Feasibility of honeycomb monolith supported sugar catalyst to produce biodiesel from palm fatty acid distillate (PFAD)

Carbon coated monolith was prepared by sucrose solution 65 wt.% via dip-coating method. Sulfonation of incomplete carbonized carbon coated monolith was carried out in order to synthesize solid acid catalyst. The textural structure characteristics of the solid acid catalyst demonstrated a low surface area and pore volume. Palm fatty acid distillate (PFAD), a by-product of palm oil refineries, was utilized as oil source in biodiesel production. The esterification reaction subjected to different reaction conditions was performed by using the sulfonated carbon coated monolith as heterogeneous catalyst. The sulfonation process had been performed by using vapour of concentrated H₂SO₄ that was much easier and efficient than liquid phase sulfonation. Total acidity value of carbon coated monolith was measured for unsulfonated sample (0.5 mmol/g) and sulfonated sample (4.2 mmol/g). The effect of methanol/oil ratio, catalyst amount and reaction time were examined. The maximum methyl ester content was 89% at the optimum condition, i.e. methanol/oil molar ratio (15:1), catalyst amount (2.5 wt.% with respect to PFAD), reaction time (240 min) and temperature 80 °C. The sugar catalyst supported on the honeycomb monolith showed comparable reactivity compared with the sugar catalyst powder. However, the catalyst reusability studies showed decrease in FFA% conversion from 95.3% to 68.8% after four cycles as well as the total acidity of catalyst dropped from the value 4.2 to 3.1 mmol/g during these cycles. This might be likely due to the leaching out of SO₃H group from the sulfonated carbon coated monolith surface. The leaching of active species reached a plateau state after fourth cycle.     

斜管沉淀池应用中存在问题的探讨

斜管沉淀池是目前广泛使用的污水物化处理工艺。针对实际应用所遇到的问题，如沉淀池进口布水不均匀，致使出水水质下降，从沉淀的基础理论，通过水力学的分析，较深入地说明了斜管沉淀池矾花泛起，水质恶化的原因。并提出了应用斜管沉淀池应注意的事项。     

从自燃煤矸石中提取聚合铝铁(PAFC)的试验研究

采用盐酸酸浸的方法从自燃煤矸石中提取聚合铝铁，对煤矸石的粉碎粒径、酸浸盐酸的浓度及用量、酸浸的温度等工艺条件进行了试验研究。结果表明，从100g自燃煤矸石中，可提取19．85g固体聚合铝铁，成品的Al2O3含量33％、Fe2O3含量16％、盐基度70％。     

水解酸化＋两级生物接触氧化处理高盐度水产品加工废水

介绍了“水解酸化＋两级生物接触氧化”处理水产品加工废水的运行效果和工程实例，结果表明：对C1^-浓度平均6000mg／L的高盐度水产品加工废水，系统对COD、SS、氨氮的去除率分别超过了88％、90％、85％，出水COD、SS、氨氮分别低于100mg／L、70mg／L、15mg／L，出水完全可以达到《污水综合排放标准》（GB8978—1996）一级排放标准。     

Vitamins,folic acid and neural tube defects: Comments on investigations in the United States

No clear answer concerning whether multivitamin/folate supplementation prevents neural tube defects (NTDs) is provided by three studies in the United States. All these studies are occurrence in nature, no recurrence studies having been conducted. The Atlanta Birth Defects Study is subject to pronounced memory and recall biases, the length between event and interview being as long as 16 years. In a second study (Boston University), objections can be raised to certain aspects of the experimental design, and the claim that 22 per cent of women started vitamins sufficiently early after pregnancy diagnosis to influence NTD formation is suspicious. Our NICHD case control study of 541 women in California and Illinois revealed no evidence for multivitamins or folic acid preventing NTDs. U.S. public policy-makers face difficulties in applying results of recurrence or occurrence studies in high-risk areas to low-risk areas in the U.S.     

Pulse cleaning flow models and numerical computation of candle ceramic filters

ＩｎｔｒｏｄｕｃｔｉｏｎＣｌｅａｎｉｎｇｔｈｅｆｉｎｅｐａｒｔｉｃｌｅｓｉｎｈｉｇｈｔｅｍｐｅｒａｔｕｒｅ (450℃ -950℃ )ａｎｄｈｉｇｈｐｒｅｓｓｕｒｅｃｏｎｄｉｔｉｏｎｃａｎｅｎｈａｎｃｅｔｈｅｔｈｅｒｍａｌｅｆｆｉｃｉｅｎｃｙｏｆｃｌｅａｎｃｏａｌｔｅｃｈｎｏｌｏｇｉｅｓｓｕｃｈａｓＩＧＣＣｏｒＰＦＢＣ .Ｒｉｇｉｄｃｅｒａｍｉｃｆｉｌｔｅｒｓｏｆａｖａｒｉｅｔｙｏｆｓｔｒｕｃｔｕｒｅｓａｒｅｕｎｄｅｒｄｅｖｅｌｏｐｍｅｎｔｉｎｐｒｏｇｒａｍｓａｒｏｕｎｄｔｈｅｗｏｒｌｄ ,ｗｈｉｃｈｃａｎｆｉ…     

模拟酸露对植物影响的实验

模拟酸露对植物影响的实验结果表明，用酸露处理后，蚕豆的生理指标发生一定的变化，尤以ｐＨ１３．０时的变化较明显，显示了模拟酸露对植物的伤害作用。     

煤矸石制取聚羟基氯化铝的研究

介绍了用煤矸石制取聚羟基氯化铝的方法,研究了酸浸、调整盐基度等过程的最佳工艺过程。     

高强铝合金超塑挤压成形

主要介绍了工业牌号高强铝合金在供应态或经简单预处理后在通用油压机上超塑成形的实例,并分析探讨了非理想组织材料超塑成形中微观组织的变化。     

开式冷挤压成形深小锥孔件时极限变形程度的理论研究

给出了深小锥孔件开式冷挤压成形时极限变形程度的定义,建立了变形区非稳态连续速度场;利用上限原理得到了极限变形程度的理论判据。分析了各主要参数对极限变形程度的影响规律,对指导制定深小锥孔件开式冷挤压成形工艺具有重要意义。