Co-pyrolysis of paper waste and mustard press cake in a semi-batch pyrolyzer—optimization and bio-oil characterization

Under the present research study, the co-pyrolysis of paper waste and mustard press cake was conducted in a 50 mm diameter and 640 mm long semi-batch pyrolyzer in the temperature range of 673 to 1173 K in nitrogen atmosphere and synergistic relationship between the pyrolysis of two feed stocks has been observed. The paper wastes were composed of local packing paper, newspaper-based food packets of grocery, and printing paper in the ratio of 6:3:1. During co-pyrolysis, response surface methodology (RSM) technique has been employed using Design Expert Version 7.0.0 to determine the collective effects of factors, namely, A: ratio of paper waste to mustard press cake and B: pyrolysis temperature, on the yield of bio-oil, energy yield, and oxygen content of bio-oil. Optimization has been done by using RSM to identify the individual sets of values of independent parameters corresponding to maximum bio-oil yield (A: 9.0:1, B: 874.75 K), energy yield (A: 8.80:1, B: 812 K), and minimum oxygen content of bio-oil (A: 2.75:1, B: 883.06 K). Bio-oil obtained at maximum energy yield condition has been characterized using the Gas chromatography–mass spectrometry (GC-MS) and Fourier transform infrared spectroscopy (FTIR) spectroscopic analyses. The array of compounds present in the bio-oil compounds has been compared with literature data available on pyro-oil obtained from similar feed stocks.     

运用模糊层次分析法优选制浆造纸废水深度处理方案

制浆造纸废水最适深度处理方案的选择是一个多准则决策问题,本文通过建立评价指标体系,从经济费用、技术性能、管理效果和社会效益4个方面,对混凝沉淀（气浮）＋过滤、Fenton氧化和生态法3种深度处理方案进行分析;采用层次分析法确定指标体系权重,其中技术性能（0.5333）权重最高;结合模糊数学法开展综合评判,评估各方案的优缺点,最后通过方案总排序确定工程优选方案。同时,针对2个具有代表意义的制浆造纸企业废水深度处理工程案例,在方案隶属度的确定时增加了决策者的期望值和企业的实际情况,分别选取了最适的制浆造纸废水深度处理方案：混凝沉淀（气浮）＋过滤法（A企业）和生态法（B企业）,这样可以更客观地指导决策者选取最合适的制浆造纸废水深度处理方案。     

废弃马铃薯渣改性制备瓦楞纸板粘合剂研究

研究了胶体磨湿法超微粉碎及高压蒸气处理对废弃污染物——马铃薯渣粒径分布及颗粒破坏程度的影响,调节胶体磨齿间隙为12μm处理30 min,并结合高压蒸气121℃处理20 min的条件下,通过显微镜观察和激光粒度分析证明马铃薯渣颗粒粒径明显减小且分布更加均匀,细胞壁和纤维素被破坏,体现出胶粘剂的性质。进而通过氧化变性处理改善其流动性,并添加一系列的助剂,制得了一种瓦楞纸板用粘合剂,其主要性能均接近于目前广泛使用的淀粉基瓦楞纸板粘合剂。     

造纸工业碱回收锅炉电除尘器设计要点

针对当前碱回收锅炉除尘器的除尘效率不能满足排放要求的情况,分析了目前造纸厂电除尘设备运行中出现的主要问题,提出了一些设计观点和相关建议。     

Biodegradation and detoxification of olive mill wastewater by selected strains of the mushroom genera Ganoderma and Pleurotus

Thirty-nine white-rot fungi belonging to nine species of Agaricomycotina (Basidiomycota) were initially screened for their ability to decrease olive-mill wastewater (OMW) phenolics. Four strains of Ganoderma australe, Ganoderma carnosum, Pleurotus eryngii and Pleurotus ostreatus, were selected and further examined for key-aspects of the OMW biodegradation process. Fungal growth in OMW-containing batch cultures resulted in significant decolorization (by 40-46% and 60-65% for Ganoderma and Pleurotus spp. respectively) and reduction of phenolics (by 64-67% and 74-81% for Ganoderma and Pleurotus spp. respectively). COD decrease was less pronounced (12-29%). Cress-seeds germination increased by 30-40% when OMW was treated by Pleurotus strains. Toxicity expressed as inhibition of Aliivibrio fischeri luminescence was reduced in fungal-treated OMW samples by approximately 5-15 times compared to the control. As regards the pertinent enzyme activities, laccase and Mn-independent peroxidase were detected for Ganoderma spp. during the entire incubation period. In contrast, Pleurotus spp. did not exhibit any enzyme activities at early growth stages; instead, high laccase (five times greater than those of Ganoderma spp.) and Mn peroxidases activities were determined at the end of treatment. OMW decolorization by Ganoderma strains was strongly correlated to the reduction of phenolics, whereas P. eryngii laccase activity was correlated with the effluent’s decolorization.     

制浆造纸废水生化出水的混凝处理研究

研究了硫酸铝和三氯化铁对制浆造纸废水生化出水的处理效果.研究发现,不调节原水pH值,硫酸铝投加量为600 mg/L或三氯化铁投加量为300mg/L时,混凝后废水的COD＜150 mg/L,色度＜50倍,出水均符合现阶段排放标准.混凝剂比较发现,在最佳反应条件下,2种混凝剂的处理效果相当,但硫酸铝混凝的成本低于三氯化铁....     

光记录相纸由湿度引起的量算误差

光记录相纸在不同的湿度下其宽度变化达 4 2 % ,而由此引起的误差将大大超过资料质量评比条例所规定的量标误差值 ,给数据处理带来影响。本文通过实验 ,得出了在不同湿度下的误差值 ,并提出解决该问题的一些办法与建议。     

制浆造纸废水生物强化技术研究进展

制浆造纸废水是国内外公认的难处理的工业废水之一,文章介绍了生物强化技术在制浆造纸废水中的应用现状,在分析中,主要从生物强化技术、固定化微生物技术和环境生物制剂等方面,总结了制剂造纸废水生物强化技术的研究进展,并讨论了今后的研究方向。     

沉积物和土壤中磷的生物有效性评估新方法

利用自制的氧化铁/醋酸纤维素复合膜(FeO/CAM)发展了一种沉积物和土壤磷的生物有效性评估的新方法. 结果表明:从沉积物和土壤中解吸的生物有效磷(FeO-P)含量随时间增加而增加,至16～20h左右,解吸过程接近平衡;随着土/水比增大而减小,至20～30g/L左右逐渐趋于平缓,且相对标准偏差较小;膜面积为20～30cm²时FeO-P含量差别较小,且相对标准偏差也较小;适当提高振荡频率(一般200r/min左右),有利于促进FeO-P的提取动力学过程.在用于评估水体沉积物和土壤解吸磷的生物有效性方面,FeO/CAM膜克服了氧化铁浸渍滤纸的缺点,易于商品化,具有更好的应用前景.     

造纸制浆集中生产及其碱回收与综合废水治理工艺设计

本文介绍了滑县锦华纸业集团新建漂白草浆集中制浆工艺、碱回收及全厂综合废水治理工艺设计。