中小型燃用烟煤层燃炉NO_x排放特征分析

以86台中小型燃烟煤层燃炉(≤65 MW)的燃料特性分析数据和NOx排放实测数据为基础,通过统计分析方法,研究了锅炉出力、过量空气系数、燃煤挥发分、燃煤氮含量对NOx排放浓度的影响,分析了我国中小型燃烟煤层燃炉NOx的排放与管理控制现状。结果表明,中小型燃用烟煤层燃炉NOx平均排放浓度为324.6 mg/m3;锅炉出力对NOx排放浓度不具有显著影响;燃煤挥发分增高,NOx排放浓度降低;过量空气系数和燃煤氮含量增大,NOx排放浓度增高;并建议在国家层面上尽快制订燃煤锅炉NOx排放标准限值。     

中小型燃用烟煤层燃炉NOx排放特征分析

以86台中小型燃烟煤层燃炉（≤65 MW）的燃料特性分析数据和NOx排放实测数据为基础,通过统计分析方法,研究了锅炉出力、过量空气系数、燃煤挥发分、燃煤氮含量对NOx排放浓度的影响,分析了我国中小型燃烟煤层燃炉NOx的排放与管理控制现状。结果表明,中小型燃用烟煤层燃炉NOx平均排放浓度为324.6 mg/m^3;锅炉出力对NOx排放浓度不具有显著影响;燃煤挥发分增高,NOx排放浓度降低;过量空气系数和燃煤氮含量增大,NOx排放浓度增高;并建议在国家层面上尽快制订燃煤锅炉NOx排放标准限值。     

我国氮氧化物排放因子的修正和排放量计算:2000年

根据我国城市的发展状况 ,采用城市分类的方法 ,将我国 2 6 1个地级市按照人口数量分为 5个类别。每类城市选取一个典型城市进行实地调查 ,对我国燃烧锅炉和机动车的NOx 的排放因子进行了修正 ,提出了适合我国目前排放水平的各类城市的固定源和移动源的排放因子。并依据 2 0 0 0年中国大陆地区的电站锅炉、工业锅炉和民用炉具的燃料消耗量和机动车保有量 ,以地级市为基本单位 ,估算了 2 0 0 0年我国各地区的NOx 排放量 ,分析了分地区、分行业、分燃料类型的NOx 排放特征。 2 0 0 0年我国NOx 排放总量为 11.12Mt,其中固定源占 6 0 .8% ;移动源占 39.2 %。NOx 排放在地域、行业和燃料类型上分布均不平衡。NOx 的排放主要集中在华东和华北地区 ,其排放量占全国排放量的一半以上。燃煤为最重要的NOx 排放源 ,其排放量占燃料型NOx 排放量的 72 .3%左右。     

中国山东电网燃煤锅炉NOx排放状况和治理技术试验研究

通过对山东电网所属发电厂锅炉NOx排放状况进行调查、测试，得出锅炉NOx排放量与煤种、炉型、燃烧器型式、运行中空气过剩系数、负荷等的关系。结果表明，山东省火力发电厂50MW及以上容量机组2003年的NOx排放总量超过40万t（按NO2计算）。控制和治理NOx排放已成为刻不容缓的重要工作。     

秸秆成型燃料锅炉污染物排放规律试验研究

根据锅炉烟尘测试方法(GB 5468-91)及锅炉大气污染物排放标准(GB 13271-2001),在不同风门的工况下,分别对设计的双层炉排秸秆成型燃料锅炉污染物排放规律进行试验.试验表明,在较好工况下,双层炉排锅炉排烟中CO等中间产物及烟尘含量低于单层炉排锅炉,其排烟中CO、NOx、SO2和烟尘浓度等指标远远低于燃煤锅炉,符合国家关于工业锅炉大气污染物排放标准要求,有较好环保效益.     

燃煤锅炉烟气NOx污染等离子体治理技术

燃煤锅炉烟气NOx污染治理技术种类较多.本文综合评述了各种烟气NOx污染等离子体治理技术,重点介绍了电晕放电脱除烟气中NOx的最新研究成果.对燃煤锅炉烟气NOx污染治理技术的研究和开发具有实用价值.     

