金属加工含磷废水的处理及水回用研究

以某金属加工企业废水为研究对象,考察了含磷废水回用工艺,即钙盐除磷和过滤的工艺条件,结果表明,废水p H调至10.0~10.5,Ca Cl2投加浓度为700~800 mg/L,PAC投加浓度为150~200 mg/L,除磷系统沉淀出水TP=3~5 mg/L,去除率可达95%,同时去除了废水中少量的重金属离子。沉淀池出水经过砂滤和炭滤后TP3 mg/L,Zn2+1 mg/L,Ni2+0.8 mg/L,水质优于回用水指标直接回用,减少了排放。     

膜生物反应器联合工艺处理合成制药废水的中试

采用混凝沉淀+砂滤+膜生物反应器+活性碳+臭氧工艺处理合成制药废水中COD中试研究。结果表明膜生物反应器出水的COD平均值为78.6mg/L,去除率为74.3%;最终出水的COD平均值为40.4mg/L,去除率为92.7%。     

UBF-物理化学组合工艺处理Zn5-ASA医药废水的研究

采用砂滤－UBF厌氧－絮凝沉淀工艺处理高浓度Zn5-ASA医药废水。实验结果表明，对于COD为8000－10000mg/L，色度7000－9000倍的Zn5-ASA废水，加石灰乳和H2SO4预调，经砂滤柱过滤后，COD会去除20％左右；再进以聚丙烯环为填料的厌氧UBF反应器，HRT为10.57h，COD去除率达83％－89％；出水再经化学絮凝沉淀后，无色透明，COD浓度远小于1000mg/L，符合GB8978－96三级排放标准要求，且色度小于10倍。     

生化与臭氧生物炭组合工艺处理反渗透膜生产废水的研究

本研究通过模拟反渗透膜生产废水水质,在实验室条件下采用生化与臭氧/生物炭组合工艺处理该含DMF的废水。实验结果显示在模拟废水COD浓度为12500 mg/L的情况下,生化出水COD稳定在2500mg/L左右,COD去除率达到85%左右。含DMF的废水在60℃的条件下,通过投加Na OH至p H=13碱解对含有DMF的废水预处理之后,使混合废水COD下降至6000mg/L左右,生化出水COD在600mg/L以下,去除率高达90%,再通过臭氧/生物炭深度处理去除COD、色度、SS等,最终出水满足污水综合排放标准GB 8978-1996中的一级排放标准。     

EGSB-CAAS工艺处理茶多酚废水的工业化研究

应用“EGSB－CAAS”工艺处理茶多酚废水的工业化研究表明，当进水COD为36960－43182mg/L、SS为6562－10904mg/L时，经混凝气浮预处理后，采用“EGSB－CAAS”工艺进行处理，系统COD和SS去除率达99％以上，出水可达标排放。     

厌氧-好氧联合法处理豆沙废水的研究

为了有效的对高COD、高悬浮物的豆沙废水进行处理,本实验中选用气浮-厌氧-曝气生物滤池为主体处理工艺对其进行处理。实验结果表明:在进水水质COD为20 000 mg/L,SS为1 500 mg/L的条件下,通过本工艺,出水水质COD降为283 mg/L,SS为200 mg/L,去除率分别为98.58%和86.67%,出水水质完全达到(CJ 3082-1999)《污水排入城市下水道水质标准》。说明:本处理工艺能够对豆沙废水进行有效处理,有望成为豆沙废水处理的主流方法。     

水解酸化+两级生物接触氧化处理高盐度水产品加工废水

介绍了“水解酸化+两级生物接触氧化”处理水产品加工废水的运行效果和工程实例,结果表明:对C l-浓度平均6000mg/L的高盐度水产品加工废水,系统对COD、SS、氨氮的去除率分别超过了88%、90%、85%,出水COD、SS、氨氮分别低于100mg/L、70mg/L、15mg/L,出水完全可以达到《污水综合排放标准》(GB8978-1996)一级排放标准。     

Fenton反应-中和-厌氧生物法处理某高盐度工业废水

实验采用Fenton反应-中和-厌氧菌法处理某高盐度工业废水,考察了各因素对COD去除率的影响。实验结果表明,Fenton反应处理该工业废水的最佳条件是:n(H2O2):n(COD)=2:1,n(H2O2):n(Fe2+)=4:1,pH=3,反应时间采用120 min。Fenton处理后废水COD由24 230 mg/L下降到13 020 mg/L,去除率达到46.26%;所得反应液用Ca(OH)2中和沉淀后COD值降低到11 060 mg/L,去除率为15.05%;最后废水经稀释后进行厌氧菌降解处理,COD为1 625 mg/L的废水经厌氧菌6天处理后降为466 mg/L,去除率为71.32%,达到GB8978-1996中规定的COD三级排放标准。     

蕉藕淀粉废水絮凝试验

试验采用化学混凝法对蕉藕淀粉加工产生的废水进行处理,研究了硫酸铝,氯化铁,聚合硫酸铁(PSF),聚合氯化铝(PAC),聚丙烯酰胺(PAM)等不同混凝剂种类和投加量对COD、SS和TP去除效果的影响。试验结果表明,聚合氯化铝处理效果最佳,在废水COD、SS和TP的浓度分别为8340mg/L、7060mg/L和320mg/L时聚合氯化铝以500mg/L的用量得到COD、SS和TP的去除率分别为97.1%、98.0%和70%,出水的COD为241mg/L,SS为142mg/L,TP为112mg/L。     

