电凝聚臭氧化耦合工艺的二级出水处理特性与机理研究

构建电凝聚臭氧化耦合工艺对城市污水处理厂二级出水进行深度处理,研究了不同初始pH值、臭氧投加量和电流密度对二级出水处理效果的影响.结果表明,当初始pH值为5、臭氧投加量为1.5 mg·mg^-1、电流密度为15 mA·cm^-2时,该工艺处理效果达到最佳,二级出水中溶解性有机物的去除率可达到58.6%.与单独电絮凝和臭氧氧化工艺相比,耦合工艺对有机物有更好的去除效果.由于金属盐水解产物可以作为臭氧化的催化剂,为了甄别其活性点位,将磷酸盐引入体系中,结果表明磷酸盐占据了混凝剂水解产物表面的羟基,从而阻碍了臭氧与水解铝盐混凝剂之间的反应,使得有机物的去除率降低,傅立叶红外(FT-IR)分析的结果进一步证明表面羟基是产生的铝盐混凝剂催化臭氧化的活性点位.为了进一步明确该耦合工艺去除溶解性有机物的机理,选择对氯苯甲酸(pCBA)探针法间接证明和电子顺磁共振(EPR)实验直接证明体系中羟基自由基(·OH)的存在,结果表明,电凝聚臭氧化耦合工艺较单独臭氧氧化工艺产生了更多的·OH,说明电絮凝产生的铝盐混凝剂水解产物可以作为催化剂催化臭氧产生·OH,提升体系对...     

Ozonation of azo dye in a semi-batch reactor: a determination of the molecular and radical contributions

Azo dye ozonation was carried in a semi-batch reactor to evaluate both the molecular and radical contributions of ozone on the dye decay. From two mass balance equations, the simultaneous determination of mass transfer, self-decomposition and solubility parameters of ozone were determinated; thus establishing the steady state conditions in the experimental system. The results of kinetic studies showed that the decay of azo dye was a pseudo-first-order reaction with respect to dye concentration and the overall rate constant increased with an increase in the pH, however declined with an increase in the dye concentration. Furthermore, from the overall rate constants obtained at various pH values a mathematical analysis of dye decay was performed, which provides a practical new method to quantify the radical and molecular contributions in the ozonation of azo dyes.     

臭氧氧化去除二级出水中PPCPs的研究

药品及个人护理用品(PPCPs)是一类痕量、顽固的新兴有机污染物,采用传统水处理工艺不易去除,需深度处理。采用批量试验方法,研究了臭氧氧化二级出水中添加的19种PPCPs的去除效果,考察了臭氧投加量、p H值、自由基抑制剂对去除效率的影响,并根据氧化产物推断可能的反应途径。结果表明,在原水水样p H=7.1条件下,臭氧质量浓度为1.2 mg/L时,能有效去除大多数PPCPs。其中,抗生素类PPCPs和个人防护类PPCPs的去除率分别达到了68%和70%,而雷尼替汀和噻苯咪唑去除效果不明显,仅为17.73%和12.3%。增加臭氧投加量或提高反应p H值会显著提高除雷尼替汀和噻苯咪唑外的PPCPs去除率。加入的自由基抑制剂对臭氧氧化PPCPs有明显抑制作用。PPCPs的氧化降解产物有机酸会降低反应p H值,进而影响PPCPs的去除效果。     

Degradation of atrazine by catalytic ozonation in the presence of iron scraps: performance,transformation pathway,and acute toxicity

Degradation of atrazine by catalytic ozonation in the presence of iron scraps (ZVI/O₃) was carried out. The key operational parameters (i.e., initial pH, ZVI dosage, and ozone dosage) were optimized by the batch experiments, respectively. This ZVI/O₃ system exhibited much higher degradation efficiency of atrazine than the single ozonation, ZVI, and traditional ZVI/O₂ systems. The result shows that the pseudo-first-order constant (0.0927?min^?1) and TOC removal rate (86.6%) obtained by the ZVI/O₃ process were much higher than those of the three control experiments. In addition, X-ray diffraction (XRD) analysis indicates that slight of γ-FeOOH and Fe₂O₃ were formed on the surface of iron scrap after ZVI/O₃ treatment. These corrosion products exhibit high catalytic ability for ozone decomposition, which could generate more hydroxyl radical (HO^?) to degrade atrazine. Six transformation intermediates were identified by liquid chromatography-mass spectrometry (LC-MS) analysis in ZVI/O₃ system, and the degradation pathway of atrazine was proposed. Toxicity tests based on the inhibition of the luminescence emitted by Photobacterium phosphoreum and Vibrio fischeri indicate the detoxification of atrazine by ZVI/O₃ system. Finally, reused experiments indicate the approving recyclability of iron scraps. Consequently, the ZVI/O₃ system could be as an effective and promising technology for pesticide wastewater treatment.     

