Chloride Released from Three Permeable Pavement Surfaces after Winter Salt Application

Few studies exist on how chloride from chloride‐based deicers is transported in infiltration‐based stormwater control measures. In 2009, the U.S. Environmental Protection Agency (USEPA) constructed a 0.4 ha parking lot in Edison, New Jersey, that was surfaced with permeable interlocking concrete pavers (PICP), pervious concrete (PC), and porous asphalt (PA). Each surface type has four equally sized, lined sections that direct all infiltrate to separate 5.7 m³ collection tanks. The USEPA acute criterion for aquatic life (860 mg/l) was exceeded in events immediately following a snow event. Concentrations of the infiltrate exceeded the detection limit (5 mg/l) year round but did not exceed the USEPA chronic toxicity (230 mg/l) after April. The chloride concentration decreased with cumulative rainfall since previous snow event, and a power regression described this relationship. In the power regression, the coefficient (b) described the initial concentration following a snow event, and the exponent (m) described the rate in which chloride was flushed through the system with infiltrating water. PC had the largest coefficient (5,664) and largest absolute exponent (?0.92), followed closely by PICP (b = 4,943 and m = ?0.87), and distantly by PA (b = 2,907 and m = ?0.67). The differences in release rate were proportional to the measured surface infiltration rates of 4,000; 2,400; and 200 cm/h for PC, PICP, and PA, respectively. These results will assist those who manage or regulate stormwater where receiving waters are chloride impaired.     

废弃混凝土对C_3S形成动力学的影响

废弃混凝土中石灰石的含量比较稳定,适合取代天然石灰石作为钙质原料配制水泥生料,并含有少量的SiO2,可以起部分硅质原料的作用。硬化的水泥浆体在高温下脱水形成氧化钙、氧化铝和氧化铁等氧化物,都是制造水泥所必须的氧化物。实验室利用20%和40%的废弃混凝土代替部分石灰石制备水泥熟料。研究了废弃混凝土对硅酸盐水泥熟料形成动力学的影响。用快速滴定法测定了不同熟料中f-CaO含量,根据文章提出CaO反应生成C3S的转化率,并用Amhenius公式计算了熟料中C3S形成反应的表观活化能。研究表明:废弃混凝土能改善生料的易烧性,并能降低熟料的烧成温度。     

热障涂层对DD6单晶高温合金高周疲劳性能的影响

目的研究电子束物理气相沉积热障涂层对单晶高温合金高周疲劳性能的影响,为热障涂层在涡轮叶片上的应用提供技术支持。方法采用真空电弧镀和电子束物理气相沉积工艺制备YSZ热障涂层,进行900℃条件下高周疲劳性能测试,采用扫描电镜对测试后的试样表面、断口形貌进行观察与分析。结果在900℃、380 MPa条件下,带涂层的DD6单晶试棒循环次数(Nf)超过了107,420 MPa条件下超过了106。通过对DD6单晶试棒断口分析,失效后的带涂层试棒仍以DD6单晶常见滑移解离形式发生破坏。结论高周疲劳性能测试条件下,带YSZ热障涂层的试棒中粘结层率先产生垂直微裂纹,但是裂纹扩展延伸中发生氧化钝化,之后DD6基体沿正常的滑移方向从表面向内部疲劳扩展,带涂层的试棒疲劳裂纹并非由涂层微裂纹直接扩展形成,热障涂层对DD6单晶高温合金高周疲劳性能影响较小。     

电子束物理气相沉积制备热障涂层研究进展

介绍了电子束物理气相沉积设备的主要组成、工作原理和电子束物理气相沉积热障涂层的结构特点,并重点论述了工件转速、工件温度、靶材蒸汽入射角度、工件表面的粗糙度、粘结层预氧化、改性粘结层和双层陶瓷层等对电子束物理气相沉积热障涂层性能的影响。     

超限结构无缝法施工在污水处理工程中的应用

介绍了一种在超限混凝土结构中取消伸缩缝或增大伸缩缝最大间距的新型施工方法——超限混凝土结构无缝法施工。论述无缝法施工的原理及膨胀加强带的设置,探讨UEA膨胀混凝土的配制,在实践的基础上总结了无缝法施工的方法、注意事项及优点。     

高强与高性能混凝土温湿度场应力分析

针对高强与高性能混凝土易于开裂的特点,对高强高性能混凝土早期温湿度场随龄期发展的分布情况以及混凝土的收缩变形进行理论分析,建立相应的计算模型,编制三维有限元程序,分析在外界温湿度变化以及不同养护条件下由混凝土内部温差和湿度变化产生的温度应力和干燥收缩应力,从施工养护方法上探讨了高强与高性能混凝土抗裂性能的改善措施.     

