上流式多级处理厌氧反应器（UMAR）处理棉浆黑液

棉浆黑液是高浓度有机废水,有较好的厌氧可生化性。利用上流式多级处理厌氧反应器处理棉浆黑液,容积负荷在14．4—24kg／（m^3·d）之间,平均COD去除率可达到80％,同时可产生沼气,具有很好的应用前景。     

SBR法处理低C/N污水的工程应用——以某基地污水处理站改造工程为例

低C/N污水的生化处理过程中,由于碳源不足,不能满足硝化和反硝化的要求,造成出水NH3-N超标。采用SBR工艺对某基地污水处理站厌氧处理后的低C/N污水进行改造,处理后出水COD去除率达到97%以上,NH3-N去除率达到93%以上。     

SBR处理铁路洗涤废水试验研究

铁路洗涤废水中含有的主要污染物直链烷基苯磺酸钠(LAS)是我国环境标准中第2类污染物质.目前,铁路洗涤废水的处理以物理和化学法为主,存在效果不稳定、成本较高和工艺复杂等问题,急需寻求一种适合铁路洗涤废水特点的处理工艺.用SBR小试装置进行铁路洗涤废水处理实验研究,并且投加LAS降解菌于SBR中,进行了工艺参数的确定,处理效果考察和投菌前后对比等方面的初步研究.     

Misoperation monitoring and early warning during startup and shutdown of petrochemical units

Most petrochemical units run under extreme conditions, such as high temperatures, pressures, and speeds. Consequently, the equipment operators may commit errors because the startup and shutdown processes usually involve complicated operation steps; moreover, the operators may lack experience in handling abnormal situations. Misoperation can lead to accidents, including fires and explosions. Thus, risk analysis for process operations and the development of preventive measures have become an effective means of avoiding misoperation-related accidents. However, it is challenging to ensure the comprehensiveness of risk-analysis results. In this paper, we present a method for misoperation monitoring and early warning in the startup and shutdown processes of petrochemical units. The mechanisms of misoperation occurrence are summarized based on investigations of serious accidents in the recent past. Knowledge regarding the mechanisms of misoperation is crucial for the risk analysis of petrochemical units. The potential risk information, such as causes, adverse consequences, key monitoring parameters, and prevention control solutions, should be acquired and be employed to construct an early-warning knowledge database. Furthermore, misoperation judgment rules need to be formulated to identify misoperations. The data obtained from the monitoring module, misoperation judgment rules, and analysis results can aid in developing schemes to avoid possible abnormal situations. This paper reports a misoperation monitoring and early-warning system for a hydrogenation unit. As demonstrated, conducting risk analysis to determine the potential operational risks and formulating misoperation judgment rules to analyze the process data are essential for enabling early warning. The application of this method will contribute to operational guidance, economic loss reduction, and accident avoidance.     

乙醛废水处理工程实例

某化工厂以酒精氧化法制得乙醛,该厂原有一套污水处理设施,但系统出水难以达标。经改造后,该废水经过冷却到35～39℃、加碱中和至pH值为7左右,进入内循环厌氧反应器(MIC)处理,在厌氧进水为ρ(CODCr)约3200mg·L-1,HRT为24h时,CODCr去除率为94%,出水进入推流式好氧池,采用微孔曝气器曝气,HRT为36h,好氧出水ρ(CODCr)<100mg·L-1。     

ABR反应器处理高浓度头孢抗生素废水实验研究

抗生素类制药废水的有机污染物浓度高,可生化性差,微生物不易降解,处理难度很大。采用动态试验对厌氧折流板反应器（ABR）处理某头孢类制药厂废水进行了研究。结果表明,当进水CODCr负荷控制在2．67—3．0kg／（m^3·d）,温度控制在35．4-0．5℃时,ABR对该废水CODCr的去除率可达在50％,且其可生化性得到了有效的提高,促进了废水进一步后续生化处理的运行稳定性。     

PTA生产废水处理装置的开工及问题探讨

阐述了乌石化ＰＴＡ废水两段好氧处理系统的原理和启动运行过程，并对运行中发现的问题提出了解决方案     

煤矸石制非烧结砖的可行性研究

从实验室试验和工业性试验出发， 煤矸石制非烧结砖的可行性。研究结果表明，用煤矸石和适量固化剂制成的非绕结砖经过２８ｄ自然养护后，其质量和放射性均符合国家有关标准。利用煤矸石非烧砖无 技术上还是经济上都是可行和有利的。     

Performance and mechanism of Cr(VI) removal by zero-valent iron loaded onto expanded graphite

Zero-valent iron (ZVI) was loaded on expanded graphite (EG) to produce a composite material (EG-ZVI) for efficient removal of hexavalent chromium (Cr(VI)). EG and EG-ZVI were characterized by X-ray diffraction (XRD), scanning electron microscopy (SEM), Fourier-transform infrared (FTIR) spectroscopy and Brunauer–Emmett–Teller (BET) analysis. EG-ZVI had a high specific surface area and contained sub-micron sized particles of zero-valent iron. Batch experiments were employed to evaluate the Cr(VI) removal performance. The results showed that the Cr(VI) removal rate was 98.80% for EG-ZVI, which was higher than that for both EG (10.00%) and ZVI (29.80%). Furthermore, the removal rate of Cr(VI) by EG-ZVI showed little dependence on solution pH within a pH range of 1–9. Even at pH 11, a Cr(VI) removal rate of 62.44% was obtained after reaction for 1 hr. EG-ZVI could enhance the removal of Cr(VI) via chemical reduction and physical adsorption, respectively. X-ray photoelectron spectroscopy (XPS) was used to analyze the mechanisms of Cr(VI) removal, which indicated that the ZVI loaded on the surface was oxidized, and the removed Cr(VI) was immobilized via the formation of Cr(III) hydroxide and Cr(III)–Fe(III) hydroxide/oxyhydroxide on the surface of EG-ZVI.     

反硝化聚磷一体化设备生产性实验研究

反硝化聚磷一体化设备主要特点是在利用含反硝化聚磷菌的活性污泥在缺氧状态过量聚磷，在完成磷去除的同时进行反硝化。通过实验得出缺氧释磷在前30min内大量释放，60min以后甚微；反硝化吸磷在最初10几分钟内速率极大；吸磷与反硝化紧密相关；聚磷菌在释、聚磷时利用一定量的有机物。