TVS／TFS去除率在ATAD污泥稳定评价的应用

在ATAD(Autothermal Thermophilic Aerobic Digestion,自升温高温好氧消化)工艺污泥稳定评价中引入TFS．提出“TVS/ TFS去除率”的概念,得出“TVS/TFS去除率”可以代替“VS(g)去除率”而成为一种新的污泥稳定指标的结论;采用数学微分的方法分析了“TVS/TFS去除率”和“VS(g)去除率”的数据误差问题,进泥TS为60g/L,TVS/TS为56％的运行条件下,前者的最大数据误差仅为3．16％,远小于后者的误差最大值15．45％,即引入TFS解决了“VS(g)去除率”数据波动大的问题;TFS的引入还节约了污泥稳定研究所需的时间和工作量。     

Environmental assessment of garden waste management in the Municipality of Aarhus, Denmark

An environmental assessment of six scenarios for handling of garden waste in the Municipality of Aarhus (Denmark) was performed from a life cycle perspective by means of the LCA-model EASEWASTE. In the first (baseline) scenario, the current garden waste management system based on windrow composting was assessed, while in the other five scenarios alternative solutions including incineration and home composting of fractions of the garden waste were evaluated. The environmental profile (normalised to Person Equivalent, PE) of the current garden waste management in Aarhus is in the order of −6 to 8 mPE Mg⁻¹ ww for the non-toxic categories and up to 100 mPE Mg⁻¹ ww for the toxic categories. The potential impacts on non-toxic categories are much smaller than what is found for other fractions of municipal solid waste. Incineration (up to 35% of the garden waste) and home composting (up to 18% of the garden waste) seem from an environmental point of view suitable for diverting waste away from the composting facility in order to increase its capacity. In particular the incineration of woody parts of the garden waste improved the environmental profile of the garden waste management significantly.     

基于VS的有机固体废物厌氧消化的趋势分析

在表示有机固废厌氧消化进程的三个指标(COD、TS、VS)中,VS是有代表性的指标。VS在整个厌氧消化过程中呈下降的趋势,同时,VS的变化是连续的,由此,可以用一元多项式和指数函数模型来预测有机固废厌氧消化过程中VS的变化。通过研制的混合式厌氧发酵自动控制实验装置(简称为MADACE)验证了两模型的可行性,其相关系数均达到了0.98以上。     

应用Modified Gompertz模型对城市生活垃圾沼气发酵的拟合研究

尽管Modified Gompertz模型与料菌比和发酵浓度之间没有直接的函数和变量关系,但是料菌比和浓度的变化必然导致Modified Gompertz模型参数的改变,因此可以通过Modified Gompertz模型参数的变化特征对料菌比和发酵浓度是否适宜作出合理的评价.据此本研究将采用中温批量发酵,分别设计单因素...     

Effects of bulking agent addition on odorous compounds emissions during composting of OFMSW

The effects of rice straw addition level on odorous compounds emissions in a pilot-scale organic fraction of municipal solid waste (OFMSW) composting plant were investigated. The cumulative odorous compounds emissions occurred in a descending order of 40.22, 28.71 and 27.83 mg/dry kg of OFMSW for piles with rice straw addition level at ratio of 1:10, 2:10 and 3:10 (mixing ratio of rice straw to OFMSW on a wet basis), respectively. The mixing ratio of rice straw to OFMSW had a statistically significant effect on the reduction of malodorous sulfur compounds emissions, which had no statistically significant effect on the reduction of VFAs, alcohols, aldehydes, ketones, aromatics and ammonia emissions during composting, respectively. The cumulative emissions of malodorous sulfur compounds from piles with the increasing rice straw addition level were 1.17, 1.08 and 0.88 mg/dry kg of OFMSW, respectively. The optimal mixing ratio of rice straw to OFMSW was 1:5. Using this addition level, the cumulative malodorous sulfur compounds emissions based on the organic matter degradation were the lowest during composting of OFMSW.     

Anaerobic digestion of chicken feather with swine manure or slaughterhouse sludge for biogas production

Biogas production from anaerobic digestion of chicken feathers with swine manure or slaughterhouse sludge was assessed in two separate experiments. Ground feathers without any pre-treatment were added to 42-L digesters inoculated with swine manure or slaughterhouse sludge, representing 37% and 23% of total solids, respectively and incubated at 25 °C in batch mode. Compared to the control without feather addition, total CH₄ production increased by 130% (P < 0.001) and 110% (P = 0.09) in the swine manure and the slaughterhouse sludge digesters, respectively. Mixed liquor NH₄N concentration increased (P < 0.001) from 4.8 and 3.1 g/L at the beginning of the digestion to 6.9 and 3.5 g/L at the end of digestion in the swine manure and the slaughterhouse sludge digesters, respectively. The fraction of proteolytic microorganisms increased (P < 0.001) during the digestion from 12.5% to 14.5% and 11.3% to 13.0% in the swine manure and the slaughterhouse sludge digesters with feather addition, respectively, but decreased in the controls. These results are reflective of feather digestion. Feather addition did not affect CH₄ yields of the swine manure digesters (P = 0.082) and the slaughterhouse sludge digesters (P = 0.21), indicating that feathers can be digested together with swine manure or slaughterhouse sludge without negatively affecting the digestion of swine manure and slaughterhouse sludge.     

