Ultrasound enhanced heterogeneous activation of peroxydisulfate by bimetallic Fe-Co/GAC catalyst for the degradation of Acid Orange 7 in water

Bimetallic Fe-Co/GAC （granular activated carbon） was prepared and used as heterogeneous catalyst in the ultrasound enhanced heterogeneous activation of peroxydisulfate （PS, S2O8 2-） process. The effect of initial pH, PS concentration, catalyst addition and stirring rate on the decolorization of Acid Orange 7 （AO7） was investigated. The results showed that the decolorization efficiency increased with an increase in PS concentration from 0.3 to 0.5 g/L and an increase in catalyst amount from 0.5 to 0.8 g/L. But further increase in PS concentration and catalyst addition would result in an unpronounced increase in decolorization efficiency. In the range of 300 to 900 r/min, stirring rate had little effect on AO7 decolorization. The catalyst stability was evaluated by measuring decolorization efficiency for four successive cycles.     

Evaluation of Bacillus sp. MZS10 for decolorizing Azure B dye and its decolorization mechanism

To evaluate decolorization and detoxification of Azure B dye by a newly isolated Bacillus sp. MZS10 strain, the cultivation medium and decolorization mechanism of the isolate were investigated. The decolorization was discovered to be dependent on cell density of the isolate and reached 93.55%(0.04 g/L) after 14 hr of cultivation in a 5 L stirred-tank fermenter at 2.0 g/L yeast extract and 6.0 g/L soluble starch and a small amount of mineral salts. The decolorization metabolites were identified with ultra performance liquid chromatography-tandem mass spectroscopy(UPLC-MS). A mechanism for decolorization of Azure B was proposed as follows: the C=N in Azure B was initially reduced to –NH by nicotinamide adenine dinucleotide phosphate(NADPH)-dependent quinone dehydrogenase, and then the –NH further combined with –OH derived from glucose to form a stable and colorless compound through a dehydration reaction. The phytotoxicity was evaluated for both Azure B and its related derivatives produced by Bacillus sp. MZS10 decolorization, indicating that the decolorization metabolites were less toxic than original dye. The decolorization efficiency and mechanism shown by Bacillus sp. MZS10 provided insight on its potential application for the bioremediation of the dye Azure B.     

交联壳聚糖-CdS颗粒可见光催化脱色甲基橙研究

利用壳聚糖对金属离子的配位络合作用和吸附性能,模拟生物矿化仿生制备交联壳聚糖/CdS复合粒子。以甲基橙为处理对象,氙灯模拟可见光,研究了该复合材料对甲基橙的降解脱色性能。用Langmuir-Hinshelwood方程从动力学的角度,考察了不同催化剂浓度、甲基橙的初始浓度、反应体系的pH值、外加无机阴离子等对甲基橙降解脱色的影响。结果表明,该复合材料的吸附性能和光催化活性产生的协同作用能较有效促进甲基橙染料的脱色,在低质量浓度条件下可见光催化过程为假一级反应。光催化剂的最佳用量为1.5g/L,甲基橙降解的最佳pH为4.0。Cl-和Br-均对MO的光催化脱色起抑制作用,而NO3-的添加明显促进MO的光催化速率。     

黄曲霉A5p1对偶氮染料的降解特性和降解途径

以黄曲霉菌株A5p1为生物材料,研究其脱色染料的广谱性,并选择偶氮染料直接蓝71（DB71）为模型底物,探讨脱色特性及降解产物.该菌株对15种染料的脱色测试结果表明,染料浓度为100mg/L时脱色效率为61.7%~100%.该菌对偶氮染料DB71具有生物吸附和生物降解的双重作用,在pH值7.0,温度30℃,染料浓度300mg/L,蔗糖为碳源时对DB71 脱色率为100%.酶分析显示葡萄糖氧化酶和锰过氧化物酶参与染料的降解.FTIR、GC-MS和LC-MS分析确定代谢终产物为萘胺、叠氮萘、2-羟基-6-草酰-苯甲酸和1-萘酚.     

