活性炭性质对其吸附水中硝基苯性能的影响

通过对活性炭进行HNO3氧化及热处理改性,研究了活性炭性质对其吸附硝基苯性能的影响.以低温液氮(N2/77 K)吸附测定活性炭的比表面积和孔容、孔径分布;以Boehm滴定、零电荷点pHPZC的测定及元素分析定量表征活性发表面含氧官能团变化.结果表明:经改性后,活性炭比表面积及总孔容略有减小,表面性质发生较大变化.改性活性炭对硝基苯的吸附容量明显改变,吸附容量大小依次为:AC1′＞AC0′＞AC0＞AC1.经硝酸氧化后,比表面积下降、存在过多表面含氧官能团是导致AC1吸附硝基苯能力降低的主要原因;而AC1'表面适量酚羟基所提供的氢键吸附是其对硝基苯吸附量增加的主要原因.     

Stability analysis of alkaline nitrobenzene-containing wastewater by a catalyzed Fe-Cu treatment process

Iron and copper bimetallic system (catalyzed Fe-Cu process) is a promising technology for alkaline nitrobenzene-containing wastewater treatment. However, little is currently known about the changes of treatment efficiency with time going. This research investigated the long-term performance of the catalyzed Fe-Cu process to reduce nitrobenzene (NB) in alkaline wastewater. In addition, the changes of the metal surfaces morphologies and matters before and after the reaction were analyzed by scanning electron microscopy (SEM) in conjunction with energy-dispersion spectroscopy (EDS) and X-ray diffraction spectroscopy (XRD). The results showed that the surface properties of copper almost remained unchanged after weeks of operation, which spelled its strong chemical stability and resistance to poisoning. Moreover, the results indicated that there were two reasons for the treatment efficiency decreasing with time. One was the gradual iron element consumption due to corrosion. The other was iron reactivity weakened due to the precipitates accumulation on the surfaces that were mainly Fe₃O₄ and FeCO. __________ Translated from Environmental Pollution & Control, 2006, 28(10): 783–785 [译自: 环境污染与防治]     

电催化氧化技术处理硝基苯废水的试验研究

用实验室自制的活性炭粒子填充电极电催化氧化反应器对模拟硝基苯废水进行了降解处理。初步探讨电催化氧化反应的机理,考察了电流强度、反应时间、进水浓度等对硝基苯去除率的影响。用一元线性回归方程对不同初始浓度和电流强度降解后硝基苯的相对残余浓度对反应时间的相关性进行了分析,结果发现相关系数大于临界相关系数,硝基苯的降解符合表观一级反应动力学模型,求出了各反应条件下的一级速率常数。通过用spss软件分析,表明不同的初始浓度和电流强度下ln(C0/C)对时间的相关性显著。实验结果表明,在本实验条件下,硝基苯的去除率达到95%以上,能有效的催化降解硝基苯。     

离子膜电解法降解苯胺硝基苯废水的研究

文章采用离子膜电解法对低浓度苯胺、硝基苯废水进行处理,对影响降解效果的几种因素进行了研究。实验结果表明:在常温,电压为4V,pH值为3时,电解0.5h苯胺去除率可达98.0%,硝基苯去除率为65.3%;4.5h后苯胺去除率可达99.7%,硝基苯去除率可达90.3%,TOC去除率为91.8%。同时,离子交换膜的加入还能去除废水中的盐分,为后续生化处理提供了有利条件。     

一株硝基苯高效降解菌的筛选及其降解特性

自南京化工厂下水道底泥和废水处理系统曝气池活性污泥中驯化分离得到一株能快速降解硝基苯的菌株,初步鉴定其为不动杆菌属菌株。该菌株降解硝基苯的最适宜环境条件为温度25℃～35℃,pH7～8,振荡速率大于120r/m。在适宜环境条件下,该菌株能够在24h内全部降解初始浓度不超过400mg/L的硝基苯,该浓度范围内硝基苯的降解过程符合零级动力学特征;当硝基苯的初始浓度超过400mg/L时,降解菌的生长受到毒害作用,该浓度范围内硝基苯的降解在开始有一个明显的停滞期,降解过程不再符合零级或一级动力学特征。     

利用FeS去除水中硝基苯的试验研究

为研究FeS还原去除硝基苯的性能,采用批次试验的方法,考察了各因素对FeS去除硝基苯性能的影响.结果表明,在初始硝基苯浓度为0.96 mmol·L-1条件下,当FeS用量为1.2 g时,反应180 min后,硝基苯去除率达到90%.初始硝基苯浓度、FeS用量、温度、FeS重复使用次数对硝基苯去除率有较大影响.初始硝基苯浓度在0.74～1.74 mmol·L-1之间变化时,初始硝基苯浓度每增加0.1 mmol·L-1,硝基苯去除率下降4.7%.FeS用量在0.3～1.5 g内变化时,FeS用量每增加0.3 g,硝基苯去除率增加近20%;FeS用量为1.8 g时,硝基苯去除率为100%.温度在10～25℃范围内变化时,温度每升高1℃,硝基苯去除率增加1.6%;温度为30℃时,硝基苯去除率为100%.硝基苯去除率随FeS重复使用次数的增加而下降.转速在10～80 r.min-1内变化时,转速变化对硝基苯去除率的影响较小,硝基苯去除率稳定在75%左右.FeS对模拟化工废水有较好的处理效果,反应60 min后,硝基苯去除率为100%.     

