The comparison of growth and nutrient removal efficiency of Chlorella pyrenoidosa in settled and activated sewage

The microscopic green alga, Chlorella pyrenoidosa was grown in settled and activated sewage under two different culture systems, batch and semi-continuous. Good growth was obtained in both types of wastewater and the algal production was comparable to and even higher than that found in commercial Bristol medium. The semi-continuous culture supported more growth than the batch system. There was a close relationship between algal growth and the amount of nutrient removed from both settled and activated sewage. A more rapid drop in NH(4)(+)-N was found in settle rather than activated sewage. The NH(4)(+)-N of settled sewage dropped from its initial 27 to 5 mg litre(-1) in both culture systems. On the other hand, the NO(3)(-)-N of activated sewage started to decrease from Day 2 onwards and the final NO(3)(-)-N concentration was less than 1 mg litre(-1) (over 90% removal efficiency). The amount of total inorganic nitrogen being reduced due to algal culture was similar in both types of sewage. The changes of phosphate content followed the same trend in both sewage, the P concentration increased slightly in the first two days then decreased, especially in the semi-continuous cultures. The final ortho-P in the sewage treated by Chlorella in semi-continuous culture was less than 5 mg litre(-1) (about 62% reduction). Such removal efficiency was slightly lower than those reported in previous studies. In general, the semi-continuous algal culture appeared to be a more suitable and efficient way for wastewater treatment than the batch system. With respect to the total reduction of wastewater inorganic N and P by means of Chlorella cells, there was no significant difference between settled and activated sewage.     

废水营养比对固定化藻菌去除污染物的影响及动力学研究

海藻酸钙作载体的固定化藻菌小球,经壳聚糖覆膜后,用于模拟废水的处理。通过研究废水初始氨氮浓度及碳氮比对固定化藻菌小球处理效果的影响,发现初始氨氮浓度为50 mg/L时,氨氮的去除率达最高值74.4%;碳氮比为35∶1时,COD去除率达最高值77.7%。系统最佳氮磷比与碳氮比分别为5∶1和35∶1。固定化藻菌降解有机物的动力学过程为一级不可逆生化反应过程,其降解速率常数约为0.099 h-1。     

The biological treatment of landfill leachate using a simultaneous aerobic and anaerobic (SAA) bio-reactor system

A set of simultaneous aerobic and anaerobic (SAA) bio-reactor system was used for the removal of organic pollutants and ammonia in the landfill leachate generated from Datian Shan Landfill in Guangzhou, China. The influent concentrations of COD and NH(4)(+)-N were 1000-3300 and 80-230 mg L(-1), respectively. The average effluent concentrations of COD and NH(4)(+)-N were 131 and 7 mg L(-1), respectively. The concentrations of COD and NH(4)(+)-N had reached the Chinese second grade effluent standard (COD<300 mg L(-1), NH(4)(+)-N<25 mg L(-1)) for this kind of wastewater. Gas chromatogram-mass spectrum (GC/MS) analysis was used to measure the organic pollutants in the landfill leachate. About 87 organics were detected in this landfill leachate, and 16 of them belong to the list of environmental priority pollutants established by the US Environmental Protection Agency. About 31 of the 87 organic pollutants were completely removed by the SAA bio-reactor, the concentrations of further 14 organic pollutants were reduced by more than 80%, and the removal efficiencies of the other 25 organic pollutants were over 50%.     

Simulation modeling for nitrogen removal and experimental estimation of mass fractions of microbial groups in single-sludge system

