The use of a sequential leaching procedure for assessing the heavy metal leachability in lime waste from the lime kiln at a caustizicing process of a pulp mill |
| |
Authors: | Pöykiö Risto Nurmesniemi Hannu Kuokkanen Toivo Perämäki Paavo |
| |
Affiliation: | aCity of Kemi, The Town Planning and Building Committee, The Environmental Research Division, Valtakatu 26, FIN-94100 Kemi, Finland bStora Enso Oyj, Veitsiluoto Mills, FIN-94800 Kemi, Finland cUniversity of Oulu, Department of Chemistry, P.O. Box 3000, FIN-90014 Oulu, Finland |
| |
Abstract: | A five-stage sequential leaching procedure was used to fractionate 13 heavy metals (Cd, Cu, Pb, Cr, Zn, Fe, Mn, Al, Ni, Co, As, V, Ba) and sulphur (S) in lime waste from the lime kiln at the causticizing plant of Stora Enso Oyj Veitsiluoto Pulp Mills at Kemi, Northern Finland, into the following fractions: (1) water-soluble fraction (H2O), (2) exchangeable fraction (CH3COOH), (3) easily reduced fraction (HONH3Cl), (4) oxidizable fraction (H2O2 + CH3COONH4), and (5) residual fraction (HF + HNO3 + HCl). Although metals were leachable in all fractions, the highest concentrations for most of the metals were observed in the residual fraction (stage 5). It was also notable that the total heavy metal concentrations in lime waste did not exceed the maximal allowable heavy metal concentrations for soil conditioner agents set by the ministry of the Agricultural and Forestry in Finland. The heavy metals concentrations in lime waste were also lower than the maximal allowable heavy metals concentrations of the European Union Directive 86/278/EEC on the protection of environment, and in particular of the soil, when sewage sludge is used in agriculture. The Ca concentration (420 g kg−1; d.w.) was about 262 times higher than the typical value of 1.6 g kg−1 (d.w.) in arable land in Central Finland. However, the concentration Mg (0.2 g kg−1; d.w.) in lime waste was equal to the Mg concentration in arable land in the Central Finland. The lime waste has strongly alkaline pH (12.8) and a neutralizing value (i.e. liming effect) of 47.9% expressed as Ca equivalents (d.w.). This indicates lime waste to be a potential soil conditioner and improvement as well as a pH buffer. |
| |
Keywords: | Leaching Pulp mill Lime Waste Lime kiln Causticizing |
本文献已被 ScienceDirect PubMed 等数据库收录! |
|