Usage of polystyrene disposable food dishes in the lightweight concrete making

The increasing use and subsequent accumulation of polystyrene containers has triggered a substantial environmental problem. This study investigated using varied percentages of solid waste polystyrene disposable food dishes in the production of lightweight concrete samples with 350 kilograms per cubic meter (kg/m³) of cement and a density of 1,300 kg/m³. The polystyrene disposable dishes were ground into beads of 0–3 millimeters (mm) and 3–6 mm in size. First, the characteristics of Type II Portland cement, polystyrene, and aggregates were examined. The following characteristics of concrete using ASTM International and British Standards Institution standards were tested: slump, compressive strength, ability to resist chloride ion penetration, and resistance of concrete to rapid freezing and thawing cycles. Scanning electron microscopy (SEM) and energy dispersive X‐ray spectroscopy analytical techniques were also used. The slump of samples varied between 40 and 70 mm and was not dependent on either the polystyrene percentage or the size of the polystyrene beads in the concrete samples (p‐value > .05). The compressive strength of the concrete samples after 90 days of curing, and using different percentages of polystyrene, varied between 96 and 113 kilograms per square centimeter (kg/cm²). The resistance of the samples to the freezing and thawing cycle and chloride ion penetration were affected unfavorably by the presence of the polystyrene. The SEM technique indicated that concrete samples containing 15% and 25% polystyrene had denser crystals and less void than concrete samples with 40% and 55% polystyrene.     

考虑爆裂影响的钢筋混凝土梁火灾温度场数值分析

为了描述混凝土高温爆裂对构件热传导过程的影响,结合钢筋混凝土梁火灾试验,考虑爆裂时间和区域的不确定性,建立了火灾下钢筋混凝土梁数值分析模型,分析爆裂深度、爆裂面积比、爆裂位置等爆裂参数对梁跨中截面温度场的影响规律。研究结果表明:当钢筋混凝土梁发生受火爆裂,梁截面的温度显著升高,并随爆裂深度的增大而进一步增强;爆裂面积比对截面温度场影响不显著,当爆裂深度、爆裂位置一定,爆裂面积比增加达到13%左右时,截面温度场基本上不再变化;爆裂深度、爆裂面积比一定,梁跨中爆裂对截面温度场影响最大,但是底部纵筋处温度较顶部纵筋处温度升高较快。     

基于不同强度等级混凝土的动力学特性研究

基于TAW-2000D电液伺服岩石三轴仪和直径75 mm的霍普金森压杆试验装置,得到了C25,C35和C45混凝土在静、动载荷作用下的应力-应变曲线,探讨了混凝土强度等级、动态峰值强度、峰值应变和应变率之间的变化规律。结果表明:混凝土准静态应力-应变曲线和动态应力-应变曲线在形态上存在明显差异,动态应力-应变曲线的峰值点随应变率的增大向右上方移动,线弹性阶段各曲线斜率变化不明显;动态峰值应力、动态弹性模量和峰值应变均存在不同程度的率相关性,并且混凝土材料的应变率敏感性随其强度等级的提高而增强;混凝土C45的各力学指标对应变率的敏感性最强,C35次之,C25的应变率敏感性最弱;推导了应变率与强度等级和冲击速率之间的经验公式,三者之间存在非线性变化规律。     

用柠檬酸废渣生产蒸压加气砼砌块

本文介绍了用柠檬酸废渣代替天然石膏生产蒸压加气砼砌块，从而解决了长期以来柠檬酸生产厂家因排放柠檬酸废渣所造成的环境污染问题，开创了柠檬酸废渣直接运用的新途径。环境效益和经济效益都较明显。