Nitrification-denitrification in a single-sludge nitrogen removal system (SSNRS; with a sufficient carbon source for denitrification) was performed. With an increase in the mixed liquor recycle ratio (R(m)) from 1 to 2, the total nitrogen (TN) removal efficiency at a lower volumetric loading rate (VLR=0.21 NH(4)(+)-N m(-3) d(-1)) increased, but the TN removal efficiency at a higher VLR (0.35 kg NH(4)(+)-N m(-3) d(-1)) decreased. A kinetic model that accounts for the mass fractions of Nitrosomonas, Nitrobacter, nitrate reducer and nitrite reducer (f(n1), f(n2), f(dn1), and f(dn2)) in the SSNRS and an experimental approach for the estimation of the mass fractions of nitrogen-related microbial groups are also proposed. The estimated f(dn1) plus f(dn2) (0.65-0.83) was significantly larger than the f(n1) plus f(n2) (0.28-0.32); the f(n1) (0.21-0.26) was larger than the f(n2) (0.05-0.07); and the f(dn1) (0.32-0.45) varied slightly with the f(dn2) (0.33-0.38). At the lower VLR, the f(dn1) plus f(dn2) increased with increasing R(m); however at the higher VLR, the f(dn1) plus f(dn2) did not increase with increasing R(m). By using the kinetic model, the calculated residual NH(4)(+)-N and NO(2)(-)-N in the anoxic reactor and NO(2)(-)-N and NO(3)(-)-N in the aerobic reactor were in fairly good agreement with the experimental data; the calculated NO(3)(-)-N in the anoxic reactor was over-estimated and the calculated NH(4)(+)-N in the aerobic reactor was under-estimated.     

青萍生长特征及其对受污染河水的修复效果

以浮萍优势品种青萍（Lemna minor）为研究对象,开展受污染河水修复。分析了青萍在不同营养盐浓度条件下的生长特征,探讨了青萍对受污染河水的修复效果。在表面积为0.0095 m2的限制空间条件下,青萍在1、2和5 mg总氮（TN）/L营养液中的生长特征都能较好地服从Logistic生长模型,受制约的临界鲜重（FW）分别为1.20、1.36和1.36 g;青萍对受污染河水中氮磷污染物具有较好的去除效果,氨氮（NH＋4-N）的平均去除率、平均去除量和平均去除速率分别为56.87%、1.22 mg/d和0.0466 mg/（g FW·h）,正磷酸盐（PO3-4-P）的平均去除率、平均去除量和平均去除速率分别为66.95%、0.25 mg/d和0.0088 mg/（g FW·h）。根据相关性分析,进水NH＋4-N和PO3-4-P浓度与其对应去除量之间极显著相关;青萍FW与NH＋4-N去除速率之间显著负相关,但与PO3-4-P去除速率之间不存在显著相关性;NH＋4-N进水浓度与去除速率相关性不显著,但PO3-4-P进水浓度与去除速率显著正相关。     

磷酸铵镁沉淀法预处理垃圾渗滤液

探讨了用磷酸铵镁沉淀法预处理垃圾渗滤液时,沉淀剂种类、pH值、物质摩尔配比和反应时间等因素对氨氮去除效果的影响。得出了处理氨氮浓度为2 677.34 mg/L的垃圾渗滤液时,在兼顾所用镁盐量尽量低和处理出水氨氮或磷酸盐的残留量都比较低的较佳实验条件为:沉淀剂种类为:MgSO4.7H2O和Na2HPO4.12H2O,反应时间为20 min,pH=9.5,n(Mg)∶n(P)∶n(N)=1.3∶1.15∶1.0。在较佳实验条件下,垃圾渗滤液的NH3-N去除率为97.05%,处理出水PO34--P含量为8.35 mg/L,NH3-N含量为75.86 mg/L。对所得沉淀物进行了成分分析和X-衍射光谱、扫描电镜表征,表明大部分沉淀物为磷酸铵镁物质。     

Trends in atmospheric ammonium concentrations in relation to atmospheric sulfate and local agriculture

