扰动强度对钝化剂抑制滇池沉积物磷释放的影响

选取滇池福保湾表层沉积物,以聚合氯化铝为钝化剂,研究了扰动强度对钝化剂抑制沉积物中磷释放的影响.结果表明,当扰动强度低于一定范围时,聚合氯化铝对沉积物中的磷有抑制作用,当转速为0,60,120r/min时,对应的水中磷浓度分别为初始值的62.5%,71.7%和83.4%;当转速达到240r/min时,沉积物会向水中释放大量磷,钝化作用完全被破坏,水中磷浓度为初始值的3.3倍.此外,在转速低于120r/min时,磷形态主要是以无机磷(DIP)为主的溶解性磷(DTP),而转速达到240r/min时,水中DTP/TP30%,DIP/DTP40%,即磷形态主要为不溶性磷,溶解性磷中以有机磷(DOP)为主.     

关于用能量同化波浪作用下溢油乳化的研究思想和思考

介绍加拿大学者用能量概念解决化学实验室锥形瓶或烧杯,水动力学物理模拟实验室水槽以及自然界海岸线波浪破碎等不同尺度下波浪同溢油乳化行为之间关系的同化方法和针对某些特殊问题所采取的措施以及新的尝试.从物理模拟实验室尺度和自然界海岸线尺度提出一些思考问题,并从发展的角度和中国同加拿大研究设备、能力和观点上的差异,提出中国曾经开展的类似研究是否有再度崛起的可能性,使得研究成果成为溢油乳化和溢油清理科学技术的基础,并带动解决冻结水域溢油乳化现象的理论解释.     

Performance of a diesel engine with water emulsified diesel prepared with optimized process parameters

An attempt has been made to produce stable water–diesel emulsion with optimal formulation and process parameters and to evaluate the performance and emission characteristics of diesel engine using this stable water–diesel emulsion. A total of 54 samples were prepared with varying water/diesel ratio, surfactant amount and stirring speed and water separation was recorded after 24 and 48 hr of emulsification. The recorded data were used in artificial neural network (ANN)-particle swarm optimization (PSO) technique to find the optimal parameters to produce water–diesel emulsion for engine testing. The predicted optimal parameters were found as 20% water to diesel ratio, 0.9% surfactant and 2200 rpm of stirrer for a water separation of 14.33% in one day with a variation of 6.54% against the actual value of water separation. Water–diesel emulsion fuel exhibited similar fuel properties as base fuel. The peak cylinder gas pressure, peak pressure rise rate and peak heat release rate for water–diesel were found higher as compared to diesel at medium to full engine loads. The improved air-fuel mixing in water–diesel emulsion enhanced brake thermal efficiency (BTE) of engine. The absorption of heat by water droplets present in water–diesel emulsion led to reduced exhaust gas temperature (EGT). With water–diesel emulsion fuel, the mean carbon monoxide (CO), unburned hydrocarbon and oxides of nitrogen (NO_x) emissions reduced by 8.80, 39.60, and 26.11%, respectively as compared to diesel.     

高炉炉顶煤气中HCl气体脱除的试验研究

高炉炉顶煤气中HCl气体会加速TRT叶片和煤气管道腐蚀。脱除高炉炉顶煤气中HCl气体可以采用石灰石、轻烧石灰石、Na_2CO_3和KOH作为脱氯剂的活性组分,脱氯剂粒度控制为3~6 mm、脱氯剂料层厚度控制为200 mm以上并适当提高煤气温度来改善高炉煤气中HCl气体的脱除过程。     