Biodegradation of Crystal Violet by Agrobacterium radiobacter

Agrobacterium radiobacter MTCC 8161 completely decolorized the Crystal Violet with 8 hr (10 mg/L) at static anoxic conditions. The decreased decolorization capability by A. radiobacter was observed, when the Crystal Violet concentration was increased from 10 to 100 mg/L. Semi-synthetic medium containing 1% yeast extract and 0.1% NH4Cl has shown 100% decolorization of Crystal Violet within 5 hr. A complete degradation of Crystal Violet by A. radiobacter was observed up to 7 cycles of repeated addition (10 mg/L). When the effect of increasing inoculum concentration on decolorization of Crystal Violet (100 mg/L) was studied, maximum decolorization was observed with 15% inoculum concentration. A significant increase in the activities of laccase (184%) and aminopyrine N-demethylase (300%) in cells obtained after decolorization indicated the involvement of these enzymes in decolorization process. The intermediates formed during the degradation of Crystal Violet were analyzed by gas chromatography and mass spectroscopy (GC/MS). It was detected the presence of N,N,N′,N′′-tetramethylpararosaniline, [N; N-dimethylaminophenyl] [N-methylaminophenyl] benzophenone, N; N-dimethylaminobenzaldehyde, 4-methyl amino phenol and phenol. We proposed the hypothetical metabolic pathway of Crystal Violet biodegradation by A. radiobacter. Phytotoxicity and microbial toxicity study showed that Crystal Violet biodegradation metabolites were less toxic to bacteria (A. radiobacter, P. aurugenosa and A. vinelandii) contributing to soil fertility and for four kinds of plants (Sorghum bicolor, Vigna radiata, Lens culinaris and Triticum aestivum) which are most sensitive, fast growing and commonly used in Indian agriculture.     

Enterobacter sp. CV-v对甲基橙的脱色特性与条件优化

从浙江温州分离筛选到1株甲基橙高效脱色菌株CV-v,经16S rRNA基因序列分析表明,该菌株属于Enterobacter sp.属.单因素实验结果表明:当pH值在5.0~9.0之间时,培养48h以后,该菌株对甲基橙的脱色率均在80%以上;脱色的最适温度范围为30~40℃之间;所测碳源中的葡萄糖和麦芽糖、氮源中的牛肉膏和酵母粉对脱色的促进效果最为显著,且Ca2+和Mg2+也对脱色有显著的促进效应;此外,当接种量达到7%(V:V)以后,48h的脱色率即可达近100%.响应面设计实验结果显示,该菌株对甲基橙脱色的最优操作条件为:pH 8.0,葡萄糖1.7g/L,酵母粉3.0g/L,氯化镁3.0mmol/L及培养温度35.9℃.验证实验结果表明在最优条件下,该菌株在10h内对甲基橙的脱色率可达88.0%.总体而言,该菌株在偶氮染料脱色中的应用潜能较大.     

铁阳极电解脱色直接黄11染料模拟废水

研究采用铁为阳极电化学法处理直接黄11染料模拟废水脱色性能的影响进行研究。影响因素包括:电流密度、pH值、染料浓度和电解质浓度。研究结果表明,电流密度大有利于染料废水脱色,但能耗消耗大;初始溶液在中性条件下不仅取得很好的处理效果,而且脱色能耗较低;随着染料初始浓度增加脱色率和脱色能耗降低的趋势;随着电解质浓度升高染料脱色率下降的趋势,脱色能耗先减少,然后缓慢增大。在染料初始浓度50 mg/L、pH值为7.11、电流密度2.083 mA/cm2、电解质Na2SO4浓度0.01 mol/L、温度20℃、搅拌速度600 r/min、电解时间60min条件下,脱色率达到92.2%,脱色能耗1.709 kW.h/kg染料。     

碳纳米管活化过二硫酸盐降解偶氮染料酸性橙7

采用碳纳米管（CNT）活化过二硫酸盐（PS）降解偶氮染料酸性橙7（AO7）.考察了PS浓度、CNT投加量、初始pH值、温度等反应条件对AO7降解效果的影响.结果表明,当初始pH为7、n（PS）/n（AO7）为20、CNT投加量为0.2g/L时,AO7在反应480min后可以被完全脱色去除.随着PS剂量、CNT投加量和温度的升高,AO7的去除率也逐渐增加,中性条件下最有利于AO7的去除.AO7降解反应主要发生在CNT表面,且反应活化能Ea为46.76kJ/mol.通过紫外-可见分光光谱、气相色谱-质谱（GC-MS）和TOC分析表明,AO7分子偶氮键和萘环结构断裂,生成含苯环类物质,最终矿化为CO₂和H₂O.     