Ammonium (NH(4)(+)) concentrations in air and precipitation at the Institute of Ecosystem Studies (IES) in southeastern New York, USA declined over an 11-year period from 1988 to 1999, but increased from 1999 to 2001. These trends in particulate NH(4)(+) correlated well with trends in particulate SO(4)(2-) over the 1988-2001 period. The NH(4)(+) trends were not as well correlated with local cattle and milk production, which declined continuously throughout the period. This suggests that regional transport of SO(4)(2-) may have a greater impact on concentrations of NH(4)(+) and subsequent deposition than local agricultural emissions of NH(3). Ammonium concentrations in precipitation correlated significantly with precipitation SO(4)(2-) concentrations for the 1984-2001 period although NH(4)(+) in precipitation increased after 1999 and SO(4)(2-) in precipitation continued to decline after 1999. The correlation between NH(4)(+) and SO(4)(2-) was stronger for particulates than for precipitation. Particulate NH(4)(+) concentrations were also correlated with particulate SO(4)(2-) concentrations at 31 of 35 eastern U.S. CASTNet sites that had at least 10 years of data. Air concentrations of NH(4)(+) and SO(4)(2-) were more strongly correlated at the sites that were located within an agricultural landscape than in forested sites. At most of the sites there was either no trend or a decrease in NH(4)(+) dry deposition during the 1988-2001 period. The sites that showed an increasing trend in NH(4)(+) dry deposition were generally located in the southeastern U.S. The results of this study suggest that, in the northeastern U.S., air concentrations of NH(4)(+) and subsequent deposition may be more closely linked to SO(4)(2-) and thus SO(2) emissions than with NH(3) emissions. These results also suggest that reductions in S emissions have reduced NH(4)(+) transport to and NH(4)(+)-N deposition in the Northeast.     

Dairy manure treatment, digestion and nutrient recovery as a phosphate fertilizer

A combined approach of biological treatment, solids digestion and nutrient recovery was tested on dairy manure. A sequencing batch reactor (SBR) was operated in three modes, in order to optimize nutrient (nitrogen and phosphorus) removals. The highest average removal efficiencies of 91% for NH4-N, 59% for PO4-P and 80% for total chemical oxygen demand (COD) were achieved. Staining experiments suggested the coexistence of glycogen and phosphorus accumulating organisms. Anaerobic digestion of wasted bio-solids was able to produce a PO4-P concentration of 70 mgL-1 in the supernatant. A pilot-scale experiment, designed to recover phosphorus in the supernatant as struvite (magnesium ammonium phosphate), was able to remove 82% of soluble PO4-P.     

ASBBR-二级SBBR-化学除磷组合工艺处理榨菜腌制废水

针对榨菜腌制废水高盐高氮磷高有机物浓度的特征,提出"厌氧序批式生物膜反应器(ASBBR)-二级序批式生物膜反应器(SBBR)-化学除磷"组合处理工艺,在前期对组合工艺中单元工艺的关键工况参数研究的基础上,考察组合工艺的处理效能。实验结果表明,采用该组合工艺,可使进水COD、NH4+-N、TN及PO43--P分别为10 000、345、550和38.5mg/L的榨菜腌制废水,处理出水COD、NH4+-N、TN及PO43--P分别达到93.6、12.3、18和0.1 mg/L,去除率分别为99.1%、96.4%、96.7%和99.9%,出水达到污水综合排放一级标准。     

反硝化除磷颗粒污泥的活性恢复及对生活污水处理能力

实验利用序批式反应器(SBR)考察反硝化除磷颗粒污泥搁置1个月后重新投入运行,其活性恢复能力及对实际生活污水的处理效果。结果表明,颗粒污泥搁置后外观由淡黄色转变为灰黑色,颗粒重新投入反应器,11 d后颜色基本恢复,污泥浓度及活性迅速增加;对COD处理能力的恢复历时14 d,去除率稳定在80.32%以上;颗粒污泥对NH4+-N和PO34--P的去除在40 d时也恢复到正常水平;反硝化聚磷菌(DNPAOs)活性恢复期为50 d。颗粒污泥对低碳氮比的实际生活污水处理结果显示,当C/N<5.1时(生活污水比例>60%),无法满足系统内微生物生长要求,需要外加适量碳源进行补充。     

接种比对碱超声波耦合溶胞污泥水解酸化的影响

以城市污水生物处理过程中的剩余污泥减量化为研究背景,通过实验研究了经碱超声波耦合溶胞后的剩余污泥在不同接种比下水解酸化的效果,分析了污泥上清液中pH、SCOD、VFAs、NH4+-N和PO34--P等参数随时间的变化趋势。结果表明,溶胞污泥经过72 h的水解酸化反应,20%接种比下的水解酸化COD溶出率和VFAs增长率最高,分别为75.5%和177%。蛋白质水解程度为16.9%,也高于50%和70%两组接种比。此外,COD、NH4+-N和PO34--P等主要溶出物均在12 h后达到基本稳定状态。     

