Comparison of Different Packing Materials for the Biofiltration of Air Toxics

Abstract

Four different biofilter packing materials (two porous ceramics, perlite, and open pore polyurethane foam) were compared for the removal of toluene vapors. The focus was on evaluating performance at relatively short gas retention time (13.5 and 27 sec). The reactors were initially operated as biotrickling filters with continuous feeding and trickling of a nutrient solution. After significant plugging of the biotrickling filter beds with biomass was observed, the operation mode was switched to biofiltration with only periodic supply of mineral nutrients. This resulted in stable conditions, which allowed detailed investigations over >6 months. The reactor packed with cattle bone Porcelite (CBP), a ceramic material containing some macronutrients and micronutrients, exhibited the highest performance. The critical load (i.e., load at which 95% removal occurred) was 29 g m^?3 hr^?1 at a gas retention time of 13.5 sec and 66 g m^?3 hr^?1 at a gas retention time of 27 sec. After the long-term experiment, the packing materials were taken from the reactors and examined. The reactors were divided into three sections, top, middle, and bottom, to determine whether spatial differentiation of biomass occurred. The assays included a double-staining technique to count total and live microorganisms and determination of moisture, protein, and dry weight contents. Microbial community analysis was also conducted by denaturing gradient gel electrophoresis. The results showed that most reactors had a significant fraction of inactive biomass. Comparatively, the CBP biofilter held significantly higher densities of active biomass, which may be the reason for the higher toluene removal performance. The analyses suggest that favorable material properties and the nutrients slowly released by the CBP provided better environmental conditions for the process culture.     

Reduction in toxicity and generation of slag in secondary lead process

This paper focuses on the improvement of a secondary lead recycling processing plant, giving special attention to the generation of lead slag. The study was conducted using two different industrial rotary furnaces that together produce three different slag types, which depend on charge composition and lead-containing raw material obtained from a lead-acid battery recycling process. First, characterization of three slag types from different batches was performed, and such characterization included chemical, mineralogical, and structural analyses. By analyzing these data and the operational conditions of the process, it was possible to identify certain deficiencies in the recycling process and implement modifications in order to improve it. A reduction of up to 25% in the quantity of slag generated could be achieved with certain charges. In addition to this process improvement, it was possible to reduce the toxicity of the slag produced when processing a charge containing the same proportion of paste and grid as the lead-acid battery. This improvement lessens the overall environmental impact of the process. By applying this methodology, it was possible to determine some principles of cleaner production in the lead recycling process. So, waste generation could be reduced via improvements in the process and slag characteristics were modified to decrease its toxicity (as determined by lead content in leaching tests).     

A comparison of concentration ratios for technetium and nutrient uptake by three plant species

Technetium (Tc) is a non-essential element for which accumulation mechanisms in plants have recently been discussed, but only from the viewpoint of existence of anion transport proteins in plant cells. In this study, using three kinds of plants (Cucumis sativus L., Raphanus sativus L., and Brassica chinensis L.), uptake of Tc and Re (a chemical analogue of Tc) were observed. The results showed that Tc and Re uptake occurred not only with water mass flow or active nutrient uptake, but also with uptake of nutrient cations such as K+. It is suggested here that most stable chemical form under aerobic conditions, TcO4-, is used in cation transport as a substitute ions, such as Cl-. After TcO4- passes through a root surface, it moves through the xylem together with cations. Due to these uptake mechanisms, Tc is highly accumulated in plants.     

Effect of phosphate addition on the sorption-desorption reaction of selenium in Japanese agricultural soils

Desorption levels of soil-sorbed selenium (Se) were studied by adding phosphate to 22 typical Japanese agricultural soils. Soil-soil solution distribution coefficients of Se (Kd-Se) were measured using a batch process as an index of Se sorption level, adding 75Se as a tracer. After the Kd measurement, extraction of soil-sorbed 75Se with a 0.1 M or 1 M Na2HPO4 solution followed to determine the amount of 75Se desorbed by the phosphate. When the 0.1 M Na2HPO4 solution was used, 18-70% of soil-sorbed Se was extracted (average: 47%). However, when the 1 M Na2HPO4 solution was used, 27-83% of soil-sorbed Se was extracted (average: 57%). The observed 75Se desorption percentage indicated the maximum Se removability by phosphate addition. The desorption percentage of Se with 1 M Na2HPO4 correlated with Kd-Se values, suggesting that the soil sample with higher Kd-Se contained more reactive components for phosphate-sorption than the soil sample with lower Kd-Se. To evaluate the effect of phosphate concentration on the Se sorption, the Kd-Se was measured for two typical soils under different levels of phosphate (0.1-10 mM PO4). The Kd values were decreased by phosphate addition for both soils. The Kd decrease was observed even for just 1 mM PO4. The phosphate addition with 1 mM PO4 is the same level as in P fertilizer applied to paddy fields in Japan. Therefore, it was suggested that Se desorption should occur in Japanese soils due to the phosphate input.     

