Preparation of rare-earth metal complex oxide catalysts for catalytic wet air oxidation

Catalytic wet air oxidation (CWAO) is one of the most promising technologies for pollution abatement. Developing catalysts with high activity and stability is crucial for the application of the CWAO process. The Mn/Ce complex oxide catalysts for CWAO of high concentration phenol-containing wastewater were prepared by coprecipitation. The catalyst preparation conditions were optimized by using an orthogonal layout method and single-factor experimental analysis. The Mn/Ce serial catalysts were characterized by Brunauer-Emmett-Teller (BET) analysis and the metal cation leaching was measured by inductively coupled plasma torch-atomic emission spectrometry (ICP-AES). The results show that the catalysts have high catalytic activities even at a low temperature (80°C) and low oxygen partial pressure (0.5 MPa) in a batch reactor. The metallic ion leaching is comparatively low (Mn<6.577 mg/L and Ce<0.6910 mg/L, respectively) in the CWAO process. The phenol, COD_Cr, and TOC removal efficiencies in the solution exceed 98.5% using the optimal catalyst (named CSP). The new catalyst would have a promising application in CWAO treatment of high concentration organic wastewater. Translated from Techniques and Equipment for Environmental Pollution Control, 2005, 6(2): 40–44 [译自: 环境污染治理技术与设备]     

含酚废水治理方法的研究

根据含酚废水的性质，用ClO2氧化除酚，ZL—1和聚丙烯酰胺(PAM)混凝沉降除悬浮物的方法处理该废水。实验结果表明，经处理后废水中的主要污染物酚、焦油和悬浮物等去除率都很高，该水可以满足循环使用的要求。     

热带假丝酵母8953菌株对苯酚的降解特性研究

实验室分离的一株热带假丝酵母(编号为8953)具有较强的苯酚降解能力,并可以利用苯酚、间苯二酚、联苯胺等芳烃为唯一碳源和能源生长。该菌株在48h内可完全降解约14.88mmol/L苯酚,完全降解10.63mmol/L苯酚只需要24h,其降解苯酚浓度最高可达19.13mmol/L。在pH4～9,温度20℃～40℃范围内,苯酚浓度为10.0mmol/L条件下该菌株均保持100%的降解率。该菌株降解苯酚的最适pH范围为6.0～8.0,最适温度范围为28℃～30℃,最佳接种量为1%～3%,外源添加氮源能促进酵母生长和苯酚的降解。     

催化裂化废水连续萃取脱酚研究

选用焦化粗柴油为萃取剂，在转盘萃取搭连续试验装置中，对催化裂化含酚废水进行脱酚预处理。结果表明，用焦化粗柴油做萃取剂，进水ｐＨ值为８０～９０不加调节；油水比（体积比）１７∶１～２１∶１；转盘转数１１００ｒ／ｍｉｎ，酚萃取脱除率达到８５％以上。萃取后的粗柴油依据现有工艺而进行加氢精制，不需进行再生等后处理。整个萃取工艺简单易行，能满足预处理的要求     

锰砂表面改性去除酚类化合物的研究

本文叙述了锰砂表面改性(以下简称旧锰砂)处理含酚饮用水的实验研究,陈酚率可达99％。本实验对除酚因素(温度、pH值、流速和接触时间等)进行了实验研究。当进水酚浓度≤2.0mg/l时,经旧锰砂的吸附,可使酚浓度≤0.002mg/l。     

Possible Utilization of Silica Gel Sludge for the Removal of Phenol from Aqueous Solutions: Laboratory Studies

This paper discusses the adsorption capacity of silica gel sludge for phenol removal from aqueous solution. Kinetic experiments showed that phenol adsorption was completed after 2 h. Adsorption isotherms were measured for phenol from aqueous solution onto silica gel sludge under various pHs and temperatures. Results showed that the adsorption capacities for phenol was increased as pH decreased from 6.5 to 2. Temperature also was found to affect the adsorption isotherm. As temperature increases from 30 to 50°C, the adsorption capacity increases. The adsorption equilibrium of phenol on silica gel sludge was described by the linear Freundlich and Langmuir models. Furthermore, results showed that the isotherm parameters fit both linearized Langmuir and Freundlich adsorption isotherms. The Freundlich and Langmuir parameters at optimum pH was found as K _f=2.89, 1/n=0.23 and K _d=22.0, q _m=7.98, respectively. Whereas, for those at optimum temperature it was observed as K _f=2.87, 1/n=0.16 and K _d=20.93, q _m=7.91, respectively.     

酚降解菌株的分离、鉴定和在含酚废水生物处理中的应用

从石油化工厂的活性污泥和废水混合物中分离到10个降解酚的细菌菌株,经16S rRNA基因序列分析,5个菌株(PD1、PD2、PD6、PD7和PD39)被鉴定为假单胞菌(Pseudomonas sp.),4个菌株(PD4、PD5、PD8和PD9)为不动杆菌(Acinetobacter sp.),1个菌株(PD3)为丛毛单胞菌(Comamonas sp.).对假单胞菌(Pseudomonas sp.)PD39菌株的酚降解特性、最适生长条件、降解底物的范围、儿茶酚1,2-双加氧酶(C12O)和儿茶酚2,3-双加氧酶(C23O)活性、含酚废水的生物处理等,进行了详细研究.结果表明,PD39菌株的最适生长和降解条件是,培养基的起始pH为7.0,培养温度为30℃,酚浓度为800 mg/L,对酚的最大降解浓度为1 200 mg/L.酚浓度为637 mg/L的工业废水经72 h处理酚的去除率达到99.96%.PD39菌株有很好的应用潜力来作含酚废水活性污泥处理系统的强化菌株.     

萃取膜生物反应器处理苯酚废水的试验研究

从经过驯化的活性污泥中筛选出苯酚降解菌.制备成菌悬液,对比活性污泥体系和菌悬液体系的萃取膜生物反应器(EMB)对苯酚废水的处理效果,考察了料液苯酚浓度、反应器温度等因素对膜萃取速率及生物降解效果的影响.结果表明,通过以苯酚为唯一碳源,逐渐提高苯酚浓度的方法对活性污泥进行驯化.当进水苯酚浓度为700 mg·L-1时,苯酚去除率达99%以上;适当提高反应器温度和料液初始浓度有利于提高膜萃取速率;当初始料液苯酚浓度为2000 mg·L-1时,膜萃取速率高于生物降解速率,生物相中产生苯酚积累;菌悬液体系EMB的生物膜厚度明显小于活性污泥体系,且水力反冲洗可有效控制生物膜厚度.对苯酚生物降解产物的GC-MS分析结果表明,苯酚的生物降解较彻底,基本无苯酚中间产物的残留.     

Enhanced electrochemical oxidation of phenol by introducing ferric ions and UV radiation

The mineralization of phenol in aerated electrochemical oxidation has been investigated.The results show that a cathodic Fenton process can occur when the Ti-0.3Mo-0.8Ni alloy material is used as cathode in solution containing ferric or ferrous ions; moreover,the reinforcement of cathodic Fenton process on the total organic carbon (TOC) removal rate of phenol is quite distinct.Among the metallic ions investigated,the ferric ion is the best catalyst for the electrochemical mineralization of phenol at initial...