Biological treatment of wastewater by selected aquatic plants

Pollutant-removal efficiency of certain macrophytes and algae, such as Eichhornia crassipes, Microcystis aeruginosa, Scenedesmus falcatus, Chlorella vulgaris and Chlamydomonas mirabilis, has been tested in laboratory conditions to evaluate their potential role in wastewater treatment. Sewage of Varanasi city, mixed with the effluents of about 1200 small-scale industries, was used for the tests. The investigation was performed in three stages i.e. a water hyacinth culture followed by an algal culture, and finally a second water hyacinth culture. For the first water hyacinth culture, 10 water hyacinth plants were grown in a tank of wastewater with 15 days' retention time. In the second stage, algal species were cultured in the treated wastewater for 5 days, whilst in the third stage, water hyacinth plants were again grown for further treatment of the wastewater for 9 days. This three-stage aquaculture resulted in very high reductions of BOD (96.9%), suspended solids (78.1%), total alkalinity (74.6%), PO(4)-P (89.2%), NO(3)-N (81.7%), acidity (73.3%), NH(4)-N (95.1%), COD (77.9%), hardness (68.6%) and coliform bacteria (99.2%). An increase in the concentration of dissolved oxygen (70%) was also observed.     

Improving nitrogen removal in two modified decentralized wastewater systems

Efficient nutrient removal in decentralized wastewater treatment systems is a challenging task. To improve the removal of organic matter and nitrogen from wastewater, two types of bioreactors using membrane-aerated biofilm reactor (MABR) and microbial fuel cell (MFC) techniques were evaluated. During more than 250 days of continuous-flow reactor operation, both reactors showed consistently high chemical oxygen demand removal (>86%). At an influent ammonium-nitrogen (NH4(+)-N) concentration of 30 mg N/L, the average effluent NH4(+)-N concentrations were 6.2 and 0.5 mg N/L for the MABR and MFC reactor, respectively, while the effluent nitrate-nitrogen (NO3(-)-N) concentrations were 5.4 mg/ L in the MABR and 19.2 mg/L in the MFC-based reactor. The overall total inorganic nitrogen removal efficiencies were 64% and 36% for the MABR and MFC reactor, respectively. At the measured dissolved oxygen concentrations of 5.2 and 0.23 mg/L in the aerobic/anoxic zone of the MFC and MABR, respectively, a specific oxygen uptake rate of 0.1 g O2/g VSS-d, resulting from ammonia oxidation, was detected in the settled sludge of the MFC, while no nitrifying activity of the sludge from the MABR was detected. Molecular microbial analysis demonstrated a link between the bacterial community structure and nitrifying activity. The relatively high abundance of Nitrosomonas europaea was associated with its detectable nitrification activity in the settled sludge of the MFC. The results suggest that MABR and MFC techniques have the potential to improve organic and nitrogen removal in decentralized wastewater systems.     

Integrated physicochemical and biological treatment process for fluoride and phosphorus removal from fertilizer plant wastewater

The phosphate fertilizer industry produces highly hazardous and acidic wastewaters. This study was undertaken to develop an integrated approach for the treatment of wastewaters from the phosphate industry. Effluent samples were collected from a local phosphate fertilizer producer and were characterized by their high fluoride and phosphate content. First, the samples were pretreated by precipitation of phosphate and fluoride ions using hydrated lime. The resulting low- fluoride and phosphorus effluent was then treated with the enhanced biological phosphorus removal (EBPR) process to monitor the simultaneous removal of carbon, nitrogen, and phosphorus. Phosphorus removal included a two-stage anaerobic/aerobic system operating under continuous flow. Pretreated wastewater was added to the activated sludge and operated for 160 days in the reactor. The operating strategy included increasing the organic loading rate (OLR) from 0.3 to 1.2 g chemical oxygen demand (COD)/L.d. The stable and high removal rates of COD, NH4(+)-N, and PO4(3-)-P were then recorded. The mean concentrations of the influent were approximately 3600 mg COD/L, 60 mg N/L, and 14 mg P/L, which corresponded to removal efficiencies of approximately 98%, 86%, and 92%, respectively.     