壳聚糖及其衍生物对染料废水的脱色研究

利用羧甲基壳聚糖(NOCC)复配聚丙烯酰胺(PAM)对3种水溶性染料模拟废水进行絮凝脱色处理,研究了溶液的酸度、絮凝剂与助凝剂的投加量等因素对脱色率的影响。实验结果表明,引入PAM作为助凝剂的脱色效果优于单纯使用羧甲基壳聚糖。处理此染料废水的最佳pH值为2.3,羧甲基壳聚糖的质量浓度为480mg/L,PAM投加量为4～8mg/L。在此优化条件下,复合絮凝剂对三种染料废水的脱色率为99%,COD去除率为90%;用壳聚糖/稀土复合膜处理染料废水时,对直接黑FF、还原红F3B染料废水的脱色率分别达到94.7%和98.2%,明显优于单纯壳聚糖膜。     

镁铝双氢氧化物用于染料废水脱色的研究

以氯化铝、氯化镁、氨水等为原料,合成了镁铝双氢氧化物正电溶胶(MADH).以水溶性染料模拟废水为研究对象,检验了MADH对染料废水的脱色效果,并对其脱色机理进行了探讨. 结果表明,MADH对活性染料、酸性染料和直接染料等阴离子型染料具有明显的脱色效果.在足量MADH存在的条件下,废水脱色率可达99%以上,最佳pH为6～9,最佳反应时间为10 min.温度升高不利于吸附过程的进行,其饱和吸附容量为327～2 113 mg/g.MADH用于实际印染工业废水处理,脱色率和CODCr去除率同样较高.脱色机理为MADH对染料的化学吸附作用.MADH对阳离子型染料的去除效果较差.      

PMS/Cl^-体系中橙黄Ⅱ脱色的影响因素和机理

为考察橙黄Ⅱ在单过硫酸盐(PMS)/Cl^-体系中的脱色过程和脱色机理,研究了初始pH值、PMS初始浓度、Cl^-初始浓度、反应温度等因素对橙黄Ⅱ在PMS/Cl^-体系中脱色效能的影响,通过自由基猝灭试验和活性氯浓度的检测,确定了不同pH值条件下PMS/Cl^-体系中的主要活性氧化物种。结果表明:橙黄Ⅱ在PMS/Cl^-体系中的脱色受pH值的影响;橙黄Ⅱ在该体系中的脱色过程符合准一级反应动力学方程,增加PMS和Cl^-的初始浓度均能提高橙黄Ⅱ在PMS/Cl^-体系中的脱色率;升高反应温度有利于橙黄Ⅱ的脱色;体系中橙黄Ⅱ脱色过程的主要活性物种随着pH值的变化而不同,在酸性条件下体系中橙黄Ⅱ的脱色主要通过活性氯(主要为HOCl)的氯化作用实现,在碱性条件下体系中橙黄Ⅱ的脱色主要由单线态氧(1O2)的氧化导致。该研究结果可为染料废水的治理提供新思路。     

Decolorization of Orange II using an anaerobic sequencing batch reactor with and without co-substrates

We investigated the decolorization of Orange II with and without the addition of co-substrates and nutrients under an anaerobic sequencing batch reactor (ASBR). The increase in COD concentrations from 900 to 1750 to 3730 mg/L in the system treating 100 mg/L of Orange II-containing wastewater enhanced color removal from 27% to 81% to 89%, respectively. In the absence of co-substrates and nutrients, more than 95% of decolorization was achieved by the acclimatized anaerobic microbes in the bioreactor treating 600 mg/L of Orange II. The decrease in mixed liquor suspended solids concentration by endogenous lysis of biomass preserved a high reducing environment in the ASBR, which was important for the reduction of the Orange II azo bond that caused decolorization. The maximum decolorization rate in the ASBR was approximately 0.17 g/hr in the absence of co-substrates and nutrients.     

