污水厂污泥堆肥及制作化肥技术研究与应用

利用污水处理厂脱水后的污泥，经粉煤灰水分调节后进人动态堆肥装置，好氧发酵成为性状良好的腐殖颗粒，然后经过一定工艺制成一种有机-无机复合化肥，其N、P、K含量达到25％，有机质含量大于30％，含水量小于10％，pH值6～8。将化肥用在农田的水稻种植，水稻的亩产量增产11．4％，各项指标均符合国家标准。     

酸性亚硫酸钙法制浆废水经自然氧化处理后在农业上的利用

本文介绍工业废水经处理后利用于农业生产上的一个较好的研究例子. 亚硫酸钙法制浆废水经田间试验、处理和分析,结果为:该废水(1)不利于水稻种子发芽、育苗,但含25%废水有利于水稻生长;(2)不施化肥时,用于水田有明显增产效果.施化肥时,以含25%废水灌溉产量最高.废水中COD、BOD分别应控制在350～400mg/l和70～90mg/l为宜;(3)有利于改善土壤;(4)稀释至25%浓度为最佳利用效果,农作物既不受毒害又不会使品质下降.     

碳酸钙和海泡石组配对水稻中Pb和Cd迁移转运的影响

为研究组配改良剂LS(碳酸钙+海泡石)对农田土壤重金属Pb和Cd的固化效果以及水稻各部位吸收累积Pb和Cd的影响,在湘南2个矿区(矿区A和矿区B)附近污染稻田中施用了不同添加量的LS(0、2、4和8 g/kg),并进行了水稻种植的田间实验。结果表明,(1)施用2~8 g/kg的LS能使矿区A和矿区B土壤pH值分别增加1.11~1.95和1.61~2.31个单位,能使矿区A和矿区B土壤中Pb和Cd的TCLP提取态含量分别降低18.6%~62.7%、15.7%~37.1%和38.6%~66.7%、0~76.6%。(2)LS能不同程度地降低水稻各部位重金属含量。矿区A糙米中Pb和Cd含量降低9.4%~35.6%、56.1%~66.8%;矿区B糙米中Pb含量降低14.4%~36.6%,而Cd含量变化不明显。(3)LS对水稻中Pb和Cd在各部位之间的转运系数均有不同程度的影响,其中Pb和Cd从茎叶到谷壳的转运系数最大,说明水稻茎叶对重金属的转运能力最强。(4)LS添加量为8 g/kg时,Pb和Cd从谷壳到糙米的转运系数最小,且糙米中Pb和Cd含量最低。     

水旱轮作原位钝化削减技术修复土壤镉污染

为筛选适用于西南地区水旱轮作土壤Cd污染的修复技术,采用水稻-油菜轮作模式和原位钝化实验相结合的方式,比较了施用石灰、生物炭和羟基磷灰石(HAP)3种常见修复剂对土壤基本理化性质、作物产量及籽粒吸收积累镉的影响。结果表明:3种处理均能显著提高土壤pH,与CK相比,使用石灰、生物炭和HAP后,水稻收获期土壤pH分别提高了1.18、 0.51和0.91个单位,油菜收获期土壤pH分别提升了0.29、0.81和0.63个单位,但在油菜收获期施用石灰和HAP处理的土壤pH出现明显回落,降幅为0.91个和0.30个单位,施用生物炭处理的土壤pH则进一步提高了0.28个单位;3种处理在水稻收获期均能提高土壤有机质含量,其中生物炭效果最佳;3种处理均能显著降低水稻收获期土壤有效Cd含量,与CK处理相比,分别降低了21.84%、34.08%和20.12%,但在油菜收获期施用石灰和HAP处理的土壤有效Cd含量较相同处理在水稻收获期时有所回升,而生物炭则进一步降低了41.76%;石灰、生物炭和HAP处理对作物产量影响不大,但与CK处理相比,稻米中Cd含量分别降低了30.00%、43.33%和38.00%,油菜籽中Cd含量分别降低了21.00%、53.57%和55.90%,施用生物炭和HAP处理效果较佳。综上所述,生物炭修复水旱轮作模式下农田Cd污染效果最佳。     