Biosorption of reactive black 5 by Corynebacterium glutamicum biomass immobilized in alginate and polysulfone matrices

Corynebacterium glutamicum, a lysine fermentation industry waste, showed promise for the removal of Reactive black 5 (RB5). Due to practical difficulties in solid-liquid separation, the free biomass was immobilized in two polymer matrices: calcium alginate and polysulfone. Initially, the optimization of biomass loading in polymeric beads and bead dosage were examined. Of the different combinations examined, 4% (with bead dosage of 2 g per 40 ml) and 14% (with bead dosage of 1 g per 40 ml) in the case of alginate and polysulfone beads, respectively, were identified as the optimal conditions. According to the Langmuir model, at pH 1, the maximum RB5 uptakes of 352, 282 and 291 mg g(-1) were observed for free, alginate and polysulfone-immobilized biomass, respectively. According to the Weber-Morris model, intraparticle diffusion was found to be the potential rate limiting step for the immobilized beads. Regeneration experiments, with 0.01 M NaOH and Na(2)CO(3) as eluents, revealed that polysulfone beads exhibited invariable RB5 uptake capacity and very high mechanical stability even at the end of twentieth cycle, confirming the technical feasibility of the biosorption process for industrial applications.     

Visual determination of nitrite and nitrate in waters by color band formation method

A spot test for aqueous nitrate and nitrite for controlling nitrogen removal performance in small-scale wastewater treatment facilities is proposed. In this method, NO(2)(-) ion in water samples was allowed to react with sulfanilic acid and 1-naphthol to form an anionic azo dye. The resulting colored solution was introduced onto a mini column (similar to a gas detecting tube) packed with PVC particles coated with benzyl cetyl dimethyl ammonium chloride (BCDMA) and biphenyl. The NO(2)(-)-N concentration was determined visually by measuring the color band length (CBL) in the column. The CBL correlates linearly with nitrite concentration in the 4-20 mg-N l(-1) range. The concentration of nitrite+nitrate was determined after reduction to nitrite with zinc. The concentration of NO(3)(-)-N species was calculated by difference. This method was used to visually determine the concentrations of NO(2)(-)-N and (NO(2)(-)+NO(3)(-))-N in domestic wastewater samples with maximum suspended solid (SS) and chemical oxygen demand (COD) concentrations of 114 mg l(-1) and 73.9 mg l(-1), respectively.     

Electrochemical oxidation of bisphenol A. Application to the removal of bisphenol A using a carbon fiber electrode

Leachate samples with a high strength of ammonium-nitrogen (NH4+-N) were collected from a local landfill site in Hong Kong. Two experiments were carried out to study (1) the inhibition of microbial activity of activated sludge by NH4+-N and (2) the chemical precipitation of NH4+-N from leachate as a preliminary treatment prior to the activated sludge process. The experimental results demonstrated that the efficiency of COD removal decreased from 97.7% to 78.1%, and the dehydrogenase activity of activated sludge decreased from 9.29 to 4.93 microg TF/mg MLSS, respectively, when the NH4+-N concentration increased from 53 to 800 mg/l. The experiment also demonstrated that the NH4+-N in the leachate can be quickly precipitated as MgNH4PO4 x 6H2O after addition of MgCl2 x 6H2O + Na2HPO4 x 12H2O. The NH4+-N concentration was reduced from 5618 to 112 mg/l within 15 min when a molar ratio of Mg2+:NH+:PO4(3-) = 1:1:1 was used. The optimum pH to reach the minimum solubility of MgNH4PO4 x 6H2O was found to be in the range of 8.5-9.0. Attention should be given to the high salinity formed in the treated leachate by using MgCl2 x 6H2O + Na2HPO4 x 12H2O, which may affect microbial activity in the following biological treatment processes. Using two other combinations of chemicals [MgO + 85%H3PO4 and Ca(H2PO4)2 x H2O + MgSO4 x 7H2O] could minimise salinity generation after precipitation, while they were less efficient for NH4+-N removal.     

