兼性生化处理生活污水最佳工况研究

在常温条件下进行兼性生化处理生活污水试验,研究COD去除率与HRT、MLSS、进水有机物浓度和混合液水温的关系。在试验中最佳的水平搭配为MLSS=5500mg/L,进水有机物浓度=180mg/L,HRT=8h和混合液水温=20℃,与回归分析所得出MLSS=5881mg/L,进水有机物浓度=192.7mg/L,HRT=8.9063h和混合液水温=21.3790℃的最佳工艺条件相吻合。最后通过等高线分析得出常温下生活污水兼性生化的适宜范围。     

序批式反应器的水力停留时间的理论探讨

根据液龄分布函数是二元函数的观点．推导出了当进、出水流量是时间的函数时，反应器的水力停留时间的通用积分式和离散式；然后得出了序批式反应器(SBR）的水力停留时间(HRT)具体表达式，并分析了用现有方法计算其水力停留时间所产生的误差．结果表明，最大相对误差rmax仅与充水比λ有关．且呈正相关关系．取典型值λ=0．4时，rmax高达25％。     

New process for anaerobic treatment of Vitamin C wastewater in a full scale plant

１ＩｎｔｒｏｄｕｃｔｉｏｎＴｈｅＦｉｒｓｔＰｈａｒｍａｃｅｕｔｉｃａｌＦａｃｔｏｒｙｉｎＳｈｉｊｉａｚｈｕａｎｇＣｉｔｙ，Ｃｈｉｎａ，ｂｕｉｌｔａｓｅｔｏｆｅｑｕｉｐｍｅｎｔｏｆｆｕｌｓｃａｌｅｔｒｅａｔｉｎｇＶｉｔａｍｉｎＣｗａｓｔｅｗａｔｅｒｉｎ...     

一种新型复合式生物流化反应器混合特性的研究

对新型蜂窝状断面复合生物流化反应器进行了液体循环速率和水力停留时间分布曲线的测定，实验表明新型反应器具有抗冲击负荷强，接近CSTR反应器的特点，反应器随气量增大、载体投加量减少和进水量减少而更近似于CSTR反应器，通过理论分析，证明了影响液体循环速率的参数主要有气体流量(气含率)、反应器沿程和局部阻力系数以及Ad/Ar，并且得出液体循环速率与反应器高度的0．5次方成正比。     

Determination and discussion hydraulic retention time in membrane bioreactor system

Based on the microorganism kinetic model, the formula for computing hydraulic retention time in a membrane bioreactor system (MBR) is derived. With considering HRT as an evaluation index a combinational approach was used to discuss factors which have an effect on MBR. As a result, the influencing factors were listed in order from strength to weakness as: maximum specific removal rate K, saturation constant Ks, maintenance coefficient m, maximum specific growth rate ,ua and observed yield coefficient Yobs. Moreover, the formula was simplified, whose parameters were experimentally determined in petrochemical wastewater treatment. The simplified formula is θ= 1.1( 1/β -1)(Kｓ S)/KXo , for oetroehemical wastewater treatment K and Ko eaualed 0.185 and 154.2, resoectively.     

流体动力系统噪声控制研究

以泵为例分析了液压动力系统中噪声产生的机理和危害，结合多年来的生产经验，给出降低和控制液压动力系统噪声的思路和几种基本方法。     

An investigation on the fuel savings potential of hybrid hydraulic refuse collection vehicles

Refuse trucks play an important role in the waste collection process. Due to their typical driving cycle, these vehicles are characterized by large fuel consumption, which strongly affects the overall waste disposal costs. Hybrid hydraulic refuse vehicles offer an interesting alternative to conventional diesel trucks, because they are able to recuperate, store and reuse braking energy. However, the expected fuel savings can vary strongly depending on the driving cycle and the operational mode. Therefore, in order to assess the possible fuel savings, a typical driving cycle was measured in a conventional vehicle run by the waste authority of the City of Stuttgart, and a dynamical model of the considered vehicle was built up. Based on the measured driving cycle and the vehicle model including the hybrid powertrain components, simulations for both the conventional and the hybrid vehicle were performed. Fuel consumption results that indicate savings of about 20% are presented and analyzed in order to evaluate the benefit of hybrid hydraulic vehicles used for refuse collection.     