FeS对CW-MFC系统降解活性艳红X-3B效果及过程的影响

在自行构建的人工湿地-微生物燃料电池(CW-MFC)系统中,以砾石填料为对照,研究了FeS对活性艳红X-3B脱色效果及降解过程的影响.结果表明,加在底层区域的FeS能够显著提高CW-MFC对活性艳红X-3B的脱色效果和系统产电性能.FeS的投加使得系统脱色率在进水活性艳红X-3B浓度200mg/L、葡萄糖浓度100mg/L条件下达到99.83%.在进水活性艳红X-3B浓度100mg/L、葡萄糖浓度200mg/L条件下,FeS组最大功率密度达到0.849W/m³.活性艳红X-3B在系统中的脱色主要发生在底层和阳极区域,由紫外-可见全波长扫描图谱和GC-MS扫描图谱可知FeS在该区域促进了偶氮双键的断裂,并有利于脱色产物苯胺、三嗪结构、萘环结构的进一步降解.     

醌介导染料脱色菌株的分离鉴定及特性

实验分离获得1株能够利用醌化合物使磺酸化偶氮染料脱色的菌株JL,通过形态特征、16S rDNA与16S-23S区间序列分析表明,该菌株为蜡状芽孢杆菌(命名为Bacillus cereus JL).菌株JL使酸性大红3R脱色的最佳条件为葡萄糖浓度1g/L, pH值为5~7,温度30℃,接种量0.25g/L.蒽醌-2-磺酸(AQS)、蒽醌-2,6-二磺酸(AQDS)和2-羟基-1,4-萘醌(Lawsone)均能显著提高酸性大红3R的脱色速率,其中AQS的促进作用最为明显.研究发现, 0.1mmol/L AQS能够使菌株JL对2.0mmol/L酸性大红3R保持较高的脱色速率,而且能使多种偶氮染料脱色,表现出较好的底物广谱性.利用高效液相色谱-质谱鉴定了AQS介导的酸性大红3R脱色产物,表明酸性大红3R的偶氮键发生断裂, AQS在这一过程中仅起到电子传递的作用.     

Decolorization of reactive Brilliant Blue KN-R by immobilized cells of Aspergillus ficuum

Aspergillus ficuum was immobilized with sodium alginate, and decolorization of Reactive Brilliant Blue KN-R was studied on immobilized and free Aspergillus ficuum. The optimal preparation condition of the strain immobilization was obtained by the orthogonal test, it is sodium alginate 3%, CaCl2 5%, wet mycelia 30 g/L, calcific time 8 h. It was found that the immobilized cells could effectively decolorize Reactive Brilliant Blue KN-R, the optimum temperature and pH were 33℃ and 5.0, respectively. The kinetics study of decolorization of immobilized cells showed that the decolorization of Aspergillus ficuum immobilized conformed to zero-order reaction model. The decolorization efficiency of immobilized cell compared with that of free cell in different physical conditions. Results showed that the decolorization of immobilized cells with mycelia had the best efficiency. The immobilized cells could be reused after the first decolorization.     

KIO_4光催化脱色甲基橙的研究

以KIO4为催化剂,对甲基橙进行了光催化脱色研究。结果表明甲基橙的脱色率随着催化剂量的增加而增加,但是没有一个最佳的量。当甲基橙浓度低于16mg/L时,反应为拟一级动力学反应,但是反应不符合Langmuir-Hinshewood动力学模型。脱色率在酸性条件下比碱性条件较高。高碘酸钾光催化脱色甲基橙的机理不完全是羟基自由基进攻。     

菌株WYT降解还原蓝4的关键基因

以印染厂活性污泥中筛选出的WYT菌株为研究对象,探索其对还原蓝4（VB4）染料降解脱色的关键基因.采用全基因组测序分析方法和同源重组法,确定染料代谢的可能关键基因.对该基因进行敲除,构建载体进行基因回补,设计表型验证实验验证基因的脱色效果.结果表明,该可能关键基因属于染料过氧化物酶基因中的B型,命名为DyP.敲除后的菌株对VB4没有脱色效果,基因敲除成功.WYT菌株与敲除载体发生双交换,获得回补株.在降解实验中,回补株对VB4的脱色率为96.04%,野生株的脱色率为96.95%,回补株恢复了对VB4的降解脱色能力,而敲除株几乎失去对VB4的降解能力,DyP基因是VB4降解脱色的关键基因.     