Mn-Co/蜂窝陶瓷催化剂制备及催化臭氧化对苯二酚效能

为了提高金属催化剂的活性和使用寿命,以硝酸钴Co(NO3)2·6H2O和硝酸锰Mn(NO3)2作为前驱体,蜂窝陶瓷(ceramic honeycomb,CH)作为载体,采用涂覆法制备了4种不同质量比的Mn-Co/CH催化剂,通过XRD、N2-吸附/脱附、FESEM和XPS等方法分析了催化剂的结构,研究了催化剂的材料力学性能,建立了单独臭氧和催化臭氧化对苯二酚的反应动力学模型,考察了催化剂催化臭氧化的效能.结果表明,Mn1Co1/CH(Mn∶Co=1∶1)催化剂的晶相主要以Mn3O4和Co O为主,具有较大的比表面积、孔容和孔径,分别达到190 m~2·g~(-1)、0.25 cm3·g-1和4.8 nm;Mn1Co1/CH催化剂的催化活性最高,对苯二酚和COD的去除率分别达到78%和54%.Mn-Co/CH催化剂的抗压缩强度大(15.89~16.94 MPa).当添加叔丁醇时,对苯二酚去除率显著下降,·OH在Mn1Co1/CH催化臭氧化过程中起着重要的作用,催化臭氧化对苯二酚符合一级反应动力学模型.Mn-Co/CH催化剂用量少、催化效率高、使用寿命长,易于实现工业化.     

Removal of a type of endocrine disruptors-di-n-butyl phthalate from water by ozonation

Ozonation of synthetic water containing a type of endocrine disruptor-di-n-butyl phthalate （DBP） was examined. Key impact factors such as pH, temperature, ionic strength, ozone dosage and initial DBP concentration were investigated. In addition, the activities of radicals on uncatalysed and catalysed ozonation were studied. The degradation intermediate products were followed and the kinetic of the ozonation were assessed as well. Results revealed that ozonation of DBP followed two mechanisms. Firstly, the reaction rate of direct ozonation was slower at lower pH, temperature, and ionic strength. Secondly, when these factors were increased for indirect radical reaction, higher percentage of DBP was removed with the increase of the initial ozone dosage and the decrease of the initial DBP concentration. In addition, tea-butanol, humic substances and Fe（Ⅱ） affected DBP ozonation through the radical pathway. It was determined that ozonation was restrained by adding tea-butanol for its radical inhibition effect. Furthermore, humic substances enhanced the reaction to some extent, but a slight negative effect would be encountered if the optimum dosage was exceeded. As a matter of fact, Mn（Ⅱ） affected the ozonation by ＂active sites＂ mechanism. In the experiment, three different kinds of intermediate products were produced during ozonation, but the amount of products for each one of them decreased as pH, temperature, ionic strength and initial ozone dosage increased. A kinetic equation of the reaction between ozone and DBP was obtained.     

BP及RBF人工神经元网络对臭氧生物活性炭水处理系统建模的比较

运用BP和RBF人工神经元网络建立臭氧生物活性炭系统模型,考察了两个网络对水处理系统建模的适应性。研究表明,BP和RBF人工神经元网络的臭氧生物活性炭系统模型准确地描述了系统影响因素的关系,可以求出系统中臭氧的经济投量;用BP人工神经元网络建立水处理系统模型,泛化能力好,但逼近速度较慢;运用RBF人工神经元网络建模,泛化能力较差,但逼近速度快。该项研究克服了运用传统方法建模的不足,为实现水处理系统的优化设计提供了可行的途径。     

催化臭氧氧化染料溶液的研究

采用催化臭氧化技术降解染料废水,以甲基紫溶液为目标污染物,研究了过渡型金属离子的类型,Fe2+的浓度,溶液初始pH值,染料浓度和正丁醇等因素对其降解率的影响。实验结果表明:臭氧氧化甲基紫溶液的过程中,加入一定浓度的过渡型金属离子对甲基紫的去除具有促进作用;当臭氧浓度为16 mg/L,一定浓度范围内,Fe2+催化臭氧化的效果随着浓度的增加而增加,但Fe2+浓度为13 mg/L时,甲基紫的降解率下降;在酸性范围时,pH值增大其降解率会减小;染料浓度增加,甲基紫的降解率减小,但是其绝对降解值会增加;正丁醇的加入抑制氧化反应的进行,甲基紫的降解率下降,说明催化臭氧化过程中有羟基自由基产生。染料降解过程符合一级反应动力学规律。     

臭氧氧化法深度处理印染废水二级出水

采用臭氧氧化法深度处理印染废水二级出水,以比臭氧消耗量为基础讨论出水水质的改善情况.实验结果表明:当比臭氧消耗量为6.5 mg/mg 时,出水的吸光度在400 nm处减少90%以上,在254 nm处减少85%以上;出水的溶解性有机碳质量浓度为11.23 mg/L、COD为16.3 mg/L;臭氧分子直接氧化对降低色度和去除有机物起到一定作用,采用臭氧氧化法深度处理印染废水二级出水在技术上是可行的.     

玉裂废水粘度对二氧化锰臭氧催化氧化处理特性的影响

通过FT-IR和GC—MS检测分析,表明了压裂废水中有机物主要以苯环结构为主的芳香类化合物和其他杂环化合物,苯环及杂环上的主要官能团包括酮、酯、羧酸、醛、酚、氨基等。同时,压裂废水中的粘度为常规水粘度的2～3倍。针对压裂废水高粘度和高COD污染水质特征,实验研究了压裂废水二氧化锰臭氧催化氧化处理特性以及粘度对处理效果的影响,研究结果表明,在粘度较高（2．2×10-3 Pa·s）压裂废水中,投加的化学药剂很难扩散,羟基自由基·OH的利用效率较低,处理效果较差。通过投加过硫酸钾（5g／L）降粘后,可在很大程度上提高二氧化锰臭氧催化氧化的处理效果。通过对压裂废水中有机物分子量分布、FT-IR分析以及GC—MS分析可知,二氧化锰臭氧催化氧化处理压裂废水是通过激发羟基自由基,破坏水中有机物极性和有机物化学构造,将复杂长链有机物转变为简单有机物,其出水COD可达到国家污水综合排放标准中的二级排放标准。