提高畜禽粪便沼气发酵产气量的研究进展

随着畜禽养殖规模的不断扩大,合理处理畜禽粪便是目前刻不容缓的问题.目前,沼气发酵是解决畜禽养殖场粪污处理和资源化利用的主要方式之一,且通过提高畜禽粪便沼气发酵产气量可以实现将粪便变废为宝的目的和达到资源利用最大化效果.综述了畜禽粪便沼气发酵产气的内在影响因素和外在影响因素对产气量的影响,为提高畜禽粪便的利用率和沼气发酵...     

Abating whey organic load through ethanol and lactic acid production by kefir

Abstract

The extent to which selected ethanol and lactic acid production bioprocesses contribute to whey waste abatement was examined. Alcoholic fermentation of whey was carried out by kefir cells immobilized on grape stalks, delignified cellulosic materials, or brewer's spent grains. Lactic acid fermentation was also performed by free kefir cells with or without addition of brewer's spent grains as promoting material. Since whey fermentation rate is affected by the lactose uptake rate, ¹⁴C-labeled lactose was used to study the fermentation ability of kefir. The highest reductions in biochemical oxygen demand and chemical oxygen demand of whey, about 68% and 52%, respectively, were achieved by lactic acid fermentation in 6 h at 37 °C and pH 5.5, in the presence of 120 g brewer's spent grains. Additionally, at the same conditions, the highest ¹⁴C-labeled lactose uptake rate by kefir and consequently the highest alcoholic fermentation rate were also recorded. However, greater reductions in biochemical oxygen demand and chemical oxygen demand of whey are required prior to final disposal.     

炭纤维载体固定床厌氧发酵启动运行效果实验

以开发高效率、抗冲击性能强的高浓度有机废水沼气发酵技术为目的,用传统的 UASB反应器作为对照,研究了以炭纤维为生物膜载体的固定床厌氧反应器的启动运行效果。反应器进口废水 COD 为 5 000 mg/L, 水力停留时间 (HRT) 由213 h 逐步缩短为35 h,进水有机容积负荷(OLR)由0.56 kg COD/ (m³·d)提到3.45 kg COD/(m³·d)。结果表明,固定床反应器厌氧发酵的效率比对照高,出水 pH 值也比对照稳定;运行到第 50 d 时,固定床厌氧反应器和对照的 COD去除率分别由第 7 d 的36.56%和33.58%上升到87.9%和62.6%;固定床厌氧反应器的容积比产气率最高为1.16 m³/(m³·d),累计产气量为415.59 L,而对照的容积比产气率最高值仅为0.31 m³ /(m³·d),累计产气量为 71.66 L,前者最高容积比产气率和累计产气量分别是后者的3.74倍和5.78倍。固定床厌氧反应器的启动速度、COD 去除率和产甲烷效率显著地高于对照反应器。     

利用酒糟生产饲料蛋白的菌种选育

为了提高酒糟蛋白质的含量和粗纤维的降解,本研究选菌种３０株,以白酒糟为原料筛选出优质饲料蛋白菌株８５０２,８５０３和８５０５三株。用微生物液体发酵法,经研究发现,以８５０３和８５０５组成的多菌发酵体系,使酒糟初始蛋白含量由２３．０％。     

Analysis of metabolic changes in Trichoderma asperellum TJ01 at different fermentation time-points by LC-QQQ-MS

Trichoderma spp. are among the most widely recognized biocontrol fungi used to inhibit pathogens and promote plant growth. These functions are related to primary and secondary metabolites. This study investigated the different metabolites in Trichoderma asperellum TJ01 cultured for 24 and 72?h using liquid chromatography with triple-quadrupole mass spectrometry. Compared to the 24?h culture of T. asperellum TJ01, the 72?h culture with amino acid metabolism tended to decrease while sugar and lipid metabolisms tended to increase. Furthermore, the 72?h culture had a higher proportion of upregulated flavonoids, in combination with a higher proportion of downregulated alkaloids, and equal proportions of upregulated and downregulated polyphenols and hormones. This study also identified a few valuable medicinal substances such as trigonelline and 5-hydroxytryptophan in T. asperellum TJ01 fermentation cultures.     

Highly efficient conversion of sugarcane bagasse pretreated with liquid hot water into ethanol at high solid loading

Liquid hot water (LHW), an environmental-friendly physico-chemical treatment, was applied to pretreat the sugarcane bagasse (SCB). Tween80, a non-ionic surfactant, was used to enhance the enzymatic hydrolysis of the pretreated SCB. It found that 0.125 mL Tween80 /g dry matter could make the maximum increase (33.2%) of the glycan conversion of the LHW-pretreated SCB. A self-designed laboratory facility with a plate-and-frame impeller was applied to conduct batch hydrolysis, fed-batch hydrolysis, and the process of high-temperature (50°C) fed-batch hydrolysis following low-temperature (30°C) simultaneous saccharification and fermentation (SSF) which was adopted to overcome the incompatible optimum temperature of saccharification and fermentation in the SSF process. After hydrolyzing LHW-pretreated SCB for 120 h with commercial cellulase, the total sugar concentration and glycan conversion obtained from fed-batch hydrolysis were 91.6 g/L and 68.3%, respectively, which were 9.7 g/L and 7.3% higher than those obtained from batch hydrolysis. With Saccharomyces cerevisiae Y2034 fermenting under the non-sterile condition, the ethanol production and theoretical yield obtained from the process of SSF after fed-batch hydrolysis were 55.4 g/L and 88.3% for 72h, respectively, which were 15.5 g/L and 24.7% higher than those from separate fed-batch hydrolysis and fermentation. The result of this work was superior to the reported results obtained from the LHW-pretreated SCB.     