重庆市郊稻米Cd风险的原位钝化削减

为筛选适合应用于重庆市郊区稻田土壤及农作物Cd污染的修复技术,采用田间小区原位钝化实验和重金属来源加密监测相结合的方法,比较了石灰、腐殖酸、硅酸钾3种常见修复剂对Cd污染稻田的土壤基本理化性质、水稻各部位Cd富集量、稻米产量和稻米品质的影响。结果表明,该区域土壤Cd污染的主要原因为该区域土壤Cd本底值含量高且土壤酸化严重。在土壤全Cd为0.66 mg·kg~(-1),有效Cd为0.39 mg·kg~(-1)的污染程度下,施用3种修复剂均可显著降低土壤有效Cd和稻米中Cd含量。其中,施用腐殖酸可显著提高土壤有机质含量,收获期种植2种水稻的土壤中有效Cd含量比CK处理分别减少了32.1%和34.8%,稻米中Cd含量比CK处理分别较少了53.3%和48.2%,同时低于国家食品污染物限量标准0.2 mg·kg~(-1),其作用机理主要通过提高土壤有机质含量,降低水稻根系对土壤中Cd的富集量及向茎叶部Cd的运输量。同时,相比于其他修复剂,施加腐殖酸可降低稻米直链淀粉含量,提升稻米品质,但会降低稻米产量。施用石灰可显著提高土壤pH和稻米产量,但水稻收割后稻米中Cd含量高于腐殖酸处理,低于硅酸钾处理。     

生物炭基调理剂对水稻镉吸收的影响

以木质生物炭为基础,与沸石、石灰石、磷酸钙等混配制生物炭基调理剂,并用于镉污染稻田。通过田间水稻栽培实验,探讨该生物炭基调理剂的合适配比及应用效果。按照DTPA浸提法分析土壤中有效态镉含量,按HNO_3-HCLO_4消化法测定水稻植株中镉的含量。结果表明:随木炭用量增加,土壤中有效态镉减少,施用0.48 kg·m~(-2)木炭时降幅高达23.87%。施用不同配比炭基调理剂实验中,木炭:石灰石:沸石:磷酸钙=4:1:1:1时对土壤中有效态镉的钝化效果最好,达到36.42%。水稻根、茎累积镉量高于叶、壳、糙米,并且稻米中镉含量与栽培后期50 d土壤中有效态镉含量高度相关,相关系数为0.921 6(P0.05)。     

5种浮床植物对宁夏引黄灌区稻田退水中氮磷的去除效果

为了探索植物浮床技术应用和农业面源污染防治的有效措施,采用稻田退水沟渠原位实验,研究了美人蕉(Canna indica)、千屈菜(Lythrum salicaria)、黄菖蒲(Iris pseudacorus)、空心菜(Ipomoea aquatica)、水稻(Oryza sativa)5种不同浮床植物对退水中氮、磷的去除效果。结果表明,在稻田退水中生长4个月后,5种浮床植物生物量均大幅度增加。其中,美人蕉生物增长量最大,为97.2 g·株~(-1),其次为千屈菜达到81.3 g·株~(-1);空心菜成活率最高,达到91.67%,美人蕉其次,为87.50%,而水稻成活率最低,仅为60.71%;千屈菜茎叶和根系的氮含量最高,分别达到0.85%和0.65%;美人蕉茎叶、根系的磷含量最高,分别达到0.15%、0.17%;空心菜氮吸收量最高,达到14 239.46 mg·m~(-2),美人蕉其次,为10 798.00 mg·m~(-2);水稻磷吸收量最高,达到407.11 mg·m~(-2),空心菜其次,为374.41 mg·m~(-2);空心菜对稻田退水中总氮(TN)去除率最高,达到85.88%,其次为美人蕉,为81.67%;空心菜总磷(TP)去除率最高,达到80.32%,其次为水稻,达到72.86%。根据上述实验结果,推荐浮床空心菜和美人蕉作为宁夏引黄灌区农田排水沟水质改善的主要植物。     