营养成分对Fe2+生物氧化的影响

在29℃和160 r/min条件下,以广东云浮矿山酸性废水为种源,采用9K培养基,经过富集培养得到氧化亚铁硫杆菌A.f.a。利用分批摇床实验,研究了在A.f.a作用下,溶液初始NH4+-N、PO34--P、Mg2+、Ca2+和Cu2+等基本营养成分对Fe2+生物氧化的影响。结果显示,随着NH4+-N、PO34--P、Ca2+或Cu2+离子浓度增加,Fe2+生物氧化率都先增大后降低,各离子最佳浓度分别为84.8、35.6、2.4和254.5 mg/L;Fe2+生物氧化率随着Mg2+浓度的增加逐渐增大,并趋于稳定,其限制浓度为88.8 mg/L。上述结果可用于控制营养条件促进Fe2+的生物氧化。     

Dynamics of nitrogen in a PAHs contaminated soil amended with biosolid or vermicompost in the presence of earthworms

Nitrogen mineralization in PAHs contaminated soil in presence of Eisenia fetida amended with biosolid or vermicompost was investigated. Sterilized and unsterilized soil was contaminated with PAHs, added with E. fetida and biosolid or vermicompost and incubated aerobically for 70 days, while dynamics of inorganic N were monitored. Addition of E. fetida to sterilized soil increased concentration of NH(4)(+) 100> mg N kg(-1), while concentrations in unsterilized remained <60 mg N kg(-1) except for soil amended with biosolid plus PAHs where it increased to >80 mg kg(-1). Addition of PAHs had no significant effect on concentration of NH(4)(+) compared to the unamended soil, except in the soil added with biosolid. Addition of E. fetida to sterilized soil increased concentration of NO(2)(-) 15> mg N kg(-1) while concentrations in unsterilized soil remained <7.5 mg N kg(-1) except for soil amended with biosolid where it increased to >20 mg kg(-1). Addition of PAHs had no significant effect on concentration of NO(2)(-) compared to the unamended soil. Addition of biosolid and vermicompost increased concentration of NO(3)(-), while addition of E. fetida decreased concentration of NO(3)(-) in biosolid amended soil. It was found that NH(4)(+) and NO(2)(-) oxidizers were present in the gut of E. fetida, but their activity was not sufficient enough to inhibit a temporarily increase in concentrations of NH(4)(+) and NO(2)(-). Contamination with PAHs induced immobilization of N in biosolid or vermicompost amended soil, as did feeding of E. fetida on biosolid or vermicompost.     

Effect of recycle-to-influent ratio on activities of nitrifiers and denitrifiers in a combined UASB-activated sludge reactor system

A laboratory study using a combined upflow anaerobic sludge bed (UASB)-activated sludge (AS) reactor system was undertaken to explore the effect of recycle-to-influent ratio (R(e)=1, 2, and 3) on the activities of nitrifiers and denitrifiers. Suspended-solids pre-settled piggery wastewater was used as the substrate-feed wastewater. At the R(e) of 1-3, the combined reactor system achieved efficient removal of COD (96-97%), TKN (100%) and total nitrogen TN (54-77%). Methanogenesis occurred with nearly-complete denitrification in the UASB reactor, whereas complete nitrification took place in the AS reactor. A higher R(e) (i.e., accompanied with a shorter solids retention time) resulted in a larger amount of high-activity denitrifiers and thereby achieved a higher TN removal efficiency. Compact granules and a high biomass concentration in the UASB reactor were observed. At the R(e) of 1-3, the maximum specific reaction rate of nitrifiers (0.45-0.49 NH(4)(+)-NmgVSS(-1)d(-1)) and the specific nitrification rates of mixed culture (0.18-0.22mg NH(4)(+)-NmgVSS(-1)d(-1)) in the AS reactor varied slightly; whereas the maximum specific reaction rate of denitrifiers (0.18-0.27mg NO(x)(-)-NmgVSS(-1)d(-1)) and the specific denitrification and COD removal rates of mixed culture (0.025-0.050mg NO(x)(-)-NmgVSS(-1)d(-1); 0.24-0.31mgCODmgVSS(-1)d(-1)) in the UASB reactor increased with increasing R(e). The primary finding of the study is that the combined UASB-AS reactor system should be operated at a higher R(e) to maintain high-activity denitrifiers to remove organic materials and nitrogen from piggery wastewater.