流体剪切与超声空化破解剩余污泥的参数优化

为提高剩余污泥的破解效果并降低能耗,采用FS（fluid shear,流体剪切）、UC（ultrasonic cavitation,超声空化）、FS和UC联合工艺（FS-UC,UC-FS）破解剩余污泥,并应用单因素试验结合响应面法对联合工艺进行优化.结果表明:FS对剩余污泥破解效果一般,只在开始阶段具有较好效果,随作用时间延长,破解效果未有显著提高甚至下降.UC对剩余污泥破解效果明显,随作用时间延长,破解效果显著提升,但能耗也随之增大,EDR（energy disintegration ratio,效能比）明显下降.相同作用时间下,UC破解效果优于FS破解效果,UC破解剩余污泥的DD_COD（degree of disintegration,破解率）与EDR均明显高于FS方法.单因素试验得出的较优FS作用时间范围为2~8 min,较优UC作用时间范围为5~15 min.响应面法试验结果显示,联合工艺的剩余污泥破解效果和能量利用率均优于单一方法,联合工艺中FS-UC工艺的破解效果优于UC-FS工艺.FS-UC工艺的最佳参数:FS处理5.6 min再UC处理15.0 min,该条件下剩余污泥实际DD_COD为50.8%,EDR为26.8%.UC-FS工艺的最佳参数:先UC作用15.0 min再FS作用7.8 min,该条件下剩余污泥实际DD_COD为36.5%,EDR为17.1%.研究显示,以DD_COD和EDR为指标,4种工艺的高效性顺序为FS-UC > UC-FS > UC > FS,其中FS-UC工艺具有能耗低、破解效率高的特点,是4种工艺中剩余污泥破解效果最好的一种工艺.      

生态高负荷土地快速渗滤系统处理猪场废水的效能及微生态

以经过厌氧反应器处理后的猪场废水为研究对象,探讨了新型生态高负荷土地快速渗滤系统对废水中COD、氨氮及总氮的去除情况;同时分析了该系统中的微生物群落结构以及过氧化氢酶、脲酶、硝酸盐还原酶的含量.结果表明,在水力负荷为11 cm·d~(-1)、进水COD为700 mg·L~(-1)左右的条件下,一级土地渗滤柱与二级土地渗滤柱对COD的去除率分别为78.8%与63.0%,总去除率达到了92.6%;而当水力负荷增大到22 cm·d~(-1)时,总的COD去除率仍在90.0%以上;该系统对于氨氮的去除更为显著,去除率可达99%左右.一级土地快速渗滤系统中上、中、下部的过氧化氢酶含量分别为1.899、0.990、0.323 m L·g~(-1),表明猪场废水中的有机物主要在该系统的上部与中部得以去除;二级土地快速渗滤系统上、中、下部的硝酸盐还原酶含量分别是3.453、3.831、1.971 m L·g~(-1),表明脱氮作用主要发生二级土地快速渗滤系统的上部与中部.该土地快速渗滤系统中微生物以Gram Negative与Gram Positive为主,特别是在二级土地快速渗滤系统中,AM Fungi与Actinomycetes占有一定比例,为猪场废水中难降解有机物的去除提供了保障.     

海水生物滤器氨氮沿程转化规律模型

生物滤器是海水循环水养殖系统中的核心水处理单元,其主要用于去除对养殖生物有害的氨氮、有机物等.本研究基于吸附原理和一级反应生物膜理论构建了氨氮在生物滤器中沿程转化规律的数学模型,并通过实验加以验证.实验所用生物滤器采用竹制空心生化球填料,装填高度为70 cm,在pH为7.1～7.6,DO为5～7 mg.L-1,气水比20∶1左右,有机负荷约为4g.(m3.h)-1,水力停留时间(HRT)为1 h条件下,生物滤器中氨氮的去除主要发生在填料高度0～10 cm处,10～70 cm处氨氮去除量很少.进水氨氮质量浓度的增大和水力停留时间的降低都会导致出水氨氮质量浓度增大.此外,模型对进水氨氮质量浓度较低时的沿程出水氨氮质量浓度具有很好的预测效果;当进水氨氮质量浓度较高时,预测值略低于实际结果.