Cu-Cd、Zn-Cd、Cu-Zn复合污染对水稻毒性和重金属吸收的影响

以"中花11号"水稻品种为研究对象,通过溶液培养探讨了不同浓度配比的Cu-Cd、Zn-Cd、Cu-Zn对水稻根相对伸长毒性及元素吸收的影响。结果表明,Cu、Cd、Zn浓度与水稻相对根伸长均符合剂量效应关系,3种金属离子对水稻毒性次序为CuCdZn;在重金属总量为50%的毒性效应浓度(EC50)下,Cu-Cd对水稻毒性因浓度配比不同而表现不同的作用方式,而Zn-Cd、Cu-Zn对水稻毒性均表现出拮抗作用。在Cu-Cd复合处理下,Cd的加入促进了水稻对Cu的吸收,而Cu的加入对水稻幼苗的Cd吸收表现出不同作用;在Zn-Cd复合处理中,不同浓度Zn的加入均抑制Cd的吸收,使得水稻幼苗中Cd含量降低了9.1%~48.4%;Cu-Zn复合处理中,高浓度Cu的加入(EC40、EC30、EC25)抑制水稻对Zn的吸收。Zn-Cd拮抗作用主要和Zn抑制了水稻对Cd的吸收有关,而Cu-Zn的拮抗作用可能和高浓度的Cu抑制了Zn的吸收有关。     

水稻与棉花秸秆不同预处理厌氧发酵产沼气

以猪粪为接种物,以棉花秸秆和水稻秸秆为发酵原料,分别对秸秆进行稀碱法预处理和稀碱法与超声波联合预处理,在发酵温度为(37±1)℃的条件下进行厌氧发酵产沼气的研究。结果表明,以联合预处理的秸秆为发酵原料,厌氧发酵的各项指标均比以稀碱预处理秸秆发酵的效果好,其中累积产气量和沼气中甲烷含量分别提高35.23%和2.4%,发酵后TS、VS含量相对减少2.6%～10.94%,发酵液代谢产物中的有机酸丙酮酸、乙酸和柠檬酸含量相对减少23.9%～25.9%、20.24%～24.53%和41.08%～45.91%。     

5种钝化剂对镉砷污染稻田的田间修复效果对比

为选取费效比高的镉砷复合污染稻田土壤修复材料,比较了黏土矿物和调理剂不同投加组合对稻田土壤中镉砷的田间修复效果,并且针对种植水稻进行了修复效果的验证;研究了修复前后稻田土壤镉砷的有效形态变化、镉砷的形态分布变化、土壤理化性质变化、成熟期水稻产量和水稻各部分镉砷的含量。结果表明,修复100 d后,不同修复材料的二乙烯三胺五乙酸提取态Cd浓度与空白对照组相比均有明显下降;各修复材料均能提高土壤中Cd的残余态(RS)和As的有机结合态(OM)。修复材料处理后,土壤pH均有所提升,其他理化性质初期虽有所变化,但最终会恢复到空白对照组的水平附近;除1 kg·m~(-2)的膨润土处理外,其他材料处理后水稻干谷产量均有所提升;农田调理剂处理后水稻的可食用部分Cd含量最低,修复率达到72.0%。水稻的可食用部分As含量无显著差异,籽粒中Cd和As平均含量符合食用标准。调理剂在田间修复镉砷复合污染稻田土壤中有明显优势,黏土矿物仅适用于镉污染农稻田土壤的修复。     

污泥中重金属的去除及回收试验

论述了利用离子交换技术循环使用柠檬酸去除污泥中重金属,并置换回收重金属的适宜工艺条件.经柠檬酸处理后,污泥中90%以上的重金属被去除;柠檬酸处理液中的重金属用离子交换法回收,考察了树脂种类、流速、操作方式等因素对离子交换、再生效果的影响;在适宜工艺条件下,重金属的交换率均为100%,而洗脱率均接近90%;柠檬酸及离子交换树脂循环使用,重金属也得到回收,降低了处理成本.     

