复合催化氧化技术对油气田压裂返排液的处理研究

酸化压裂作业废水是石油天然气生产过程中的主要污染源,它的污染成份复杂,有害物质浓度高,特别是含有胍胶和表面活性剂等高分子物质,具有高COD、高稳定度、高粘度的特点.本文通过对压裂液的来源、水质特征、治理现状等常用方法的分析,确定了物理化学脱稳,过滤、O3/H2O2复合催化氧化、深度氧化的达标治理工艺路线.经过处理后的压裂液澄清透明,达到国家二级排放标准(GB8978-96).     

兼性生化处理生活污水最佳工况研究

在常温条件下进行兼性生化处理生活污水试验,研究COD去除率与HRT、MLSS、进水有机物浓度和混合液水温的关系。在试验中最佳的水平搭配为MLSS=5500mg/L,进水有机物浓度=180mg/L,HRT=8h和混合液水温=20℃,与回归分析所得出MLSS=5881mg/L,进水有机物浓度=192.7mg/L,HRT=8.9063h和混合液水温=21.3790℃的最佳工艺条件相吻合。最后通过等高线分析得出常温下生活污水兼性生化的适宜范围。     

序批式反应器的水力停留时间的理论探讨

根据液龄分布函数是二元函数的观点．推导出了当进、出水流量是时间的函数时，反应器的水力停留时间的通用积分式和离散式；然后得出了序批式反应器(SBR）的水力停留时间(HRT)具体表达式，并分析了用现有方法计算其水力停留时间所产生的误差．结果表明，最大相对误差rmax仅与充水比λ有关．且呈正相关关系．取典型值λ=0．4时，rmax高达25％。     

New process for anaerobic treatment of Vitamin C wastewater in a full scale plant

１ＩｎｔｒｏｄｕｃｔｉｏｎＴｈｅＦｉｒｓｔＰｈａｒｍａｃｅｕｔｉｃａｌＦａｃｔｏｒｙｉｎＳｈｉｊｉａｚｈｕａｎｇＣｉｔｙ，Ｃｈｉｎａ，ｂｕｉｌｔａｓｅｔｏｆｅｑｕｉｐｍｅｎｔｏｆｆｕｌｓｃａｌｅｔｒｅａｔｉｎｇＶｉｔａｍｉｎＣｗａｓｔｅｗａｔｅｒｉｎ...     

一种新型复合式生物流化反应器混合特性的研究

对新型蜂窝状断面复合生物流化反应器进行了液体循环速率和水力停留时间分布曲线的测定，实验表明新型反应器具有抗冲击负荷强，接近CSTR反应器的特点，反应器随气量增大、载体投加量减少和进水量减少而更近似于CSTR反应器，通过理论分析，证明了影响液体循环速率的参数主要有气体流量(气含率)、反应器沿程和局部阻力系数以及Ad/Ar，并且得出液体循环速率与反应器高度的0．5次方成正比。     

Determination and discussion hydraulic retention time in membrane bioreactor system

Based on the microorganism kinetic model, the formula for computing hydraulic retention time in a membrane bioreactor system (MBR) is derived. With considering HRT as an evaluation index a combinational approach was used to discuss factors which have an effect on MBR. As a result, the influencing factors were listed in order from strength to weakness as: maximum specific removal rate K, saturation constant Ks, maintenance coefficient m, maximum specific growth rate ,ua and observed yield coefficient Yobs. Moreover, the formula was simplified, whose parameters were experimentally determined in petrochemical wastewater treatment. The simplified formula is θ= 1.1( 1/β -1)(Kｓ S)/KXo , for oetroehemical wastewater treatment K and Ko eaualed 0.185 and 154.2, resoectively.     

流体动力系统噪声控制研究

以泵为例分析了液压动力系统中噪声产生的机理和危害，结合多年来的生产经验，给出降低和控制液压动力系统噪声的思路和几种基本方法。     

页岩气加砂压裂高压管汇失效爆裂风险 控制措施研究与实践

随着页岩气平台井工厂化压裂施工启动,在大排量、高压力、长时间施工条件下,高压管汇失效爆裂大幅增加。为减少高压管汇在压裂过程中失效爆裂风险,运用故障假设、因果分析法从人的因素、物的因素、技术工艺、生产管理、工作环境5个方面分析事故的原因,提出了提升采购产品质量、修订完善高压管汇使用技术规范和管理制度、实施专业化管理、应用大数据管理高压管汇、优化现场地面高压管汇流程分配布局设计与联接工艺等高压管汇失效爆裂风险预防控制措施和失效后应急安全防护措施,建立了生命周期全过程、专业化的高压管汇失效爆裂防控与应急防护体系,实现风险可防受控。为页岩气压裂作业的安全提供了参考。     

An investigation on the fuel savings potential of hybrid hydraulic refuse collection vehicles

Refuse trucks play an important role in the waste collection process. Due to their typical driving cycle, these vehicles are characterized by large fuel consumption, which strongly affects the overall waste disposal costs. Hybrid hydraulic refuse vehicles offer an interesting alternative to conventional diesel trucks, because they are able to recuperate, store and reuse braking energy. However, the expected fuel savings can vary strongly depending on the driving cycle and the operational mode. Therefore, in order to assess the possible fuel savings, a typical driving cycle was measured in a conventional vehicle run by the waste authority of the City of Stuttgart, and a dynamical model of the considered vehicle was built up. Based on the measured driving cycle and the vehicle model including the hybrid powertrain components, simulations for both the conventional and the hybrid vehicle were performed. Fuel consumption results that indicate savings of about 20% are presented and analyzed in order to evaluate the benefit of hybrid hydraulic vehicles used for refuse collection.     

生态高负荷土地快速渗滤系统处理猪场废水的效能及微生态

以经过厌氧反应器处理后的猪场废水为研究对象,探讨了新型生态高负荷土地快速渗滤系统对废水中COD、氨氮及总氮的去除情况;同时分析了该系统中的微生物群落结构以及过氧化氢酶、脲酶、硝酸盐还原酶的含量.结果表明,在水力负荷为11 cm·d~(-1)、进水COD为700 mg·L~(-1)左右的条件下,一级土地渗滤柱与二级土地渗滤柱对COD的去除率分别为78.8%与63.0%,总去除率达到了92.6%;而当水力负荷增大到22 cm·d~(-1)时,总的COD去除率仍在90.0%以上;该系统对于氨氮的去除更为显著,去除率可达99%左右.一级土地快速渗滤系统中上、中、下部的过氧化氢酶含量分别为1.899、0.990、0.323 m L·g~(-1),表明猪场废水中的有机物主要在该系统的上部与中部得以去除;二级土地快速渗滤系统上、中、下部的硝酸盐还原酶含量分别是3.453、3.831、1.971 m L·g~(-1),表明脱氮作用主要发生二级土地快速渗滤系统的上部与中部.该土地快速渗滤系统中微生物以Gram Negative与Gram Positive为主,特别是在二级土地快速渗滤系统中,AM Fungi与Actinomycetes占有一定比例,为猪场废水中难降解有机物的去除提供了保障.