Removal and desorption of chromium in synthetic effluent by a mixed culture in a bioreactor with a magnetic field

Two chromium removal experiments were performed in bioreactors with and without a magnetic field under the same conditions.The release of the chromium present in the biomass was tested in two experiments one with the initial pH of the medium and one with pH 4.0.The objective was to remove Cr(Ⅵ) and total Cr from the effluent,this was carried out by placing biological treatments of synthetic effluent contaminated with 100 mg/L of Cr(Ⅵ) in a bioreactor with neodymium magnets that applied a magnetic field(intensity85.4 mT) to the mixed culture.The removal of Cr(Ⅵ) was approximately 100.0% for the bioreactor with a magnetic field and 93,3% for the bioreactor without a magnetic field for9 hr of recirculation of the synthetic effluent by the bioreactor.The removal of total Cr was61.6% and 48.4%,with and without a magnetic field,respectively;for 24 hr.The desorption of Cr(VI) in the synthetic effluent was 0.05 mg/L,which is below the limit established by Brazilian legislation(0.1 mg/L) for the discharge of effluent containing Cr(Ⅵ) into bodies of water.The results obtained for the removal of chromium in synthetic effluent suggested that there was no significant influence on the viable cell count of the mixed culture.The desorption of Cr(Ⅵ) in synthetic effluent after bioadsorption of chromium by the mixed culture in the process of removal of chromium in bioreactors with and without a magnetic field was not significant in either of the experiments with different initial pHs.     

炼油污水气浮絮凝处理中试

气浮絮凝是炼油污水处理工艺中重要的一步 ,它是确保炼油污水生化处理顺利运行的关键 ,而开发和筛选优良的絮凝剂则又是提高气浮处理效果的保证。采用无机—有机复合絮凝剂进行炼油污水的中试试验 ,通过一系列条件试验 ,确定了复合絮凝剂投药剂量、投药间隔时间和投药方式 ,取得了令人满意的试验效果 ,CODCr的去除率 5 5 % ,石油类去除率 >75 % ,为后续的生化处理提供了合格的水质     

影响微生物絮凝剂产生的因素研究

本文通过改变培养基的种类、培养基的碳源、氮源、无机盐离子来选择絮凝剂产生菌“Dfjm-1”高效低廉的培养基 ;通过改变培养基初始 p H值、培养温度、培养过程中的通气量等因素 ,得出“Dfjm-1”菌株产生絮凝剂的最佳条件。Dfjm-1产生絮凝剂的最佳因素为 :培养基初始 p H值为 6.5～ 7.0 ,培养温度为 3 0℃ ,培养时间为 60小时左右 ,通气量为 :早期 :2 50 r/ min;中期 1 50 r/ min;后期 1 0 0～ 1 50 r/ min     

草履虫──针杆藻群落对混合印染废水净化作用的条件实验

本文对混合印染废水的静态净化过程，进行了生物群落观察和条件实验。发现废水净化初期以大量细菌和草履虫（以 Ｐ． Ｃａｕｄａｔｕｍ为主）繁殖为特征，同时伴生着少量浮游藻类。随着净化过程的进行，细菌和草履虫数量下降，以针杆藻（以 Ｓ． ａｕｃｓ为主）为建群种的浮游藻类群落占优势。化学分析表明，净化作用与温度、光照条件及废水起始浓度有关。     

阳离子絮凝剂研制

介绍了一种阳离子絮凝剂的研制情况。用该絮凝剂对几种污水进行混凝处理，加药后生成的絮体大，沉降速度快，处理后水清澈度高。同时，用日立Ｈ－３００扫描电镜对絮体形态进行了观察，对阳离子絮凝剂的作用机理进行了初步探讨。     

利用XPS研究复合氧化物催化剂在汽车尾气净化中硫中毒及抗硫中毒机理

运用ＸＰＳ分析方法研究一系列复合氧化物催化剂中毒前后硫在其表面的各种形态及催化剂活性组分中毒前后的组成，价态，化学机理及其变化。结果表明，ＳＯ２在催化剂活性中心进行化学吸附，然后一部分ＳＯ２与活性组分生成相应的亚硫酸盐和硫酸盐，从而使催化剂失活。     

稠油污水处理系统改造与絮凝剂筛选试验研究

河南油田井楼稠油联合站含油污水中的污油和悬浮物含量较高,超过150mg/L。为此,对该处理系统进行了改造,并对絮凝剂的筛选进行了试验。结果表明:无机絮凝剂与有机絮凝剂联合作用,可对污水中所含有的污油和有机物杂质的悬浮物产生很好的絮凝沉降效果。加药浓度、加药顺序及沉降时间均对絮凝沉降效果有一定的影响。改造后的污水处理系统实现了污水达标回注,降低了无效回注费用。同时还回收了污油,降低了药剂成本,产生了十分明显的经济效益,每年节约成本约500万元。     

炼化废水絮凝剂筛选实验

中国石油大连石化公司的生产废水不仅具有炼化废水的复杂性,而且其中含有大量的氯离子,给絮凝药剂的筛选带来一定的困难。通过对715、728两种絮凝药剂的现场应用实验,找出了不同水质情况下的最佳投药量。实验结果表明,当污水中含油量大于100mg/L时,715药剂加入量控制在150～180mg/L,728的加入量为4mg/L,此时油、SS、COD、浊度的去除率分别为92%、41%、41%和82%。当污水含油量在30mg/L以下时,715药剂加入量为90～120mg/L,728加入量为2.7～3.3mg/L,此时油、SS、COD、浊度的去除率分别为74%、71%、38%和89%。经实验筛选出的这两种药剂可以利用现有的加药系统设备加入污水,加药处理后能提高出水的水质。     

不同絮凝剂对活性污泥特性及除污效能的影响研究

为了研究絮凝剂对污泥特性及除污效能的作用结果,考察了SBR反应器中投加聚合氯化铝(PAC)、聚合硫酸铁(PFS)和阳离子聚丙烯酰胺(CPAM)对污泥特性及COD、NH_4~+-N和TP去除效果的影响。结果表明:投加10 mg/L PAC会导致活性污泥沉降性能变差,降低了微生物对污染物质的分解能力;投加0.1 mg/L CPAM和10 mg/L PFS能够改善活性污泥菌胶团和絮体结构,使得活性污泥的吸附效能和沉降性增强。     

Effects of sludge retention time, carbon and initial biomass concentrations on selection process: From activated sludge to polyhydroxyalkanoate accumulating cultures

Four sequence batch reactors (SBRs) fed by fermented sugar cane wastewater were continuously operated under the aerobic dynamic feeding (ADF) mode with different configurations of sludge retention time (SRT), carbon and initial biomass concentrations to enrich polyhydroxyalkanoate (PHA) accumulating mixed microbial cultures (MMCs) from municipal activated sludge. The stability of SBRs was investigated besides the enrichment performance. The microbial community structures of the enriched MMCs were analyzed using terminal restriction fragment length polymorphism (T-RFLP). The optimum operating conditions for the enrichment process were: SRT of 5 days, carbon concentration of 2.52 g COD/L and initial biomass concentration of 3.65 g/L. The best enrichment performance in terms of both operating stability and PHA storage ability of enriched cultures (with the maximum PHA content and PHA storage yield (Y_PHA/S) of 61.26% and 0.68 mg COD/mg COD, respectively) was achieved under this condition. Effects of the SRT, carbon concentration and initial biomass concentration on the PHA accumulating MMCs selection process were discussed respectively. A new model including the segmentation of the enrichment process and the effects of SRT on each phase was proposed.