Influence of papermill sludge on growth of Medicago sativa, Festuca rubra and Agropyron trachycaulum in gold mine tailings: a greenhouse study

A greenhouse study was undertaken to determine the suitability of adding papermill sludge to neutral/alkaline gold mine tailings to improve the establishment of Festuca rubra, Agropyron trachycaulum and Medicago sativa. Festuca rubra root and shoot biomass and A. Trachycaulum shoot biomass were increased with papermill sludge amendment. The addition of papermill sludge and fertilizer drastically increased the shoot and root biomass of M. sativa (20-30 times) while A. trachycaulum and F. rubra showed a more moderate increase in growth. Photosynthetic pigment content of the leaves was higher in papermill sludge treatments than in the treatments without papermill sludge. The organic carbon content, macro-aggregate content and field capacity of the gold mine tailings were increased while the bulk density was decreased by the addition of papermill sludge. This study suggests that addition of papermill sludge and adequate fertilization can alleviate some of the adverse conditions of neutral/alkaline gold mine tailings.     

Uptake and distribution of rare earth elements in rice seeds cultured in fertilizer solution of rare earth elements

The uptake behavior of rare earth elements (REEs) under pot conditions using deionized water and a REE fertilizer solution as the culture media as well as the distribution of REEs in rice proteins were studied. The uptake of REEs in rice seeds increased dramatically after a lag period of approximately three days. Roots can accumulate a much higher content of REEs than germs and the resting seeds. The REE content in each water-soluble (albumin) and salt-soluble (globulin) component of the rice seeds accounted for 5-8% and 4-6% of the total REEs, respectively. However, there are less than 1.5% of the total REEs were found in the alcohol-soluble (prolamin) and acetic acid-soluble (glutelin) components. The high performance liquid chromatography (HPLC) in the gel permeation and the reserved-phase were used to monitor changes in the molecular weight distribution changes of the soluble proteins of rice seeds during germination after having been cultured in the same solution for seven days. No changes occurred in the prolamin, while a slight change occurred in the albumin, globulin and glutelin. Fractionation of the albumin of rice seeds cultured in a REE fertilizer solution on the Sephadex G-100 column indicated that REEs, especially Ce, La, Pr and Nd, were associated mainly with biological compounds of a molecular weight between 10,000 and 12,000.     

Prevention of struvite scaling in digesters combined with phosphorus removal and recovery--the FIX-Phos process

The fixation of phosphorus (FIX-Phos) combines struvite prevention and phosphorus recovery by the addition of calciumsilicatehydrate (CSH) particles into the anaerobic digester. The CSH fixates phosphorus as calcium phosphate and reduces the phosphorus concentration in the sludge water that allows for control of struvite formation. The phosphorus-containing recovery product can be separated and recovered from the digested sludge. In pilot plant experiments, 21% to 31% of phosphorus contained in digested sludge could be recovered when CSH was added at concentrations of 2 g/L to 3.5 g/L to a mixture of primary sludge and waste activated sludge (WAS) from enhanced biological phosphorus removal. The recovery product contained few heavy metals and a phosphorus content of 18 wt % P2O5, which allows for recycling as fertilizer. The fixation of phosphorus within the digester may increase wastewater sludge dewaterability. The phosphorus recycle stream to the headworks of the wastewater treatment plant is reduced.     

Persistence of polycyclic aromatic hydrocarbons (PAHs) in sewage sludge-amended soil

The application of sewage sludge as a fertilizer is a common method used to improve soil properties. However, sewage sludge may contain various organic pollutants including polycyclic aromatic hydrocarbons. In the present study, the persistence of PAHs in soils fertilized with different sewage sludge doses was compared in relation to the sewage sludge dose applied (30, 75, 150, 300 and 600 Mgha(-1)) and the content of the polycyclic aromatic hydrocarbons in them. The experiment was carried out in two blocks of experimental plots divided according to the type of plants grown: field plants and perennial-willow. Sewage sludge addition to soils resulted in an increase in the content of polycyclic aromatic hydrocarbons in these soils. This increase was proportional to the quantity of sewage sludge applied. The results obtained showed that during a 42/54-month period, more than half of the individual PAHs introduced into the soil with sewage sludge were degraded. The scope of dissipation depended on the sewage sludge dose and the use to which the area was put. In the experiment with the willow only in the case of the highest sludge dose was a decrease in the PAH content above 50% noted; whereas in the case of the experiment with the field plants, it was higher by 50% for all sewage sludge doses. In experiment with field plants the highest scope of individual PAH disappearance was observed in the soil with the sewage sludge dose amounting to 300 Mgha(-1). In experiment with willow a relatively high dissipation of individual PAHs (>50%) was found in the treatment with the highest sludge dose (600 Mgha(-1)). A wider PAH dissipation range in the experiment with field plants was conditioned by the more favourable conditions created as a result of the breeding treatments applied. Agrotechnical treatments clearly increased the disappearance of the PAHs in those soils fertilized with the lowest sewage sludge doses (30 and 75 Mgha(-1)). The results obtained showed that the preferred method of treating a light soil fertilised with sewage sludges should be a one-year system, with a sludge application of 75 Mgha(-1).     