电厂NOx控制政策与技术:美国的经验及对我国的启示

我国NOx排放的快速增长导致其环境和生态影响日益加剧,已经引起全球关注,但是现行的NOx污染控制技术和政策远远落后于实际需求.为减少酸雨、臭氧和颗粒物带来的环境问题,美国采取排放控制和排污交易等方式削减了燃煤电厂的NOx排放.系统分析了美国NOx污染控制法规、标准、规划和控制技术应用情况,总结了其NOx控制的成功经验,...     

小型燃油锅炉大气污染物的排放管理控制

燃料燃烧过程是大气污染物的重要来源之一,对人体健康,空气质量和气候变化具有非常重要的影响;管理控制是控制污染物排放的重要手段.以85台小型燃油锅炉(≤10.5 MW)燃料特性分析数据和污染物排放实测数据为基础,通过统计分析方法,分析了中国在用燃油品质以及大气污染物的排放现状,讨论了小型燃油锅炉大气污染物排放管理控制的潜力与可行性.结果表明,对燃油品质的管理控制是有效控制燃烧过程大气污染物排放的重要措施,分别有95%和98%燃油的灰分和含硫量符合国家相关规定;所有测试锅炉PM排放浓度远低于<锅炉大气污染物排放标准>(GB/T 13271-2001)规定的最高允许排放限值,有90%以上的锅炉达到GB/T 13271～2001中SO2最高允许排放限值,有84%的锅炉达到GB/T 13271-2001中NOx最高允许排放限值;与其他国家相比,中国对小型燃油锅炉常规大气污染物排放的管理控制处于中等水平,应当适时开展对有害空气污染物的管理控制.     

柴油机排放碳颗粒物和NOx催化净化技术的研究进展

本文从柴油机排放的特点、柴油机排放的标准、柴油机排放碳颗粒物和NOx催化净化技术等方面进行了综述与探讨,就柴油机排放碳颗粒物和NOx催化净化技术的研究提出了一些建议和设想.     

不同规模火电机组排污负荷实测分析

通过对不同规模火电机组污染物排放实测,对各种规模机组的排污负荷进行了分析.实测结果显示,1 000 MW机组平均烟尘排放负荷为0.013 g/(kW·h),平均SO2排放负荷0.142 g/(kW·h),平均NOx排放负荷0.254 g/(kW·h),分别为130MW机组的5.58％、15.45％、9.12％.说明通过采取机组规模以大代小和技术改革后,火电机组单位发电量排放的烟尘、SO2、NOx显著下降.中国火电机组SO2排放水平可满足先进国家排放要求,而600MW及以下规模机组的NOx排放水平与先进国家存在差距,应对600MW及以下规模机组采取进一步脱硝措施.     

小型燃油锅炉NO_x的排放特征与管理控制

以68台燃油锅炉(≤10.5 MW)NO_x排放实测数据为基础,通过统计分析方法,研究了NO_x的排放特征;通过对比分析,探讨了我国燃油锅炉NO_x排放控制与管理现状,讨论了进一步加强我国燃油锅炉NO_x排放管理控制的可能性与可行性,并提出了相应的管理控制建议。结果表明,NO_x平均排放浓度为318.2 mg/m~3,基于燃料消耗量的平均排放因子为4.4 kg/t,基于燃料发热量的平均排放因子为102.8 ng/J,基于燃料氮含量的平均排放因子为2.1 mg/mg;建议采取分阶段控制的方式,逐步提高NO_x排放限制,从而实现控源减排目标。     