Nitrate metabolism in abyssal waters

Activities of nitrate assimilation and nitrate reduction were measured 50 cm above the ocean floor (5,845 m and 5,207 m) by an in situ ¹⁵N tracer technique at stations in the subtropical (28°29.8′N; 144°58′E) and subarctic (44°10.2′N; 154°03′E) western North Pacific Ocean. Nitrate assimilation ranged from 0.009 to 0.11 μg-at N/1/day, and nitrate reduction from 0 to 0.42 μg-at N/1/day in the presence of added peptone and yeast extract. Nitrate assimilation was higher than nitrite formation at the southern station, but the reverse was the case at the subarctic station. No correlation was observed between bacterial growth and nitrate metabolizing activities. Data are also presented on the effect of hydrostatic pressures upon nitrate metabolism by microbial populations in the surface waters.     

Triterpenoid and caffeic acid derivatives in the leaves of ragweed, <Emphasis Type="Italic">Ambrosia artemisiifolia</Emphasis> L. (Asterales: Asteraceae), as feeding stimulants of <Emphasis Type="Italic">Ophraella communa</Emphasis> LeSage (Coleoptera: Chrysomelidae)

Summary. The leaf beetle Ophraella communa infests almost exclusively Ambrosia artemisiifolia in the fields of Japan, even though it normally feeds on several Asteraceous plants. A filter paper bioassay showed that the feeding of O. communa is strongly stimulated by methanolic extracts of A. artemisiifolia. The feeding stimulants for O. communa have been isolated from methanolic extracts of A. artemisiifolia. -Amyrin acetate, -amyrin acetate, 5-caffeoylquinic acid (chlorogenic acid) and 3,5-dicaffeoylquinic acid from A. artemisiifolia have been identified as feeding stimulants for O. communa. Triterpenoid derivatives (-amyrin acetate or -amyrin acetate) and caffeic acid derivatives (3, 5-dicaffoylquinic acid or 5-caffeoylquinic acid) showed feeding stimulant activity when mixed together.     

T cell-derived IL-5 production is a sensitive target of 2,3,7,8-tetrachlorodibenzo-p-dioxin (TCDD)

The immune system is one of the organs most vulnerable to the toxicity of 2,3,7,8-tetrachlorodibenzo-p-dioxin (TCDD). Among the various immunotoxic effects of TCDD, the thymus involution and suppression of IgM antibody production are well known sensitive reactions of the thymocytes and B cells affected by TCDD. Recently, we reported that TCDD greatly inhibits the production of type-2 helper T (Th2) cell-derived cytokines, especially IL-5, by the splenocytes in mice immunized with ovalbumin (OVA). In the present study, we investigated the dose-dependency of these TCDD immunotoxic effects in OVA-immunized mice to identify the most sensitive target. Mice of two age groups, 6 weeks old and 3 weeks old, were dosed with 0.3, 1.0, or 3.0 microg TCDD/kg and immunized with OVA using alum as an adjuvant. Seven days later, the thymus weight, thymocyte population, antigen-specific IgM in the plasma, and IL-5 production by the splenocytes were examined. Among them, IL-5 production was significantly suppressed by all three doses of TCDD and reduced to about 30% by even a small dose of 0.3 microg TCDD/kg in both age groups. The thymus weight was significantly reduced by 1.0 microg or 3.0 microg TCDD/kg, but IgM production was not affected by up to 3.0 microg/kg of TCDD in both age groups. Taken together, the Th2 cell-derived IL-5 production was the most sensitive endpoint detecting TCDD toxicity among those examined. Our results also suggest that effector T cells are targets more vulnerable to TCDD toxicity than thymocytes or antibody-producing B cells in the OVA-immunized mice.