气浮-水解酸化-SBR工艺在屠宰废水处理中的应用研究

屠宰废水具有有机物含量高、可生化性较好等特点,因此生化处理是屠宰废水的主要工艺。某公司对屠宰废水采用"气浮-水解酸化-SBR"工艺进行处理,废水处理结果表明,当废水进水SS、COD cr、BOD5、NH3-N平均浓度分别为580 mg/L、1 900 mg/L、1 140 mg/L、54 mg/L时,出水SS、COD cr、BOD5、NH3-N平均浓度分别为45 mg/L、55 mg/L、15 mg/L、10 mg/L,出水水质指标满足《肉类加工工业水污染物排放标准》(GB 13457-92)的一级排放标准要求,废水中SS、COD cr、BOD5、NH3-N平均去除率分别为92%、97%、98.5%、72%。     

Effects of two sludge application on fractionation and phytotoxicity of zinc and copper in the soil

The potential harm of heavy metals is a primary concern in application of sludge to the agricultural land. A pot experiment was conducted to evaluate the effect of two sludges on fractionation of Zn and Cu in soil and their phytotoxicity to pakchoi. The loamy soil was mixed with 0%, 20%, 40%, 60% and 80% (by weight) of digested sewage sludge (SS) and composted sludge (SC). The additions of both sludges caused a significant raise in all fractions, resulting in that exchangeable (EXCH) and organic bound (OM) became predominance of Zn and organic bound Cu occupied the largest portion. There was more available amount of Zn and Cu in SS treatments than SC treatments. During the pot experiment, the concentration of Zn in EXCH, carbonate (CAR) and OM and Cu in EXCH and OM fractions decreased in all treatments, so their bioavailability reduced. Germination rate and plant biomass decreased when the addition rate was high and the best yield appeared in 20% mixtures at the harvest of pakchoi. The two sludges increased tissue contents of Zn and Cu especially in the SS treatments. Zn in pakchoi was not only in relationship to ΔEXCH and ΔCAR forms but also in ΔOM forms in the sludge-soil mixtures. Tissue content of Cu in pakchoi grown on SC-soils could not be predicted by ΔEXCH. These correlation rates between Zn and Cu accumulation in pakchoi and variation of different fractions increased with time, which might indicate that sludges represented stronger impacts on the plant in long-term land application.     

Intraspecific differences in effects of co-contamination of cadmium and

A hydroponic experiment was carried out to study intraspecific differences in the effects of different concentrations of cadmium (Cd)(0-10 mg/L) and arsenate (As(V)) (0-8 mg/L) on the growth parameters and accumulation of Cd and As in six wheat varieties Jing-9428, Duokang-1, Jingdong-11, Jing-411, Jingdong-8 and Zhongmai-8. The endpoints of wheat seedlings, including seed germination,biomass, root length and shoot height, decreased with increasing the Cd and As concentrations. Significant differences in seed germination, biomass, root length, shoot height and the accumulation of Cd and As were observed between the treatments and among the varieties (p ＜ 0.05). The lethal dosage 50% were about 20, 80, 60, 60, 80 and 20 mg As/L for Jing-9428, Duokang-1, Jingdong-11,Jing-411, Jingdong-8 and Zhongmai-8, respectively, and the corresponding values for Cd were about 30, 80, 20, 40, 60 and 10 mg Cd/L, respectively. Among the six varieties, Duokang-1 was found to be the most resistant to Cd and As toxicity, and Zhongmai-8 was the most sensitive to Cd and As co-contamination. The resistance of the six varieties was found dependant on the seedling uptake of Cd and As. Duokang-1 was the most suitable for cultivation in Cd and As co-contaminated soils.     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

Effect of sorbed and desorbed Zn(Ⅱ) on the growth of a green alga (Chlorella pyrenoidosa)

Toxic effect of Zn(Ⅱ) on a green alga (Chlorella pyrenoidasa) in the presence of sepiolite and kaolinite was investigated.The Zn-free clays were found to have a negative impact on the growth of C.pyrenoidosa in comparison with control samples (without adding any clay or Zn(Ⅱ)).When Zn(Ⅱ) was added,the algae in the presence of clays could be better survived than the control samples,which was actually caused by a decrease in Zn(Ⅱ) concentration in the solution owing to the adsorption of Zn(Ⅱ) on the clays.When the solution system was diluted,the growth of algae could be further inhibited as compared to that in a system which had the same initial Zn(Ⅱ) concentration as in the diluted system.This in fact resulted from desorption of Zn(Ⅱ) from the zinc-contaminated clays,although the effect varied according to the different desorption capabilities of sepiolite and kaolinite.Therefore the adsorption and desorption processes of Zn(Ⅱ) played an important part in its toxicity,and adsorption and desorption of pollutants on soils/sediments should be well considered in natural eco-environmental systems before their risk of toxicity to aquatic organisms was assessed objectively.