硫酸/硫酸钠复合淋洗剂对铬渣的淋洗效果研究

以湖南长沙某铬盐厂铬渣为研究对象,通过室内模拟实验,采用振荡淋洗方法研究了硫酸-硫酸钠复合淋洗剂对铬渣污染场地Cr的淋洗效果,探讨了淋洗剂浓度、液固比和淋洗时间等对淋洗效果的影响,以及淋洗前后重金属形态的变化,并通过对比试验研究了硫酸钠、柠檬酸、草酸、Na2-EDTA、硫酸、柠檬酸-柠檬酸三钠以及盐酸-氯化钠作为淋洗剂对总铬和六价铬的淋洗效果。结果表明:硫酸/硫酸钠复合淋洗剂在浓度为0.4 mol/L,液固比为20∶1,反应时间为6 h,常温条件下可以达到最佳淋洗效果,总铬和六价铬的浸出效率分别为70.35%和71.56%;另外,重金属形态分析表明,该复合淋洗剂有效减少了铬渣中弱酸可提取态和有机物结合态Cr的百分比,使得残渣态Cr的百分比增加,从而降低了Cr的活性,达到修复目的。淋洗剂对比试验结果表明,与其他淋洗剂相比,硫酸-硫酸钠淋洗效果最好,其中的氢离子能与Cr~(3+)进行离子交换,而硫酸根能够有效地将钙与六价铬分离,对此高钙铬渣的处理更具针对性和有效性。     

BS-Ⅰ型乳液抑尘剂防治矿山运输路面扬尘

由2.0—5.0%乳化油、0.05%乳化剂和水制备而成的BS-Ⅰ型乳液抑尘剂,在山东铝厂矿山公司使用表明,一次喷洒0.8—2.0kg/m²,能使砂土或砂石运输路面粉尘从9.6—33.3mg/m³(平均19.5mg/m³)。在10—15昼夜内降至10mg/m³以下(平均4.3—5.8mg/m³)。使用该抑尘剂,大大减轻了路面扬尘污染,同时降低了车辆磨损和油耗。乳液抑尘剂良好的防尘效果主要是由其自身的物理化学性质决定的。     

乳化液膜法处理含氨基J酸工业废水中破乳的实验研究

针对当前乳化液膜法中关键步骤—破乳进行了实验性研究。对于煤油—LMA－1—NaOH膜体系,研究了化学法和交流低电压电破乳的可行性,重点研究了电破乳的方法及温度、液膜体系及电场强度对破乳的影响。结果表明：对本实验的膜体系,化学法破乳效果不佳,而低电压破乳效果较好,破乳后的LMA－1油相可重复使用,具有良好的工业化应用前景。     

Leaching of arsenic from coal fly ashes 2. Arsenic pre‐leaching with sodium gluconate solution

The present study deals with the development of an efficient and reliable process for safe disposal of coal fly ash to remove arsenic that has been found to be the most easily leachable and hazardous heavy metal in coal fly ash. Pre‐leaching of fly ash prior to disposal by a natural chelating agent, sodium gluconate (SG), was proposed and studied. Several operational factors influencing arsenic leachability, such as concentration of SG solution, liquid to solid ratio, pH, length of leaching time and leaching temperature were examined. Arsenic was found to leach out substantially with SG, but almost no further release was observed from the ash pre‐leached by SG. After the pre‐leaching treatment, the desirable high buffering capacity of the ash was well sustained. SG solution was effectively regenerated by activated alumina adsorption so that it could be successfully reused for multiple leaching/adsorption cycles.     

利用赤泥和造纸黑液研制散煤固硫助燃剂

根据钙系固硫剂固硫原理 ,将高CaO含量赤泥加入散煤中燃烧 ,发现其能够起到固硫的效果。但是赤泥的加入影响原煤的发热量 ,因此利用高有机质含量的造纸黑液来弥补其发热量的损失 ,从而研制成功了固硫助燃剂。试验结果表明 :固硫助燃剂能够起到对燃煤固硫助燃的效果 ,具有良好的应用前景     

无机超滤技术和生化处理技术在宝钢冷轧含油废水处理中的应用

冷轧废水处理是轧钢工艺中的难点之一。宝钢 2 0 30冷轧废水处理改造工程 ,首次将生化处理技术引入到冷轧含油废水处理工艺 ,并在工程中采用了无机陶瓷超滤技术 ,从而实现了冷轧废水处理的国产化及国内技术总成