|
|||||
|
|
| 用甲基异丁基甲酮从电子废料中萃取金及条件优化 | |
| 引用本文： | 王哲,丁辉,李鑫钢,刘雪艳,汤桂兰,顾春瑞,巩晓明.用甲基异丁基甲酮从电子废料中萃取金及条件优化[J].环境科学学报,2010,30(3):544-548. |
| 作者姓名： | 王哲 丁辉 李鑫钢 刘雪艳 汤桂兰 顾春瑞 巩晓明 |
| 作者单位： | 1. 天津大学精馏技术国家工程研究中心,天津,300072;北洋国家精馏技术工程发展有限公司,天津,300072 2. 天津大学精馏技术国家工程研究中心,天津,300072 3. 北洋国家精馏技术工程发展有限公司,天津,300072 4. 天津子牙环保产业园,天津,301605 |
| 基金项目： | 天津市科技创新专项资金项目（No.07FDIDSH02400） |
| 摘 要： | 以电子废料中的金为研究对象,用统计学方法对甲基异丁基甲酮(MIBK)萃取电子废料中金的影响因素进行了探讨和分析.同时,通过Plackett-Burman实验设计筛选出相比、萃取时间和萃取温度为主要影响因素,并应用响应面方法分析得到了这3个因素的优化结果.数据统计分析结果表明,最佳的萃取条件为相比0.58、萃取时间9.0min、萃取温度20℃,在此条件下金的萃取率最高可达98.36%.萃取液经质量分数5%的草酸溶液还原,反萃金的回收率可达到96.2%. |
| 关 键 词： | 电子废料 甲基异丁基甲酮(MIBK) 金的萃取率 Plackett-Burman设计 响应面方法(RSM) |
| 收稿时间： | 2009/5/18 0:00:00 |
| 修稿时间： | 9/8/2009 12:00:00 AM |
Investigation of gold purified from electronic waste with methyl isobutyl ketone |
|
| WANG Zhe,DING Hui,LI Xingang,LIU Xueyan,TANG Guilan,GU Chunrui and GONG Xiaoming.Investigation of gold purified from electronic waste with methyl isobutyl ketone[J].Acta Scientiae Circumstantiae,2010,30(3):544-548. | |
| Authors: | WANG Zhe DING Hui LI Xingang LIU Xueyan TANG Guilan GU Chunrui and GONG Xiaoming |
| Institution: | 1. National Engineering Research Centre for Distillation Technology, Tianjin University, Tianjin 300072; 2. Pei-yang Distillation Engineering Limited Company, Tianjin 300072,National Engineering Research Centre for Distillation Technology, Tianjin University, Tianjin 300072,National Engineering Research Centre for Distillation Technology, Tianjin University, Tianjin 300072,Pei-yang Distillation Engineering Limited Company, Tianjin 300072,Ziya Environmental Protection Industry Park, Tianjin 301605,Ziya Environmental Protection Industry Park, Tianjin 301605 and Ziya Environmental Protection Industry Park, Tianjin 301605 |
| Abstract: | To improve the extraction of gold from electronic waste,statistical methods were used to analyze the impact of different factors affecting the extraction of Ao (III) using methyl isobutyl ketone (MIBK) as solvent.The Plackett-Burman experimental design was used to determine the main influencing factors which are phase ratio,extraction time and extraction temperature.Using these three factors as variables,the extraction operation conditions were optimized by Response Surface Methodology (RSM).The optimum phase ratio was 0.59 (water to MIBK) ,extraction time 9.0 rain and extraction temperature 20℃.Under this optimized condition,the extraction rate of Au(III) was 98.36% which was much higher than that under other conditions.The MIBK-Au(III) was regenerated with a 5 solution of oxalic acid,and the recovery of stripped gold was 96.2%. |
| Keywords: | electronic waste MIBK extraction rate of Au Plackett-Burman RSM |
| 本文献已被 CNKI 万方数据 等数据库收录！ | |
| 点击此处可从《环境科学学报》浏览原始摘要信息 | |
| 点击此处可从《环境科学学报》下载免费的PDF全文 | |