Nitrogen oxides emission control options for coal-fired electric utility boilers

Recent regulations have required reductions in emissions of nitrogen oxides (NOx) from electric utility boilers. To comply with these regulatory requirements, it is increasingly important to implement state-of-the-art NOx control technologies on coal-fired utility boilers. This paper reviews NOx control options for these boilers. It discusses the established commercial primary and secondary control technologies and examines what is being done to use them more effectively. Furthermore, the paper discusses recent developments in NOx controls. The popular primary control technologies in use in the United States are low-NOx burners and overfire air. Data reflect that average NOx reductions for specific primary controls have ranged from 35% to 63% from 1995 emissions levels. The secondary NOx control technologies applied on U.S. coal-fired utility boilers include reburning, selective noncatalytic reduction (SNCR), and selective catalytic reduction (SCR). Thirty-six U.S. coal-fired utility boilers have installed SNCR, and reported NOx reductions achieved at these applications ranged from 15% to 66%. Recently, SCR has been installed at >150 U.S. coal-fired utility boilers. Data on the performance of 20 SCR systems operating in the United States with low-NOx emissions reflect that in 2003, these units achieved NOx emission rates between 0.04 and 0.07 lb/10(6) Btu.     

Nitrogen Oxide Emissions of Boilers in Finland

This article discusses nitrogen oxide emissions from various types of boilers in Finland. The boilers have been classified into 61 classes according to their size, combustion technique, and main fuel. A specific emission coefficient (ng NO₂/J = mg NO₂/MJ) for each class has been determined, based on literature surveys and actual measurements. The total NO_X emission has been calculated for each class, using the emission coefficient and energy statistics. The effect of various techniques for emission reduction has also been investigated. The development of NO_X emissions has been estimated for both the case where no preventing actions have been taken and for four defined cases where alternative reduction measures are assumed

The total NO_X emission from energy production in Finland was 107,000 tons NO₂ in 1987. Seventy-five percent of this amount originated in boilers larger than 1 MWfuel effect (input effect), and the rest in smaller boilers and industrial processes. The most important boiler classes from the NO_X emission’s point of view were coal-fired boilers, with an emission of approximately 38,000 tons NO₂, peat-fired boilers and boilers fired with a mixture of fuels, emitting approximately 12,000 tons NO₂ each.

By 2005, the total NO_X emission from energy production would increase 50 percent to approximately 160,000 tons if left uncontrolled. The emission level would be 140,000 tons if primary reduction techniques are applied, and 110,000 tons NO₂, if catalytic NO_X reduction devices are installed in boilers larger than 300 MW.     

北京市燃煤的空气质量影响及其控制研究

建立了2005年北京市燃煤污染源排放清单,利用MM5-CMAQ模型计算了各区县各行业燃煤对北京市空气质量的影响。研究表明,2005年1月北京市燃煤源对各监测站点SO_2浓度的贡献在70%以上,对PM_(10)和NO_x浓度的贡献约为20%～40%和10%～30%;7月本地燃煤源对SO_2浓度的贡献在40%～50%左右。1月采暖锅炉对空气质量影响最大,占50%～70%;7月电厂的影响最大。依据北京市奥运空气质量保障方案以及"十一五"期间能源规划,建立了2010年燃煤污染源大气排放的规划情景,并模拟了各规划措施对大气质量的改善效果。通过实施电厂脱硫脱硝除尘、炼焦工业停产、钢铁行业和水泥行业搬迁减产、供热锅炉改造、平房用煤改造等措施,与2005年相比,SO_2平均浓度下降30%左右,NO_x和PM_(10)浓度的下降幅度15%。     

Analysis of Industrial Boiler Solid Waste Impacts

This paper presents an examination of industrial coal-fired boiler waste products. Presently the atmospheric emissions from all new boilers larger than 250 × 10⁶ Btu/hr are controlled by existing New Source Performance Standards, and boilers smaller than 250 × 10⁶ Btu/hr are controlled to levels required by the regulations of the particular state in which the facility is located. The 1977 Clean Air Act Amendments, however, specify categories of sources for which EPA must develop revised New Source Performance Standards. Industrial coal-fired boilers are included as one of these categories, and a relevant issue concerns the potential amount of solid waste generated as a result of tightened emission standards that require flue gas desulfurization. This paper examines the air quality and solid waste impacts of moderate and stringent emission controls for particulate and SO₂ emissions from industrial coal-fired boilers.