Parameters affecting the stability of the digestate from a two-stage anaerobic process treating the organic fraction of municipal solid waste

This paper focused on the factors affecting the respiration rate of the digestate taken from a continuous anaerobic two-stage process treating the organic fraction of municipal solid waste (OFMSW). The process involved a hydrolytic reactor (HR) that produced a leachate fed to a submerged anaerobic membrane bioreactor (SAMBR). It was found that a volatile solids (VS) removal in the range 40-75% and an operating temperature in the HR between 21 and 35 °C resulted in digestates with similar respiration rates, with all digestates requiring 17 days of aeration before satisfying the British Standard Institution stability threshold of 16 mg CO₂ g VS⁻¹ day⁻¹. Sanitization of the digestate at 65 °C for 7 days allowed a mature digestate to be obtained. At 4 g VS L⁻¹ d⁻¹ and Solid Retention Times (SRT) greater than 70 days, all the digestates emitted CO₂ at a rate lower than 25 mg CO₂ g VS⁻¹ d⁻¹ after 3 days of aeration, while at SRT lower than 20 days all the digestates displayed a respiration rate greater than 25 mg CO₂ g VS⁻¹ d⁻¹. The compliance criteria for Class I digestate set by the European Commission (EC) and British Standard Institution (BSI) could not be met because of nickel and chromium contamination, which was probably due to attrition of the stainless steel stirrer in the HR.     

Distributed generation by energy from waste technology: A life cycle perspective

Municipal Solid Waste in general and its organic fraction in particular is a potential renewable and non-seasonal resource. In this work, a life cycle assessment has been performed to evaluate the environmental impacts of two future scenarios using biogas produced from the organic fraction of municipal solid waste (OFMSW) to supply energy to a group of dwellings, respectively comprising distributed generation using solid oxide fuel cell (SOFC) micro-CHP systems and condensing boilers. The London Borough of Greenwich is taken as the reference case study. The system is designed to assess how much energy demand can be met and what is the best way to use the digestible waste for distributed energy purposes.The system is compared with two alternative scenarios fuelled by natural gas: a reference scenario, where the electricity is supplied by the grid and the heat is supplied from condensing boilers, and a fuel cell micro-CHP system. The results show that, although OFMSW alone can only supply between 1% and 4% of the total energy demand of the Borough, a saving of ∼130 tonnes of CO₂ eq per year per dwelling equipped with micro-CHP is still achievable compared with the reference scenario. This is primarily due to the surplus electricity produced by the fuel cell when the micro-CHP unit is operated to meet the heat demand. Use of biogas to produce heat only is therefore a less desirable option compared with combined heat and power production. Further investigation is required to identify locally available feedstock other than OFMSW in order to increase the proportion of energy demand that can be met in this way.     

多元混合物料协同促进厌氧消化产甲烷性能试验研究

为评估农牧废弃物多元物料混合厌氧发酵对产甲烷性能的协同促进作用,研究了中温（37±1）℃和固体质量分数为12%时,牛粪、蔬菜废弃物和玉米秸秆混合原料的厌氧消化产甲烷性能,最后应用修正的Gompertz方程分析甲烷生产的动力学过程.结果表明：3种物料混合厌氧发酵发生了明显的协同促进作用,协同效应作用值为34.85%~70.39%,贡献效果显著（P<0.05）;当牛粪、蔬菜废弃物和玉米秸秆VS混合比例为50：20：30时,甲烷产率、累计甲烷产量和VS降解率达到最大值,分别为286.0mL/g VS、20713mL和65.6%,比单一牛粪、蔬菜废弃物以及玉米秸秆厌氧消化甲烷产量分别提高了32.9%、229.9%和82.0%.修正的Gompertz方程能较好反映物料厌氧消化产甲烷过程,拟合结果的R²均大于0.99,牛粪、蔬菜废弃物和玉米秸秆VS比例为50：20：30时具有最大产甲烷速率17.34mL/（d×g）和较短的迟滞时间2.97d.该研究结果可为农牧废弃物多元混合物料厌氧消化产沼气工程提供参考.     

Long-term thermophilic mono-digestion of rendering wastes and co-digestion with potato pulp

In this study, mono-digestion of rendering wastes and co-digestion of rendering wastes with potato pulp were studied for the first time in continuous stirred tank reactor (CSTR) experiments at 55 °C. Rendering wastes have high protein and lipid contents and are considered good substrates for methane production. However, accumulation of digestion intermediate products viz., volatile fatty acids (VFAs), long chain fatty acids (LCFAs) and ammonia nitrogen (NH₄-N and/or free NH₃) can cause process imbalance during the digestion. Mono-digestion of rendering wastes at an organic loading rate (OLR) of 1.5 kg volatile solids (VS)/m³ d and hydraulic retention time (HRT) of 50 d was unstable and resulted in methane yields of 450 dm³/kg VS_fed. On the other hand, co-digestion of rendering wastes with potato pulp (60% wet weight, WW) at the same OLR and HRT improved the process stability and increased methane yields (500–680 dm³/kg VS_fed). Thus, it can be concluded that co-digestion of rendering wastes with potato pulp could improve the process stability and methane yields from these difficult to treat industrial waste materials.