Processing and Characterization of Short-Fiber Reinforced Jute/Poly Butylene Succinate Biodegradable Composites: The Effect of Weld-Line

Fabrication of complex injection molded parts often involves the use of multiple gates. In such situations, polymer melts from different gates meld to form the molded part (weld line). This paper reports on the fabrication and characterization of the mechanical and morphological properties of short fiber reinforced jute/poly butylene succinate (PBS) biodegradable composites. The effect of a dual gated mold in the fabrication of welded specimens was a key focus of the investigation. It was observed that incorporation of jute fiber (10 wt%) conferred drastic changes on the stress–strain properties of the matrix as the elongation at break (EB), dropped from 160% in the matrix to just 10% in the composite. The tensile strength of the composite was lower than that of the matrix. However, it is noteworthy that the tensile modulus of the composite increased. Bending test also revealed that both bending strength and modulus increased with the incorporation of jute. Morphological studies of the tensile fracture surface using SEM revealed two types of failure mode. Ductile failure was indicated by plastic deformation at the initiation of fracture followed by brittle failure. The good interfacial bonding indicated between jute and PBS was attributed to positive interaction between the two polar polymers. A comparison of the non-weld and weld-line samples revealed that the weld-line composites have better mechanical integrity than the corresponding polymer matrix with weld line. The results also revealed that elongation at break and toughness are most sensitive to the presence of the weld-line whereas flexural properties are least sensitive.     

Photodegradation of pentachlorophenol and its degradation pathways predicted using density functional theory

The objectives of the present research were (i) to report the mass balance of chlorine during pentachlorophenol (PCP) photodegradation and (ii) to reveal the photodegradation pathway experimentally with a theoretical proof based on the density functional theory (DFT). The chlorine of PCP was completely mineralized to produce chloride ions after 24h of UV irradiation. As intermediates, 2,3,5,6-tetrachlorophenol, 2,3,4,6-tetrachlorophenol and 2,5-dichlorophenol were identified. At least 80% of the chlorine balance during PCP photodegradation was accounted by PCP, these intermediates, and chloride ions. A DFT calculation showed differences in the C-Cl bond dissociation energy level and the positions of respective PCP molecular and the PCP intermediates. The dechlorination intermediates predicted using the calculated C-Cl bond dissociation energy were consistent with those experimentally confirmed, indicating the feasibility of this theoretical method in predicting the dechlorination pathway.     

Cytochrome p450 induction and gonadal status alteration in common carp (Cyprinus carpio) associated with the discharge of dioxin contaminated effluent to the Hikiji River,Kanagawa Prefecture,Japan

Accumulations of polychlorinated dibenzo-p-dioxins, dibenzofurans and coplanar polychlorinated biphenyls were analyzed in common carp (Cyprinus carpio) collected in the Hikiji River, Kanagawa Prefecture, Japan in which dioxin contaminated effluent was released during the period starting from November 1992 to March 2000. Higher levels of 2,3,7,8-tetrachlorinated dibenzo-p-dioxin toxic equivalents were observed in carps collected downstream to the dioxin release site (contaminated site) than the reference site. Modulations of cytochrome p450 (CYP) enzyme in liver, serum estrogen concentration and gonadal somatic index (GSI) were also measured as biomarkers for the contaminants. Total CYP content in livers was markedly higher in male and female carps from the contaminated site relative to the reference site fish. The expression level of the cytochrome p450 1A and Ethoxyresorufin O-deethylase activity were significantly higher in female carps from the contaminated site than from the reference site. A lower level of plasma estrogen was observed in carps from the contaminated site. The GSI in female carps from the contaminated site was smaller than that recorded at the reference site. The present study indicates that dioxins released to the Hikiji River might induce the CYP enzyme and inhibit the reproductive functions in common carps dwelling downstream from the release site.     

Silver speciation in liver of marine mammals by synchrotron X-ray absorption fine structure and X-ray fluorescence spectroscopies

The chemical form of Ag in the livers of five species of marine mammals was examined using X-ray absorption fine structure (XAFS) and X-ray fluorescence (XRF) spectroscopies. The XAFS analysis suggested that Ag(2)Se was present in the livers of the Franciscana dolphin (Pontoporia blainvillei), Dall's porpoise (Phocoenoides dalli), and Baird's beaked whale (Berardius bairdii), whereas Ag(2)S was present in the livers of the striped dolphin (Stenella coeruleoalba) and pygmy killer whale (Feresa attenuata). XRF spectroscopy results revealed that the distribution patterns of Ag and Se in a thin section of the liver of the Franciscana dolphin were the same; this also implied that Ag was associated with Se in the liver. Thus, the interaction of Ag with Se or S may offer significant protection against the toxicity of Ag in marine mammals. The formation of either Ag(2)Se or Ag(2)S might depend on the Hg levels in the liver. Ag(2)Se was observed in liver samples with relatively high Ag/Hg ratio, whereas liver samples with low Ag/Hg ratio contained Ag(2)S.     

