Using chemical process simulation to design industrial ecosystems

Chemical process simulation (CPS) software has been widely used by chemical (process) engineers to design, test, optimise, and integrate process plants. It is expected that industrial ecologists to bring these same problem-solving benefits to the design and operation of industrial ecosystems can use CPS. This paper provides industrial ecology researchers and practitioners with an introduction to CPS and an overview of chemical engineering design principles. The paper highlights recent research showing that CPS can be used to model industrial ecosystems, and discusses the benefits of using CPS to address some of the technical challenges facing companies participating in an industrial ecosystem. CPS can be used to (i) quantitatively evaluate and compare the potential environmental and financial benefits of material and energy linkages; (ii) solve general design, retrofit, or operational problems; (iii) help to identify complex and often counter-intuitive solutions; and (iv) evaluate what-if scenarios. CPS should be a useful addition to the industrial ecology toolbox.     

安徽月山地区闪长岩类地质地球化学研究

安徽月山地区是长江中下游地区的重要成岩-成矿区段。本文通过岩石学、岩石化学和同位素地球化学等方面的研究，探讨和阐明了月山地区闪长岩类的形成环境、物质来源、源区特征、岩浆形成与演化机理等。     

从动力地质作用原理探讨沙漠化成因

大规模沙漠化从岩石记录中可以追溯到中生代中期，第四纪以来南北两半球各存在一条中纬度沙漠带，中国的沙漠化是这个全球沙漠化进程的一个组成部分。沙漠化是在地质演化过程中受内、外动力地质作用联合控制的地质事件。是岩石圈与大气圈、生物圈及水圈强烈作用在地壳表层形成的一种特殊地质现象。这种现象的形成与演化是漫长的和具有周期性的，不会因为局部的条件变化而发生整体意义上的突变。人类活动是局部的，在整个地球沙漠化进程中只是起到一个加速剂的作用。沙漠化过程可分为3个阶段，即物理风化与沙源积聚阶段、风沙作用阶段和沙漠化阶段。沙漠期后沙丘沙经过固化生草、胶结成岩阶段后即形成风成砂岩。     

生物作用强化城市污水一级处理工艺研究

提出生物作用强化城市污水一级处理工艺 ,探讨利用生物絮凝吸附作用独立承担城市污水处理任务的可行性、影响因素及运行参数。试验证明 ,处理城市污水 ,当HRT为 1 1h ,DO为 1 0mg L ,CODCr污泥负荷为 3 4～ 4 0kg kg·d时 ,CODCr、BOD5和SS去除率分别为 6 8%～ 78%、6 5 %～ 72 %和 75 %～ 85 %。     

加压活性炭生物膜法处理DSD有机废水

采用加压活性炭生物膜法处理以对硝基甲苯磺酸盐为主的难降解的有机废水的研究,是在活性炭生物膜法处理有机废水基础上发展起来的新技术。本实验结果表明,在加压9.8×10~4Pa(1kgt/cm~2)的条件下,COD_(Cr)去除率为62％～70％,比常压活性炭生物膜法高20％～25％;其容积负荷Nv=1.7～2.9kgCOD/m~3·d,比一般活性污泥法高3～6倍。     

循环悬浮式半干法烟气脱硫技术在煤粉锅炉中的应用

半千法烟气脱硫技术目前在国内正在快速推广应用中，但成功的实例还较少，还存在系统不可靠，技术指标达不到，故障率高等问题。介绍了循环悬浮式半千法烟气脱硫技术及首次在煤粉锅炉中应用的烟气净化新工艺：静电预除尘＋循环悬浮式半干法烟气脱硫＋布袋除尘，论述了净化原理及在我厂的实际应用情况。     

固硫剂制备工艺探讨

探讨了循环流化床锅炉脱硫方法中固硫剂的制备工艺，对几种石灰石破碎设备及工艺进行了分析比较，通过柱磨机粉磨石灰石的工业试验，了解其产品粒度分布，从而择优确定固硫剂制备工艺流程。     

Calculating overpressure from BLEVE explosions

Although a certain number of authors have analyzed the prediction of boiling liquid expanding vapour explosion (BLEVE) and fireball effects, only very few of them have proposed methodologies for predicting the overpressure from such explosions. In this paper, the methods previously published are discussed and shown to introduce a significant overestimation due to the erroneous thermodynamic assumptions—ideal gas behaviour and isentropic vapour expansion—on which they are based (in fact, they give the maximum value of overpressure which can be caused by a BLEVE). A new approach is proposed, based on the—more realistic—assumption of an adiabatic and irreversible expansion process; the real properties of the substance involved in the explosion are used. The two methods are compared through the application to a given case.     

Stabilization and utilization of hospital waste as road and asphalt aggregate

This article reports the operational results of the effective utilization of hospital waste molten slag produced using a high-temperature melting system, and being operated at a hospital in Selangor, Malaysia. The hospital waste is incinerated and subsequently melted at 1200°C. Scanning election microscope (SEM)/EDX results showed that the slag produced after melting contained amounts of SiO₂, CaO, and Al₂O₃ in excess of 53%, 9%, and 16%, respectively. The results from a leaching analysis on the slag produced proved that the melting process had successfully stabilized the heavy metals. The use of this slag as an alternative material to replace conventional aggregates for road construction was studied. The results from aggregate and asphalt mix tests showed that the slag produced fulfills all the requirements of an alternative aggregate. The average asphalt content, or the optimum asphalt content to be mixed with hospital waste molten slag, was found to be about 5.53%.     

稳定同位素混合模型揭示的长江下游新石器时代人群摄食策略

长江下游地区是稻作农业的主要起源地之一。然而,水稻对长江下游新石器时代人群饮食的贡献程度仍不清晰。稳定同位素混合模型能够量化揭示长江下游地区史前人群的摄食策略。系统收集长江下游地区已发表的人骨、动物骨和植物稳定碳氮同位素数据,基于稳定同位素混合模型,对长江下游地区新石器时代人群的摄食策略进行研究。结果发现：距今7.0—5.3 ka长江下游地区人群可能摄食多种动植物资源,该时期水稻对人类饮食的贡献与其他植物资源基本相当。距今5.3—4.3 ka,水稻已超过其他动植物资源,成为美人地遗址人群的主要食物资源。研究揭示了长江下游新石器时代文明化进程与稻作农业发展具有同步性,狩猎采集经济则为该区域文明化进程起到基础支撑作用。