好氧微生物在硝基苯污染河水原位修复中的应用

在好氧条件下,从长期受硝基苯污染的化工厂排污口底泥和河道底质中分离得到3株对硝基苯有明显降解作用的优势微生物.为了比较这些优势菌的降解效果,作了硝基苯初始质量浓度分别为50 mg/L、25 mg/L、12.5 mg/L、6.25 mg/L、3.13 mg/L等不同梯度下的模拟修复实验,并且检验了单一菌与混合菌的降解能力.实验结果表明:当硝基苯初始质量浓度为50 mg/L时,优势菌作用不明显,硝基苯的去除主要依靠自然挥发作用;当硝基苯初始质量浓度为3.13 mg/L时,混合菌对硝基苯的降解能力较强,72 h的去除率达到99%,而此时空白对照(CK)的去除率仅为60%.分析实验结果得到,混合菌可能存在协同作用;由于产物中未检出NO2-,所以硝基苯降解途径中可能存在部分还原历程.     

Efficient dechlorination of chlorinated solvent pollutants under UV irradiation by using the synthesized TiO2 nano-sheets in aqueous phase

Titanium dioxide(TiO2), which is the widely used photo-catalyst, has been synthesized by simple hydrothermal solution containing tetrabutyl titanate and hydrofluoric acid. The synthesized product has been applied to photo-degradation in aqueous phase of chlorinated solvents, namely tetrachloroethene(PCE), trichloroethene(TCE) and 1,1,1-trichloroethane(TCA). The photo-degradation results revealed that the degradation of these harmful chemicals was better in UV/synthesized TiO2 system compared to UV/commercial P25 system and UV only system. The photo-catalytic efficiency of the synthesized TiO2 was 1.4, 1.8 and 3.0 folds higher compared to the commercial P25 for TCA, TCE and PCE degradation, respectively. Moreover, using nitrobenzene(NB) as a probe of hydroxyl radical(.OH), the degradation rate was better over UV/synthesized TiO2, suggesting the high concentration of.OH generated in UV/synthesized TiO2system. In addition,.OH concentration was confirmed by the strong peak displayed in EPR analysis over UV/synthesized TiO2system. The characterization result using XRD and TEM showed that the synthesized TiO2 was in anatase form and consisted of well-defined sheet-shaped structures having a rectangular outline with a thickness of 4 nm, side length of 50 nm and width of 33 nm and a surface 90.3 m2/g. XPS analysis revealed that ≡Ti-F bond was formed on the surface of the synthesized TiO2. The above results on both photocatalytic activity and the surface analysis demonstrated the good applicability of the synthesized TiO2 nano-sheets for the remediation of chlorinated solvent contaminated groundwater.     

柱状污泥基活性炭制备方法及其除污染效能研究

以城市污水厂剩余污泥为原料,用氯化锌活化法研究一种柱状污泥基活性炭(CSAC)的制备方法及其工艺条件优化,并选择粉末污泥基活性炭(PSAC)和一种商品煤质碳(MAC)作为对照,考察了CSAC对重金属离子Cu(Ⅱ)和Pb(Ⅱ)及有机污染物硝基苯的吸附去除效能.结果表明,CSAC的比表面积及微孔容积分别是306.9 m2·g-1和0.109 cm3·g-1,仅为MAC的36.7%和23.6%,但其对Cu(Ⅱ)和Pb(Ⅱ)的平衡吸附量却远远高于MAC,说明CSAC表面存在的高含量酸性官能团在吸附去除重金属过程中起到了重要的作用.由于制备原料相同及制备工艺相似,CSAC与PSAC的理化性质基本相同,两种炭的表面酸性官能团含量较高,对Cu(Ⅱ)和Pb(Ⅱ)均具有较好的吸附去除效果,优于MAC,只是CSAC的比表面积和微孔容积略低于PSAC;在对硝基苯的吸附实验中,CSAC及PSAC的吸附效率均远远低于MAC,说明在对有机物硝基苯的吸附中,活性炭的比表面积等物理性质起到了较大的作用.同时,所制备的CSAC的稳定度大于95%,易于分离回收,不会造成二次污染,适合废水中重金属离子的吸附去除.     

大孔网状聚氨酯载体MBBR工艺处理低浓度硝基苯废水实验研究

利用大孔网状聚氨酯载体在MBBR工艺条件下,研究了系统挂膜与启动过程,同时利用挂膜成熟稳定的载体进行低浓度硝基苯废水处理实验。研究结果表明,在20℃条件下培养的活性污泥生长状况良好,挂膜速度快,生物膜厚度大,耐冲击负荷。在MBBR反应时间24 h、材料投加量为1/4、硝基苯初始浓度为2.095mg/L的条件下,处理低浓度硝基苯废水的效果最好,CODcr去除率为92.58%,硝基苯去除率为49.82%。