添加不同钝化剂降低污泥堆肥的植物毒性研究

高温堆肥后污泥的土地利用可充分发挥资源化、无害化的优势，污泥土地利用防止重金属污染一直是污泥施用中最重要的问题。通过测验发芽率指数这一代表植物毒性的指标证明，通过在污泥堆肥中加入粉煤灰、磷矿粉和草炭等不同的改性剂或重金属钝化剂可大大降低堆肥的植物毒性，从而降低污泥中重金属的可利用性。     

提高生物法分离制革污泥中铬分离效率的研究

在已确定污泥驯化最佳条件的基础上，通过改变滤材、液固分离条件，添加营养物质继续降低pH等方法，进行提高生物沥滤法分离制革污泥中铬的分离效率的研究。同时考察化学沥滤法（1∶1硫酸）在相同条件下的分离效率。试验结果表明：用相应pH值酸液（1∶1硫酸配制）淋洗，淋洗+闷洗和抽真空＋酸液淋洗等过滤方式可提高铬的分离效率。生物沥滤中当pH值下降至1.8时，分离效率即可达到94.65%，与直接用蒸馏水淋洗相比要高得多。化学沥滤中当pH值下降到1时，分离效果可达96.7%，沥滤污泥中剩余铬含量可达到制革污泥农用标准。     

Co-cropping for phyto-separation of zinc and potassium from sewage sludge

The use of sewage sludge as a fertilizer and soil amendment has resulted in high concentrations of heavy metals in the soil limiting its use. The present study was carried out to find the possibility of phyto-separating toxic and beneficial elements from the sludge using suitable plants. Of the five plants tested the hyperaccumulator Sedum alfredii H achieved the greatest removal of Zn, while shoots of Alocasia marorrhiza accumulated high content of K. Co-cropping these two plants on the sludge verified the previous observations on A. marorrhiza and the shoots of this plant could accumulate more than 120 g K kg(-1) dry matter in the median growth stage. Zn hyperaccumulated in Sedum's shoots to an extent more than 10 g kg(-1) dry matter; K concentrated five to ten times in the Alocasia's shoots which could be used as a good organic-K-fertilizer. Hence, the two elements were simultaneously phytoseparated and could be recycled. Furthermore, cultivation of plants in the sludge resulted in significant decreases in total Zn but kept the favorable agronomic characteristics of the sludge material, such as pH, organic matter content, and NPK concentrations and ameliorated its biological stability. These results suggest that simultaneous phyto-separation of toxic and beneficial elements from sewage sludge are possible by co-cropping using specific plants without the input of any chemicals.     

Use and environmental implications of pulp-mill sludge as an organic fertilizer

Pulp-mill sludge is an industrial by-product with a high level of organic matter, which is eventually biodegradable. Since there are few alternatives for its practical use, its utilization as an agricultural fertilizer is proposed. An experiment was carried out during 2 years, with yellow lupin plants (Lupinus luteus L.), in order to define the critical application levels of this material. Biodegradability of the sludge in the soil was also evaluated, as well as its pollutant effects. Results obtained in the first year of the experiment showed that an application rate larger than 50 t ha(-1) of pulp-mill sludge, has a depressive effect on yield. Yet, this effect is completely dissipated in the second year. Finally, it is concluded that, if the use of this organic waste as an agricultural fertilizer is adequately monitored, soil pollution problems should not occur.