花状软锰矿的超声合成及其对亚甲基蓝的脱色性能

首次通过操作简便成本低廉的超声方法合成花状软锰矿(MWs).采用X射线衍射仪(XRD)、扫描电子显微镜(SEM)以及能量散布分析仪(EDS)等测试手段对其结构和形貌进行表征.研究了MWs对偶氮染料亚甲基蓝(MB)的脱色性能,考察pH值、反应时间、MWs投加量以及MB初始浓度等影响因子对脱色效果影响.结果表明,MWs对MB具有优良的脱色性能,90min达到近100%的脱色率,无需使用H2O2或者UV灯和超声等其它辅助设备,这明显优于其他催化剂,如Mn3O4/H2O2需3h达到99.7%最大脱色率、ZnS/CdS在光照下需6h最大脱色率仅为73%、硫改性的TiO2光照下需4h才能达到近100%的脱色率.     

Decolorization of Methyl Orange by a new clay-supported nanoscale zero-valent iron: Synergetic effect, efficiency optimization and mechanism

In this study, a novel nanoscale zero-valent iron (nZVI) composite material was successfully synthesized using a low-cost natural clay, “Hangjin 2^# clay” (HJ clay) as the support and tested for the decolorization of the azo dye Methyl Orange (MO) in aqueous solution by nZVI particles. According to the characterization and MO decolorization experiments, the sample with 5:1 HJ clay-supported nZVI (HJ/nZVI) mass ratio (HJ-nZVI5) showed the best dispersion and reactivity and the highest MO decolorization efficiency. With the same equivalent Fe⁰ dosage, the HJ-nZVI1 and HJ-nZVI5 samples demonstrated a synergetic effect for the decolorization of MO: their decolorization efficiencies were much higher than that achieved by physical mixing of HJ clay and nZVIs, or the sum of HJ clay and nZVIs alone. The synergetic effect was primarily due to the improved dispersion and more effective utilization of the nZVI particles on/in the composite materials. Higher decolorization efficiency of MO was obtained at larger HJ-nZVI dosage, higher temperature and under N₂ atmosphere, while the MO initial concentration and pH were negatively correlated to the efficiency. HJ clay not only works as a carrier for nZVI nanoparticles, but also contributes to the decolorization through an “adsorption-enhanced reduction” mechanism. The high efficiency of HJ-nZVI for decontamination gives it great potential for use in a variety of remediation applications.     

高盐度复杂染料废水脱色菌群的降解特性

从天津市市政污泥中筛选出复杂染料脱色菌群,其经16SrDNA基因序列鉴定,主要由Dokdonella（12.26%）、Dyella（10.19%）、Saccharibacteria genera（7.07%）、Rhodobacter（5.80%）、Pseudodoxanthomonas（3.61%）、Flavihumibacter（3.02%）组成.将其用于高盐度复杂染料废水的降解脱色,并研究共代谢基质和各种理化参数对染料废水脱色的影响.结果表明,最佳共代谢基质为葡萄糖和硫酸铵;最佳脱色条件：温度为35℃、pH值为9.0、菌群接种浓度为1.2g/L;在高盐度条件下（50g/L）,菌群能高效脱色复杂染料废水,72h脱色率达到（87.0±2.4）%.经高效液相色谱仪（HP-LC）、傅里叶红外光谱（FT-IR）及气相色谱质谱联用仪（GC-MS）分析,甲基橙首先被迅速降解,分散蓝次之,酸性品红的降解较慢;复杂染料的发色基团（-N=N-,-NH_2,-SO₃）和苯环结构被破坏;其降解产物为苯胺、乙酰胺及2-氨基-5-甲基苯甲酸等.