Comparisons are presented of physical and chemical characterizations of the emissions and solid wastes produced when boilers are equipped with particulate and SO₂ control equipment. The SO₂ systems examined are lime spray drying, lime/limestone, double alkali, sodium throwaway, physically cleaned coal, and fluidized-bed combustion. The solid waste disposal alternatives and the disposal costs are discussed. The most common disposal methods used are landfill for dry wastes and impoundment for sludges, with special wastewater treatment requirements for the sodium throwaway aqueous wastes.     

Nitrogen Oxides Emission Control Options for Coal-Fired Electric Utility Boilers

Abstract

Recent regulations have required reductions in emissions of nitrogen oxides (NO_x) from electric utility boilers. To comply with these regulatory requirements, it is increasingly important to implement state-of-the-art NO_x control technologies on coal-fired utility boilers. This paper reviews NO_x control options for these boilers. It discusses the established commercial primary and secondary control technologies and examines what is being done to use them more effectively. Furthermore, the paper discusses recent developments in NO_x controls. The popular primary control technologies in use in the United States are low-NO_x burners and overfire air. Data reflect that average NO_x reductions for specific primary controls have ranged from 35% to 63% from 1995 emissions levels. The secondary NO_x control technologies applied on U.S. coal-fired utility boilers include reburning, selective noncatalytic reduction (SNCR), and selective catalytic reduction (SCR). Thirty-six U.S. coal-fired utility boilers have installed SNCR, and reported NO_x reductions achieved at these applications ranged from 15% to 66%. Recently, SCR has been installed at >150 U.S. coal-fired utility boilers. Data on the performance of 20 SCR systems operating in the United States with low-NO_x emissions reflect that in 2003, these units achieved NO_x emission rates between 0.04 and 0.07 lb/10⁶ Btu.     

Development of Federal Air Standards to Reduce Sulfur Dioxide Emissions from New Industrial Boilers

Federal new source performance standards to control air emissions of sulfur dioxide from new industrial boilers were proposed by EPA on June 19, 1986. These standards would require boiler owners to reduce SO₂ emissions by 90 percent and meet an emission limit of 1.2 lb/MM Btu of heat input for coal-fired boilers and 0.8 lb/MM Btu for oil-fired boilers. In developing these standards, several regulatory options were considered, from standards that could be met by firing low sulfur fuels to standards that would necessitate flue gas treatment. The environmental, economic, and cost impacts of each option were analyzed. National impacts were estimated by a computer model that projects the population of new boilers over the 5-year period following proposal, predicts the compliance strategy that will be used to comply with the particular option (always assuming that the lowest cost method of compliance will be selected), and estimates the resulting emission reductions and costs. Impacts on specific industries and on model boilers were also analyzed. This paper focuses on these analyses and their results. The Agency's conclusions from these analyses, which led to the decision to establish percent reduction standards, are provided, and the proposed SO₂ standards are summarized. The proposed standards also include an emission limit for particulate matter from oil-fired boilers (0.1 lb/MM Btu). However, this article focuses only on the SO₂ standards.     

循环流化床锅炉燃烧城市生活垃圾的研究进展

城市生活垃圾(MSW)产量的与日俱增及环保要求的不断提高,使循环流化床(CFB)燃烧技术逐渐在MSW的回收和利用方面扮演越来越重要的角色.简要分析了国内外采用分类回收及综合利用、卫生填埋、堆肥和一般焚烧方法处理MSW的不足之处以及采用CFB燃烧技术的优越性,重点介绍了国内外采用CFB燃烧装置焚烧MSW的研究和应用现状,指出了目前存在的问题及努力的方向.采用CFB燃烧装置焚烧MSW关于SO2、NOx、CO排放的实验研究和运行结果令人满意,但对HCl、二恶英及重金属排放还需要进一步研究.试验及实际运行结果都表明,采用CFB燃烧装置对MSW进行焚烧处理是切实可行的,它将是未来解决MSW问题的重要手段.