Feasibility study of the separation of chlorinated films from plastic packaging wastes

This study describes the possible separation of chlorinated plastic films (PVC and PVDC) from other heavy plastic packaging waste (PPW) by selective twist formation and gravity separation. Twists formation was mechanically induced in chlorinated plastic films, whereas twist formation did not occur in PS and PET films. After twist formation, all the films had the apparent density of less than 1.0 g/cm³ and floated in water even though the true density was more than 1.0 g/cm³. However, the apparent density of the PS and the PET films increased with agitation to more than 1.0 g/cm³, whereas that of chlorinated plastic films was kept less than 1.0 g/cm³. The main reason would be the air being held inside the chlorinated plastic films which was difficult to be removed by agitation. Simple gravity separation after twist formation was applied for artificial film with 10 wt.% of the chlorinated films and real PPW films with 9 wt.% of the chlorinated films. About 76 wt.% of the artificial PPW films and 75 wt.% of real PPW films after the removal of PP and PE were recovered as settling fraction with 4.7 wt.% and 3.0 wt.% of chlorinated plastic films, respectively. These results indicate that simple gravity separation process after twist formation can be used to reduce the chlorinated plastic concentration from mixed heavy PPW films.     

Effects of dietary habits and CYP1A1 polymorphisms on blood dioxin concentrations in Japanese men

The major source of dioxin impurities in Japan in the past was agrochemical formulations; more recently, it has been exhaust from waste incinerators. To examine the environmental and genetic factors that influence blood dioxin concentration, we investigated the relationship among dioxin concentrations, dietary habits and cytochorome P450 1A1 (CYP1A1) polymorphisms (MspI type and Ile-Val type) in Japanese fishermen and farmers, including also a group of office workers as controls. The mean dioxin concentrations in the fishermen, the farmers and the controls were 161369, 79079 and 100500 pg/g fat, respectively. The elevated dioxin concentration with polychlorinated dibenzo-p-dioxins, polychlorinated dibenzofurans and coplanar-PCBs found in the fishermen may be due to the frequent consumption of fish; no such relationship was found both in the farmers and the controls. We found that the concentrations of congeners found as impurities in certain chemicals such as those previously used in agriculture showed no significant differences among the three groups; we consider it unlikely that the farmers would be directly exposed to dioxins from such chemicals. Thus, it is probable that the primary route of dioxin exposure in the Japanese population is through the food chain via fish consumption, regardless of occupation. No meaningful relationship between blood dioxin concentration and CYP1A1 polymorphisms was found in this study, although there was a significant difference between the concentration of total non-ortho-PCBs in genotypes A and B. Further studies on more subjects, including those of genotype C, are needed to confirm the relationship between blood dioxin concentrations and MspI polymorphisms.     

Photodegradation fates of cis-chlordane, trans-chlordane, and heptachlor in ethanol

cis-Chlordane, trans-chlordane, and heptachlor were photodegraded in ethanol, and their degradation fates and degradation products were determined by a computational chemical method. The most degradable material was heptachlor (first-order reaction constant k=0.13 min(-1)). Chlorine balances changed during UV irradiation, and the chlorine atoms in chlordane and heptachlor were eventually mineralized. cis-Chlordane, trans-chlordane and heptachlor each generated two di-dechlorinated products. Reactivities at various positions in these compounds were predicted on the basis of bond dissociation energies calculated by nonempirical molecular orbital calculation (Gaussian 98W).     

Polychlorinated dibenzothiophenes in Japanese environmental samples and their photodegradability and dioxin-like endocrine-disruption potential

Polychlorinated dibenzothiophenes (PCDTs) in sediment, soil, and fly ash samples collected in Japan were analyzed and their dioxin-like endocrine-disruption potential and photodegradability investigated. PCDTs were detected in all three types of sample, although the concentrations were lower than those of polychlorinated dibenzo-p-dioxins (PCDDs) and polychlorinated dibenzofurans (PCDFs). An Ah-immunoassay confirmed that 2,3,7,8-TeCDT, 1,2,3,7,8-PeCDT, 1,2,3,7,8,9-HxCDT, and 1,2,3,4,7,8,9-HpCDT had Ah receptor-binding activities, which means that these PCDTs have the potential to cause dioxin-like endocrine-disruption. Photodegradation of PCDTs by UV irradiation was accompanied by dechlorination. The photodegradation rates of 2,3,7,8-TeCDT and OCDT were lower than the rates for the corresponding PCDF isomers (2,3,7,8-TeCDF and OCDF), which indicates that PCDTs are more stable than PCDFs to photodegradation.