能的影响,分析了等离子体联合Mn复合金属氧化物催化降解H2S机理。结果表明,金属负载量相同条件下,电压低于22kV时,Mn复合金属氧化物对H2S的催化活性高于单组分Mn金属氧化物,催化活性及对O3的分解能力从大到小依次为:Ag+Mn、Cu+Mn、Fe+Mn、Mn。当电压为18 kV时,Ag+Mn、Cu+Mn、Fe+Mn复合催化剂分别比单组分Mn催化剂对H2S的去除效率提高了近10%、6%、4%。等离子体后催化区域中Mn催化剂催化氧化H2S的效率明显低于等离子体催化区域。Mn催化剂在等离子体后催化区域中能有效催化分解O3。随着电压的升高,Mn金属氧化物在等离子体后催化区域对H2S催化作用逐渐增强。在电压22 kV时,等离子体联合后催化比单独等离子体作用时,H2S去除效率提高了近11%。     

含硫天然气净化厂硫化氢泄漏分析及对策

以川东北某含硫天然气净化厂为对象,通过分析该净化厂的处理工艺及可能造成泄漏的各种原因,确定了硫化氢泄漏危险较高的生产单元。通过工艺压力、流量、物料组分的比对,选取了脱硫单元原料气和硫磺回收单元酸性气作为模拟泄漏物料。对该厂所在地的气象条件和厂区的地形地貌进行了调查,净化厂当地近5年风速、云量统计表明低风速和多云为主导天气,将D1.5m/s作为模拟硫化氢泄漏扩散的典型气象条件。采用了美国石油学会(API)推荐地面粗糙度长度。运用PHAST软件计算了在典型气象条件下通过3种不同孔径泄漏1 min,5min和30min,形成的立即危及生命或健康(IDLH)范围。在典型气象条件下IDLH的下风向边界距离在41m至1190m范围内,以硫磺回收单元的大孔径泄漏为最远。以小孔泄漏为例模拟并讨论了风速、大气稳定度对硫化氢扩散的影响。为降低H2S泄漏风险提出了在线监测及联锁系统设置的要求,对避免和减少硫化氢中毒伤亡事故具有指导意义。     

钻屑法测定煤层H_2S含量

为了测定煤层硫化氢(H2S)含量,防治矿井H2S涌出,提出一种通过钻屑法测定煤层H2S含量的方法。在未受采动影响的新鲜煤壁,采用钻屑法取样,通过测定煤样H2S解吸量、取样过程损失量和H2S残存量确定煤层H2S含量。根据溶于水中H2S的p H值和色谱分析解吸气体中H2S体积分数,确定H2S解吸量;根据煤样解吸规律和气样H2S体积分数,确定H2S损失量;根据色谱分析残存气体中H2S体积分数,确定其残存量。用此方法,对山西某矿H2S涌出煤层进行现场和实验室测定。研究表明,该矿H2S含量为(4.465~6.701)×10-3m3/t。钻屑法测定煤层H2S含量是可行的,可以为矿井H2S治理提供基础数据。     

Ammonium nitrate thermal decomposition with additives

Runaway reactions present a potentially serious threat to the chemical process industry and the community; such reactions occur time and time again often with devastating consequences. The main objective of this research is to study the root causes associated with ammonium nitrate (AN) explosions during storage. The research focuses on AN fertilizers and studies the effects of different types of fertilizer compatible additives on AN thermal decomposition. Reactive Systems Screening Tool (RSST) has been used for reactivity evaluation and to better understand the mechanisms that result in explosion hazards. The results obtained from this tool have been reported in terms of parameters such as “onset” temperature, rate of temperature and pressure rise and maximum temperature. The runaway behavior of AN has been studied as a solid and solution in water. The effect of additives such as sodium sulfate (Na₂SO₄) and potassium chloride (KCl) has also been studied. Multiple tests have been conducted to determine the characteristics of AN decomposition accurately. The results show that the presence of sodium sulfate can increase the “onset” temperature of AN decomposition thus acting as AN thermal decomposition inhibitor, while potassium chloride tends to decrease the “onset” temperature thus acting as AN thermal decomposition promoter.     

