深水淹没高喷注浆帷幕技术

介绍导孔钻进、旋喷注浆成桩、桩顶沉降回灌等三重管高压旋喷注浆技术、参数、设备、工艺及其在上海市杨树浦水厂改建工程中的成功应用。该技术对保证安全、优质、高效的施工发挥了重要作用。     

Effects of compression ratio,swirl augmentation techniques and ethanol addition on the combustion of CNG–biodiesel in a dual-fuel engine

The diminishing resources and continuously increasing cost of petroleum in association with their alarming pollution levels from diesel engines has led to an interest in finding alternative fuels to diesel. Emission control and engine efficiency are two of the most important parameters in current engine design. The impending introduction of emission standards such as Euro IV and Euro V has forced research towards developing new technologies for combating engine emissions. This paper examines the effects of compression ratio, swirl augmentation techniques and ethanol addition on the combustion of compressed natural gas (CNG) blended with Honge oil methyl esters (HOME) in a dual fuel engine. The present results show that the combustion of HOME and 15% ethanol blend with CNG induction in a dual-fuel engine operated in optimized parameters at an injection timing of 27° Before Top Dead Centre and a compression ratio of 17.5 resulted in acceptable combustion emissions and improved brake thermal efficiencies. The implementation of swirl augmentation techniques increased brake thermal efficiencies (BTEs) and considerably reduced combustion emissions such as smoke, HC, CO and NO_x. The addition of ethanol also increased BTEs. However, at more than 15% of ethanol in HOME, NO_x emissions increased dramatically.     

辽河油田稠油泥砂综合处理工艺的研究*

稠油污泥作为含油污泥的典型代表,其成分极为复杂、处理难度极大,由于目前国内外尚无成熟工艺可完全实现其"减量化、资源化、无害化处理",给油田生产和环境保护带来了严重影响。文章分析了稠油污泥的组成及性质,根据稠油污泥来源不同实施分类预处理,利用热风干化技术将其减量,经热解气化焚烧和热能利用,为实现含油污泥无害化处理进行了有益探索。     

稠油污水回用锅炉处理工艺的应用

新疆油田公司稠油污水处理普遍采用成熟的离子调整旋流反应水处理技术,污水处理后达到回用锅炉水质标准SY/T 0097-2000《稠油油田采出水用于蒸汽发生器给水处理设计规范》,供给油田专用高压注汽锅炉用水。采用相同技术建成的采油一厂稠油处理站污水回用锅炉处理工艺投用后,处理后污水回用锅炉,减少了含油污水的外排,充分利用了稠油污水的热能,取得了良好的经济和社会效益。     

无上部抽吸装置储罐区人工龙卷风风场模拟

为了减少因储罐泄漏位置不确定造成的人员伤亡,指导应急疏散,提出利用人工龙卷风定向控制气体流动方向的模型。首先基于Fluent软件建立了储罐区域人工龙卷风数值模型,分析切向速度和压强沿径向变化规律,发现与经典Rankine涡模型切向速度沿径向分布规律一致,证实可在储罐区以射流相切的方式形成人工龙卷风风场。其次研究了涡流比和进风量对风场控制气流特性的影响,即分析形成的龙卷风风场最大切向速度、压强差变化规律,结果表明,涡流比越大,形成的龙卷风风场中切向速度和压强差越小,即气流向中心汇聚能力越弱;进风量越大,形成的龙卷风风场中切向速度和压强差越大,即气流向中心汇聚能力越强。研究表明,用人工龙卷风控制储罐泄漏气流方向是可行的。     

Effects of EGR,swirl augmentation techniques on combustion of biodiesel/ethanol and their blends in a diesel engine

The diminishing resources and continuously increasing cost of petroleum in association with their alarming pollution levels from diesel engines have caused an interest in finding alternative fuels to diesel which are renewable and sustainable. Emission control and engine efficiency are two most important parameters in current engine design. The impending introduction of emission standards such as Euro IV and Euro V is forcing the research towards developing new technologies for combating engine emissions. The classification of Euro IV and V norms is applicable to heavy-duty engines in Europe, where as Euro 5 is applicable to light-duty engines. This paper presents the effects of exhaust gas recirculation (EGR), swirl augmentation techniques and ethanol addition on the combustion of Honge oil methyl ester (HOME) and its blends with ethanol in a diesel engine. From the experimental work conducted, it is found that the combustion of HOME plus up to 15% ethanol blend in a diesel engine operated with optimised parameters of injection timing 23° Before Top Dead Centre and compression ratio 17.5 results in acceptable combustion emissions and improved brake thermal efficiency (BTE). The addition of ethanol increased BTE with reduced hydrocarbons (HCs), CO and smoke emissions. However, NO _x emissions increased dramatically. Use of appropriate EGR reduces NO _x to acceptable levels. The implementation of swirl augmentation techniques further resulted in increased BTE and considerable reduction in tail pipe emissions such as smoke, HCs, CO and NO _x . The effect of swirl by providing grooves on the piston was taken into consideration to find the overall biodiesel engine performance, which gives scope for further studies.     

电捕法净化焙烧炉沥青烟气

针对炭素焙烧炉烟气特点,采用雾化水预处理和电捕焦油技术,对某炭素厂焙烧炉烟气进行治理,达到既高效净化有害气体,又降低资金投入。处理后的烟气指标为:沥青烟浓度13.8mg/m3,苯并(a)芘浓度0.053×10-3mg/m3,烟尘浓度19.1mg/m3,各项污染物均达标排放。     

接地极雾化电晕放电旋风除尘器的实验研究

静电旋风除尘器的除尘效率高,占地面积小,安装方便,得到了广泛的应用。比较了接地极雾化电晕放电旋风除尘器,静电旋风除尘器和传统旋风除尘器的放电特性、捕集效率、分割粒径、分级效率和对高比电阻的适应能力。研究表明:首先,流量为80 m L/min时,接地极雾化电晕放电旋风除尘器的起晕电压和放电电流均优于静电旋风除尘器;其次,接地极雾化电晕放电旋风除尘器的分割粒径和分级效率都明显优于静电旋风除尘器,而分级效率更是较传统旋风除尘器提高了15%以上。最后,当粉尘的比电阻增大时,接地极雾化电晕放电旋风除尘器的收集效率保持稳定,几乎不随工作时间改变,而静电旋风除尘器的效率则随着工作时间的增加而降低。因此,接地极雾化电晕放电技术更有利于高比电阻粉尘的捕集,应用前景广阔。     

径向浓淡旋流煤粉燃烧器直流二次风对流场及NO_x排放的影响

针对径向浓淡旋流煤粉燃烧器直流二交风对出口冷态流动特性的影响进行了试验研究，并在一台２２０ｔ／ｈ锅炉和一台６７０ｔ／ｈ锅炉上进行了工业性试验。冷模试验表明，直流二次风对旋流燃烧器出口气流的流动和混合特性有重要影响。     

双旋喷雾除尘工艺治理选煤厂粉尘实践

粉尘问题是影响选煤厂高效安全洁净生产的重要问题。分析了粉尘产生和扩散的原因,根据选煤厂的实际采用密闭抑尘与双旋喷雾除尘相结合工艺治理粉尘污染。该工艺系统简单,运行可靠,投资少有较好的应用前景。