Kinetics study of fermentative hydrogen production from liquid swine manure supplemented with glucose under controlled pH

Kinetics of H₂ production from liquid swine manure supplemented with glucose by mixed anaerobic cultures was investigated using batch experiments under four different pH conditions (4.4, 5.0, 5.6, and uncontrolled). The temperature for the experiments was controlled at 37 ± 1°C and the length of experiments varied between 50 and 120 hours, depending upon the time needed for completion of each individual experiment. The modified Gompertz model was evaluated for its suitability for describing the H₂ production potential, H₂ production rate, and substrate consumption rate for all the experiments. The results showed that the Gompertz model could adequately fit the experimental results. The effect of pH was significant on all kinetic parameters for H₂ production including yield, production rate and lag time, and the substrate utilization rate. The optimal pH was found to be 5.0, at which a maximum H₂ production rate (0.64 L H₂/h) was obtained, and deviation from the optimal pH could result in substantial reductions in H₂ production rate (0.32 L H₂/h for pH 4.0 and 0.43 L H₂/h for pH 5.6). The results also showed that if pH was not controlled for the batch fermentation process, the substrate utilization efficiency could steeply decrease from 98.8% to 33.7%.     

水稻与棉花秸秆不同预处理厌氧发酵产沼气

以猪粪为接种物,以棉花秸秆和水稻秸秆为发酵原料,分别对秸秆进行稀碱法预处理和稀碱法与超声波联合预处理,在发酵温度为(37±1)℃的条件下进行厌氧发酵产沼气的研究。结果表明,以联合预处理的秸秆为发酵原料,厌氧发酵的各项指标均比以稀碱预处理秸秆发酵的效果好,其中累积产气量和沼气中甲烷含量分别提高35.23%和2.4%,发酵后TS、VS含量相对减少2.6%～10.94%,发酵液代谢产物中的有机酸丙酮酸、乙酸和柠檬酸含量相对减少23.9%～25.9%、20.24%～24.53%和41.08%～45.91%。     

不同菌种组合对发酵残余物好氧堆肥进程及氮素变化的影响

适宜菌剂组合对于初始电导率（Electronic conductivity,EC）较高的发酵残余物二次干化腐熟效果具有重要影响。通过在发酵残余物（猪场沼渣、城市生活污泥）好氧发酵过程中添加不同菌种组合,研究堆肥腐熟指标变化,特别是不同形态氮素指标变化,以期更好提升发酵残余物的干化和腐熟程度。结果表明：F3菌剂组合处理高温期达16 d,最高温度为69.5℃,最早进入腐熟阶段,全氮损失比例最少,为8.72%;对照组在高温期（14 d、69.3℃）及全氮损失比例（9.21%）指标上仅低于F3处理组,表明自然堆体存在耐盐菌种;在促进堆肥腐熟效果方面,霉菌起着关键的作用,堆肥后期酵母菌的存在促进堆体腐熟度的提升;菌种比例和种类的合理设置对于堆体腐熟度提高的重要性要高于活菌添加量;在堆肥保氮过程中,真菌（霉菌和酵母菌）起着重要作用。F3处理（即芽孢杆菌：霉菌：酵母菌=1：2：2）,是实现发酵残余物快速高效堆肥的理想菌剂配方,其他复配菌种组合保氮效果改良侧重点各不相同。     

酸化冲击对低pH厌氧发酵系统性能的影响

为了研究酸化冲击对厌氧发酵有机废水能源回收系统的影响,利用自制的厌氧内循环反应器（anaerobic internal circulation reactor,AICR）,以模拟糖蜜废水为底物,逐步提高进水容积负荷以模拟高容积负荷下出现的酸化冲击。研究了反应器酸化前后运行参数,并利用高通量测序检测了酸化后系统微生物群落结构。结果表明：酸化会导致颗粒污泥解体,产气速率和COD去除率下降,产甲烷活性严重抑制,同时发酵类型也发生转变。反应器酸化以后,发酵类型从丁酸型发酵类型转变为混合酸发酵类型,在进水负荷不变的情况下,总产气速率下降约50%,从2 100 mmol·（L·d）-1下降至1 056 mmol·（L·d）-1。酸化后的系统中,非产氢发酵细菌为优势细菌（54.7%）,而产氢细菌所占比例较少（37.3%）,未检测到产甲烷细菌。