Hybrid H2/Al dust explosions in Siwek sphere

Explosion indices and explosion behaviour of Al dust/H₂/air mixtures were studied using standard 20 l sphere. The study was motivated by an explosion hazard occurring at some accidental scenarios considered now in ITER design (International Thermonuclear Experimental Reactor). During Loss-of-Vacuum or Loss-of-Coolant Accidents (LOCA/LOVA) it is possible to form inside the ITER vacuum vessel an explosible atmosphere containing fine Be or W dusts and hydrogen. To approach the Be/H₂ explosion problem, Be dust is substituted in this study by aluminium, because of high toxicity of Be dusts. The tested dust concentrations were 100, 200, 400, 800, and 1200 g/m3; hydrogen concentrations varied from 8 to 20 vol. % with 2% step. The mixtures were ignited by a weak electric spark. Pressure evolutions were recorded during the mixture explosions. In addition, the gaseous compositions of the combustion products were measured by a quadruple mass-spectrometer. The dust was involved in the explosion process at all hydrogen and dust concentrations even at the combination ‘8%/100 g/m3’. In all the other tests the explosion overpressures and the pressure rise rates were noticeably higher than those relevant to pure H₂/air mixtures and pure Al dust/air mixtures. At lower hybrid fuel concentrations the mixture exploded in two steps: first hydrogen explosion followed by a clearly separated Al dust explosion. With rising concentrations, the two-phase explosion regime transits to a single-phase regime where the two fuel components exploded together as a single fuel. In this regime both the hybrid explosion pressures and pressure rise rates are higher than either H₂ or Al ones. The two fuels compete for the oxygen; the higher the dust concentration, the more part of O2 it consumes (and the more H₂ remains in the combustion products). The test results are used to support DUST3D CFD code developed at KIT to model LOCA or LOVA scenarios in ITER.     

Effects of pond salinization on survival rate of amphibian hosts infected with the chytrid fungus

The chytrid fungus Batrachochytrium dendrobatidis has been implicated in the decline and extinction of amphibian populations worldwide, but management options are limited. Recent studies show that sodium chloride (NaCl) has fungicidal properties that reduce the mortality rates of infected hosts in captivity. We investigated whether similar results can be obtained by adding salt to water bodies in the field. We increased the salinity of 8 water bodies to 2 or 4 ppt and left an additional 4 water bodies with close to 0 ppt and monitored salinity for 18 months. Captively bred tadpoles of green and golden bell frog (Litoria aurea) were released into each water body and their development, levels of B. dendrobatidis infection, and survival were monitored at 1, 4, and 12 months. The effect of salt on the abundance of nontarget organisms was also investigated in before and after style analyses. Salinities remained constant over time with little intervention. Hosts in water bodies with 4 ppt salt had a significantly lower prevalence of chytrid infection and higher survival, following metamorphosis, than hosts in 0 ppt salt. Tadpoles in the 4 ppt group were smaller in length after 1 month in the release site than those in the 0 and 2 ppt groups, but after metamorphosis body size in all water bodies was similar . In water bodies with 4 ppt salt, the abundance of dwarf tree frogs (Litoria fallax), dragonfly larvae, and damselfly larvae was lower than in water bodies with 0 and 2 ppt salt, which could have knock‐on effects for community structure. Based on our results, salt may be an effective field‐based B. dendrobatidis mitigation tool for lentic amphibians that could contribute to the conservation of numerous susceptible species. However, as in all conservation efforts, these benefits need to be weighed against negative effects on both target and nontarget organisms.     

氯化钠/纳米疏水二氧化硅超细干粉制备及灭火性能研究

选用氯化钠为基体制备金属火灾超细干粉灭火剂。应用反溶剂法对其改性,使纳米疏水二氧化硅吸附在氯化钠晶体表面,其中分散剂为PEG-1000。结果表明,纳米疏水二氧化硅的添加有利于细化氯化钠颗粒,但过量的添加会起反作用,最佳用量为3 wt%左右,平均粒径为2.18μm。镁片灭火实验证明超细复合干粉的灭火性能明显好于传统氯化钠灭火剂(商用D类灭火剂),纳米疏水二氧化硅最佳添加量为3 wt%,此时灭火时间仅需传统灭火剂的一半。最后利用FDS5.0模拟干粉颗粒与燃烧火焰作用过程,模拟结果表明干粉覆盖对火焰具有一定的抑制效果,并分析了复合干粉灭火机理。     

Na_2CO_3/H_2O_2“稳定”的CO_2的型体研究(Ⅱ)——“稳定性二氧化氯”溶液的UV吸收光谱、纸层析特性、微观结构和离子色谱分析

本文对以稳定剂H_2O_2和Na_2CO_3与ClO_2制备的所谓"稳定性二氧化氯"溶液的UV吸收光谱、纸层析特性、微观结构及离子色谱进行了分析,并与纯NaClO_2及ClO_2溶液做了对比.结果表明,“稳定性二氧化氯” 与NaClO_2在UV吸收光谱、层析比移值、微观结构、离子色谱这几方面都具有很好或极其相似的一致性 表明“稳定性二氧化氮’与NaClO_2溶液中氯氧化物存在型体的一致性.因此,认为“稳定性二氧化氯“溶液中ClO_2是以亚氯酸盐ClO_2~-的型体存在的.